Ion-selective optical sensor for continuous on-line monitoring of dialysate sodium during dialysis

Patients with end stage renal disease are dependent on dialysis. In most outpatient centers, the dialysate is prepared with a fixed electrolyte concentration without taking into account the inter-individual differences of essential electrolytes (sodium, potassium and calcium). This one-size fits all approach can lead to acute and chronic cardiovascular complications in dialysis patients. On-line monitoring of these essential electrolytes is an important physiological step towards patient specific dialysate leading to individualized treatment. Currently, changes in electrolyte concentrations are indirectly measured by conductivity measurements, which are not ion- specific. In this paper, we present a novel optical sensor for on-line monitoring of sodium concentrations in dialysate. This sensor is ion-specific and can detect up to a single ion. The working principle is based on the selective fluorescence quenching of photo-induced electron transfer (PET) molecules. The PET molecules when complexed with sodium ions start fluorescing upon laser excitation. The emission intensity is directly correlated to the sodium concentration. To prove the working principle, a micro-optofluidic device has been fabricated in polydimethylsiloxane (PDMS) with integrated optical fibers for fluorescence light collection. The PET molecules are covalently grafted in the PDMS microchannel for continuous monitoring of the sodium dialysate concentrations. The experimental setup consists of a laser module (λ=450nm) operating at 4.5mW, a syringe pump to precisely control the sample flow and a spectrometer for fluorescence collection. The performance of the sensor has been evaluated for sodium ions ranging from 0-50mM. A clear signal and good response time was observed.

[1]  I. Leray,et al.  Design principles of fluorescent molecular sensors for cation recognition , 2000 .

[2]  A. P. de Silva,et al.  Fluorescent PET (photoinduced electron transfer) sensors as potent analytical tools. , 2009, The Analyst.

[3]  G. Whitesides,et al.  Rapid Prototyping of Microfluidic Systems in Poly(dimethylsiloxane). , 1998, Analytical chemistry.

[4]  Tanya M. Monro,et al.  Photoinduced Electron Transfer Based Ion Sensing within an Optical Fiber , 2011, Sensors.

[5]  A. P. de Silva,et al.  The development of molecular fluorescent switches. , 2001, Trends in biotechnology.

[6]  S. Michel,et al.  Surface functionalization of silicone rubber for permanent adhesion improvement. , 2008, Langmuir : the ACS journal of surfaces and colloids.

[7]  Terence E. Rice,et al.  Recent evolution of luminescent photoinduced electron transfer sensors. A review , 1996 .

[8]  A Spectroscopic Technique for Local Temperature Measurement in a Micro-Optofluidic System , 2016, IEEE Sensors Journal.

[9]  J. Kooman,et al.  On-line monitoring of electrolytes in hemodialysis: on the road towards individualizing treatment , 2016, Expert review of medical devices.

[10]  F. Gotch,et al.  Preliminary clinical results with sodium-volume modeling of hemodialysis therapy. , 1980, Proceedings of the Clinical Dialysis and Transplant Forum.

[11]  A. P. Silva,et al.  Bright Molecules with Sense, Logic, Numeracy and Utility , 2008 .

[12]  Jin-Woo Choi,et al.  Point-of-care testing (POCT) diagnostic systems using microfluidic lab-on-a-chip technologies , 2015 .

[13]  J. Tusa,et al.  A fluorescent chemosensor for sodium based on photoinduced electron transfer. , 2003, Analytical chemistry.

[14]  C. Basile,et al.  A neglected issue in dialysis practice: haemodialysate , 2015, Clinical kidney journal.

[15]  G. Whitesides,et al.  Soft Lithography. , 1998, Angewandte Chemie.

[16]  B. Palmer,et al.  Individualizing the Dialysate in the Hemodialysis Patient , 2001, Seminars in dialysis.

[17]  J. Kooman,et al.  Creating a wearable artificial kidney: where are we now? , 2015, Expert review of medical devices.

[18]  J. Tusa,et al.  Critical care analyzer with fluorescent optical chemosensors for blood analytes , 2005 .

[19]  A. P. Silva,et al.  Molecular fluorescent signalling with ‘fluor–spacer–receptor’ systems: approaches to sensing and switching devices via supramolecular photophysics , 1992 .