Icing Condition Predictions Using FBGS

Icing is a hazard which is important for the aerospace industry and which has grown over the last few years. Developing sensors that can detect the existence not only of standard icing conditions with typically small droplet size, but also of Supercooled Large Droplet (SLD) conditions is one of the most important aims in order to minimize icing hazards in the near future. In the present paper a study of the Fiber Bragg Grating Sensors’ (FBGSs) performance as a flight icing detection system that predicts the conditions of an icing cloud is carried out. The test matrix was performed in the INTA Icing Wind Tunnel (IWT) with several icing conditions including SLD. Two optic fibers with 16 FBGS in total were integrated in the lower and upper surface of an airfoil to measure the temperature all over the chord. The results are compared with a Messinger heat and mass balance model and the measurements of the FBGS are used to predict the Liquid Water Content (LWC) and Ice Accretion Rate (IAR). Finally, the results are evaluated and a sensor assessment is made. A good correlation was observed between theoretical calculations and test results obtained with the FBGS in the IWT tests. FBGS proved to detect the beginning and end of ice accretion, LWC and IAR quickly and with good precision.

[1]  The Spalart Allmaras turbulence model , 2010 .

[2]  David N. Anderson,et al.  Manual of Scaling Methods , 2004 .

[3]  F. Morency,et al.  An Experimental Investigation of the Convective Heat Transfer on a Small Helicopter Rotor with Anti-Icing and De-Icing Test Setups , 2021, Aerospace.

[4]  Christoph Chojetzki,et al.  High-mechanical-strength single-pulse draw tower gratings , 2004, Photonics North.

[5]  B. L. Messinger.  Equilibrium Temperature of an Unheated Icing Surface as a Function of Air Speed , 1953 .

[6]  T. Myers.  Extension to the Messinger Model for Aircraft Icing , 2001 .

[7]  R. Stubbe,et al.  Operational load monitoring using optical fibre sensors , 2004 .

[8]  Daniel Betz,et al.  Smart sensing of aviation structures with fiber optic Bragg grating sensors , 2000, Smart Structures.

[9]  H. Herwig,et al.  Laminar Boundary Layers , 1998 .

[10]  William B. Wright,et al.  Comparison of LEWICE and GlennICE in the SLD Regime , 2008 .

[11]  John P. Zarling.  Heat and Mass Transfer from Freely Falling Drops at Low Temperatures , 1980 .

[12]  D. R. Freitag,et al.  Principles of Heat Transfer , 1997 .

[13]  R. Hansman,et al.  Heat transfer on accreting ice surfaces , 1992 .

[14]  Darren G. Jackson,et al.  Ice Detection Systems: A Historical Perspective , 2007 .

[15]  Adrian Ilinca,et al.  Heat and mass transfer during ice accretion on aircraft wings with an improved roughness model , 2006 .

[16]  W. Frost,et al.  Influence of multidroplet size distribution on icing collection efficiency , 1983 .

[17]  Gary A. Ruff,et al.  Users Manual for the NASA Lewis Ice Accretion Prediction Code (LEWICE) , 1990 .

[18]  I. H. Abbott,et al.  Theory of Wing Sections , 1959 .