Dynamic Effects of Wind Loads on a Gravity Damper

Abstract The gravity damper is safety device used for the air treatment that prevent overpressure inside the unit through the opening. It is a normally closed valve under the effect of the gravity force, which, under the action of the incident air flow, allows to manage any excess mass. Clearly, although the device is rather simple and therefore reliable, the operating conditions may prove burdensome, especially if the gravity dampers are applied to installations of energy transformation, such as the gas turbines; this is mainly due to the need to develop large masses of air at speeds rather incurred. This article describes an experiment carried out on a gravity damper designed to be installed in a gas turbine. The characterization has been performed in numerical (CFD-FEM), considering both the mode shapes and the natural frequencies of the device in working condition as well as any phenomenon of detachment of the fluid that can trigger vortex shedding and subsequently validated in the wind tunnel facilities of the University of Perugia. In particular, what is wanted to be highlighted is the fact that, after a preliminary analysis, it has been clearly evident that, under the operating conditions, the structure would be affected by phenomena of vortex shedding. The shedding frequency is next to some natural frequencies of the structure, with obvious repercussions on the integrity of the structure. An experimental vibration analysis performed in the wind tunnel at flow regime has in fact allowed to identify the phenomenon of lock-in.

[1]  J. Gregory,et al.  Investigation of the cylinder wake under spanwise periodic forcing with a segmented plasma actuator , 2015 .

[2]  Yahya Modarres-Sadeghi,et al.  Monitoring VIV fatigue damage on marine risers , 2009 .

[3]  A. Nakayama,et al.  LES simulation of flow around a bluff body fitted with a splitter plate , 2000 .

[4]  Olivier Flamand,et al.  Conditions for occurrence of vortex shedding on a large cable stayed bridge: Full scale data from monitoring system , 2014 .

[5]  D. Bouris,et al.  2D LES of vortex shedding from a square cylinder , 1999 .

[6]  Yan Yu,et al.  Investigation of vortex-induced vibration of a suspension bridge with two separated steel box girders based on field measurements , 2011 .

[7]  Alberto Zasso,et al.  Vortex shedding from a circular cylinder in a smooth and wired configuration: comparison between 3D LES simulation and experimental analysis , 2000 .

[8]  L. Battisti,et al.  In-field testing of a steel wind turbine tower , 2011 .

[9]  Hayden Marcollo,et al.  On shear flow single mode lock-in with both cross-flow and in-line lock-in mechanisms , 2006 .

[10]  Owen M. Griffin.  A universal Strouhal number for the ‘locking-on’ of vortex shedding to the vibrations of bluff cylinders , 1978 .

[11]  M. W. Sarwar,et al.  Numerical study on suppression of vortex-induced vibrations of box girder bridge section by aerodynamic countermeasures , 2010 .

[12]  Anjaneyulu Krothapalli,et al.  Unsteady flow past an airfoil pitching at a constant rate , 1992 .

[13]  P. Sagaut,et al.  Large Eddy Simulation for Compressible Flows , 2009 .

[14]  G. Kopp,et al.  A numerical study of geometric effects on vortex shedding from elongated bluff bodies , 2012 .

[15]  Toshio Kobayashi.  Large Eddy simulation for engineering applications , 2006 .

[16]  A. Roshko.  Experiments on the flow past a circular cylinder at very high Reynolds number , 1961, Journal of Fluid Mechanics.

[17]  Uwe Starossek,et al.  Wind tunnel test of an active mass damper for bridge decks , 2007 .

[18]  P. Moin,et al.  NUMERICAL SIMULATION OF THE FLOW AROUND A CIRCULAR CYLINDER AT HIGH REYNOLDS NUMBER , 2003 .

[19]  Francesco Ricciardelli,et al.  Effects of the vibration regime on the spanwise correlation of the aerodynamic forces on a 5:1 rectangular cylinder , 2010 .

[20]  D. Favier,et al.  Vortex shedding and lock-on of a circular cylinder in oscillatory flow , 1986, Journal of Fluid Mechanics.

[21]  S. Yen,et al.  Flow patterns and vortex shedding behavior behind a square cylinder , 2011 .

[22]  A. Mochida,et al.  On turbulent vortex shedding flow past 2D square cylinder predicted by CFD , 1995 .

[23]  G. Koopmann,et al.  The vortex-excited resonant vibrations of circular cylinders , 1973 .

[24]  Kenny C. S Kwok,et al.  Wind-induced pressures around a sectional twin-deck bridge model : effects of gap-width on the aerodynamic forces and vortex shedding mechanisms , 2012 .