Characterisation of a hybrid, fuel-cell-based propulsion system for small unmanned aircraft

Abstract Advanced hybrid powerplants combining a fuel cell and battery can enable significantly higher endurance for small, electrically powered unmanned aircraft systems, compared with batteries alone. However, detailed investigations of the static and dynamic performance of such systems are required to address integration challenges. This article describes a series of tests used to characterise the Horizon Energy Systems' AeroStack hybrid, fuel-cell-based powertrain. The results demonstrate that a significant difference can exist between the dynamic performance of the fuel-cell system and its static polarisation curve, confirming the need for detailed measurements. The results also confirm that the AeroStack's lithium-polymer battery plays a crucial role in its response to dynamic load changes and protects the fuel cell from membrane dehydration and fuel starvation. At low static loads, the AeroStack fuel cell recharges the battery with currents up to 1 A, which leads to further differences with the polarisation curve.

[1]  Dimitri N. Mavris,et al.  Development and experimental characterization of a fuel cell powered aircraft , 2007 .

[2]  James Larminie,et al.  Fuel Cell Systems Explained , 2000 .

[3]  Sejin Kwon,et al.  Design and development of a fuel cell-powered small unmanned aircraft , 2012 .

[4]  James Larminie,et al.  Fuel Cell Systems Explained: Larminie/Fuel Cell Systems Explained , 2003 .

[5]  Sungho Chang,et al.  Performance test and simulation of a reciprocating engine for long endurance miniature unmanned aerial vehicles , 2005 .

[6]  F. Philipps,et al.  Dynamic investigation of PEFC stacks in interaction with the air supply system , 2006 .

[7]  Fortunato Migliardini,et al.  Energy management in fuel cell power trains , 2006 .

[8]  Rajesh K. Ahluwalia,et al.  Direct hydrogen fuel cell systems for hybrid vehicles , 2005 .

[9]  K. Agbossou,et al.  Dynamic behavior of a PEM fuel cell stack for stationary applications , 2001 .

[10]  Vincenzo Antonucci,et al.  Batteries analysis for FC-hybrid powertrain optimization , 2008 .

[11]  Christoph Ziegler,et al.  Transient Behavior of a Proton Exchange Membrane Fuel Cell under Dry Operation , 2006 .

[12]  Thomas H. Bradley,et al.  Hardware-in-the-Loop Testing of a Fuel Cell Aircraft Powerplant , 2009 .

[13]  Chao-Yang Wang,et al.  Transient analysis of polymer electrolyte fuel cells , 2005 .

[14]  Q. Cai,et al.  A sizing-design methodology for hybrid fuel cell power systems and its application to an unmanned underwater vehicle , 2010 .

[15]  Aymeric Rousseau,et al.  Fuel economy of hybrid fuel-cell vehicles , 2005 .

[16]  Fortunato Migliardini,et al.  Experimental assessment of energy-management strategies in fuel-cell propulsion systems , 2006 .

[17]  Roger A. Dougal,et al.  Design and experimental tests of control strategies for active hybrid fuel cell/battery power sources , 2004 .

[18]  Fabien Harel,et al.  Design and Validation of a 2 kW‐Fuel Cell Test Bench for Subfreezing Studies , 2008 .

[19]  Mohammad S. Alam,et al.  Improved dynamic performance of hybrid PEM fuel cells and ultracapacitors for portable applications , 2008 .

[20]  E. Pyrgioti,et al.  A simple electric circuit model for proton exchange membrane fuel cells , 2009 .

[21]  Ugo Reggiani,et al.  Modelling a PEM fuel cell stack with a nonlinear equivalent circuit , 2007 .

[22]  C. Bordons,et al.  Development and experimental validation of a PEM fuel cell dynamic model , 2007 .

[23]  Andreas Jossen,et al.  Hybrid systems with lead–acid battery and proton-exchange membrane fuel cell , 2005 .

[24]  Fortunato Migliardini,et al.  PEFC stacks as power sources for hybrid propulsion systems , 2009 .

[25]  Norhisyam Jenal,et al.  Design and Initial Flight Tests of a Hydrogen Fuel Cell Powered Unmanned Air Vehicle (UAV) , 2010 .

[26]  Phatiphat Thounthong,et al.  Energy management of fuel cell/battery/supercapacitor hybrid power source for vehicle applications , 2009 .

[27]  Nigel P. Brandon,et al.  Development and application of an actively controlled hybrid proton exchange membrane fuel cell—Lithium-ion battery laboratory test-bed based on off-the-shelf components , 2011 .

[28]  Michael C. Georgiadis,et al.  Modeling, simulation and experimental validation of a PEM fuel cell system , 2011, Comput. Chem. Eng..

[29]  Phatiphat Thounthong,et al.  Energy management of fuel cell/solar cell/supercapacitor hybrid power source , 2011 .

[30]  Dimitri N. Mavris,et al.  Comparison of Design Methods for Fuel-Cell-Powered Unmanned Aerial Vehicles , 2009 .

[31]  Ohad Gur,et al.  Optimizing Electric Propulsion Systems for Unmanned Aerial Vehicles , 2009 .

[32]  Yong Tang,et al.  Experimental investigation on the dynamic performance of a hybrid PEM fuel cell/battery system for lightweight electric vehicle application , 2011 .

[33]  Michael A. Danzer,et al.  Prevention of fuel cell starvation by model predictive control of pressure, excess ratio, and current , 2009 .

[34]  Kai Sundmacher,et al.  Bistable Current-Voltage Characteristics of PEM Fuel Cells Operated with Reduced Feed Stream Humidification , 2008 .

[35]  M. Y. Ayad,et al.  Comparison of proton exchange membrane fuel cell static models , 2013 .

[36]  Bo-Hwa Lee,et al.  Power managements of a hybrid electric propulsion system for UAVs , 2012 .

[37]  Angkee Sripakagorn,et al.  Experimental assessment of fuel cell/supercapacitor hybrid system for scooters , 2009 .

[38]  Rui Costa Neto,et al.  Thermal and electrical experimental characterisation of a 1 kW PEM fuel cell stack , 2013 .

[39]  Wei-Mon Yan,et al.  Transient behavior of water transport in the membrane of a PEM fuel cell , 2004 .

[40]  Chao-Yang Wang,et al.  Dynamics of polymer electrolyte fuel cells undergoing load changes , 2006 .

[41]  Chunhua Zheng,et al.  Fuel consumption of fuel cell hybrid vehicles considering battery SOC differences , 2012 .

[42]  Sejin Kwon,et al.  Fuel cell system with sodium borohydride as hydrogen source for unmanned aerial vehicles , 2011 .