Modeling and measurement of minority-carrier lifetime versus doping in diffused layers of n+-p silicon diodes

The results of minority-carrier lifetime measurements in heavily phosphorus-doped n+diffused layers of p-n junction diodes using a spectral response technique are reported in this paper. Exact modeling of current-flow equations, modified to include bandgap reduction due to high carrier concentration and Auger recombination, is used to compute the dependence of diffused-layer photocurrent Jpthon the incident light energy and intensity. The photocurrent in the diffused layer is also obtained by subtracting the theoretical value of the space charge and uniformly doped p-region component from the experimentally measured photocurrent of the diode at each wavelength. Note that all calculated values based on light intensity include computed transmittance/reflectance through the oxide layer at each wavelength. The comparison of the values of Jpthwith Jpexp, using nonlinear least square techniques, then directly gives the lifetime profile in the diffused layer. A simple expression is given for lifetime as a function of doping which may be used in modeling and prediction of device performance. Using this experimental technique it was found that the lifetime in the diffused layer is an order of magnitude less than that corresponding to uniformly doped bulk-silicon values and is very much process dependent; its value being 3.72 × 10-11s for surface concentration of 3.0 × 1020cm-3and increases to 2.9 × 10-8s at doping concentration of 1.0 × 1017cm-3.

[1]  H. C. de Graaff,et al.  Measurements of bandgap narrowing in Si bipolar transistors , 1976 .

[2]  M. J. D. Powell,et al.  A Method for Minimizing a Sum of Squares of Non-Linear Functions Without Calculating Derivatives , 1965, Comput. J..

[3]  E. Barta.  Optical constants of various heavily doped p- and n-type silicon crystals obtained by Kramers-Kronig analysis , 1977 .

[4]  R. Conradt,et al.  Auger-rekombination in Si , 1973 .

[5]  P. Ostoja,et al.  Relationship between resistivity and phosphorus concentration in silicon , 1974 .

[6]  M.S. Adler,et al.  Measurement of heavy doping parameters in silicon by electron-beam-induced current , 1980, IEEE Transactions on Electron Devices.

[7]  H.C. de Graaff,et al.  Bandgap narrowing in silicon bipolar transistors , 1977, IEEE Transactions on Electron Devices.

[8]  Measurement of carrier lifetime profiles in diffused layers of semiconductors , 1978, IEEE Transactions on Electron Devices.

[9]  Guido Masetti,et al.  Relationship between carrier mobility and electron concentration in silicon heavily doped with phosphorus , 1979 .

[10]  R. E. Thomas,et al.  Carrier mobilities in silicon empirically related to doping and field , 1967 .

[11]  A method for the characterization of p+-n-n+diodes using DC measurements , 1978, IEEE Transactions on Electron Devices.

[12]  Chih-Tang Sah,et al.  A method for determining the emitter and base lifetimes in p-n junction diodes , 1977, IEEE Transactions on Electron Devices.

[13]  N. D. Arora,et al.  Diffusion length determination in p‐n junction diodes and solar cells , 1980 .

[14]  Richard B. Fair,et al.  A Quantitative Model for the Diffusion of Phosphorus in Silicon and the Emitter Dip Effect , 1977 .

[15]  H. R. Philipp,et al.  Optical Constants of Silicon in the Region 1 to 10 ev , 1960 .

[16]  J. Hauser,et al.  Performance limitations of silicon solar cells , 1977, IEEE Transactions on Electron Devices.

[17]  R. Dutton,et al.  Models for computer simulation of complete IC fabrication process , 1979, IEEE Transactions on Electron Devices.

[18]  H.P.D. Lanyon,et al.  Bandgap narrowing in moderately to heavily doped silicon , 1979, IEEE Transactions on Electron Devices.

[19]  D. Roulston,et al.  Spectral response limitation mechanisms of a shallow junction n + -p photodiode , 1978 .

[20]  O. Christensen,et al.  Quantum efficiency of the internal photoelectric effect in silicon and germanium , 1976 .

[21]  D. Roulston,et al.  Spectral response limitation mechanisms of a shallow junction n+-p photodiode , 1978, IEEE Transactions on Electron Devices.

[22]  Raya Mertens,et al.  Transport equations in heavy doped silicon , 1973 .

[23]  J. Dziewior,et al.  Auger coefficients for highly doped and highly excited silicon , 1977 .

[24]  M. A. Shibib,et al.  Heavily doped transparent-emitter regions in junction solar cells, diodes, and transistors , 1979, IEEE Transactions on Electron Devices.

[25]  David J. Roulston,et al.  Simplified computer-aided analysis of double-diffused transistors including two-dimensional high-level effects , 1972 .