Modeling of a Solar Driven HD (Humidification-Dehumidification) Desalination System

Abstract The paper presents a computer code developed to simulate the operation of a low-temperature thermally driven desalination system, based on the HD process. The system is a closed air cycle unit and is based on a single-effect humidification/dehumidification technique: heated salt water is introduced into an humidifier to saturate the circulating air and then the water vapor separates in a condensation section, where fresh water production takes place. The modeling procedure allows to investigates the air and water thermodynamic properties across each component. The computer code is able to optimize the heat exchanger surfaces and the air and water mass flow rates, depending on the sea water and the heat source temperature levels. The code was used to analyze an HD desalination unit with fresh water production of about 200 liters per hour, for two different configurations: a direct solar driven scheme, where the salt water entering the HD unit is heated by a solar collector field, and an integrated cooling-desalination system driven by solar energy, where the solar collected heat is used to drive a LiBr absorption machine and then the low-temperature heat rejected by the chiller is exploited to drive the HD process. The simulation code has been integrated into the Trnsys environment to perform a transient simulation of the whole systems. The annual simulations have been carried out on an hourly basis for typical climatic conditions of Abu Dhabi (UAE).

[1]  M. T. Chaibi,et al.  Water desalination by humidification and dehumidification of air: State of the art☆ , 2001 .

[2]  Giuseppe Franchini,et al.  HD desalination by heat rejected from solar cooling systems , 2010, 2010 IEEE International Energy Conference.

[3]  Efat Chafik,et al.  A new seawater desalination process using solar energy , 2003 .

[4]  Giuseppe Franchini,et al.  Combined Solar Heating and Cooling Systems: Simulation and Design Optimization , 2008 .

[5]  Yunfei Dai,et al.  Experimental investigation of a solar desalination unit with humidification and dehumidification , 2000 .

[6]  Nagamany Nirmalakhandan,et al.  Combined desalination and solar-assisted air-conditioning system , 2008 .

[7]  Cemil Yamali,et al.  A solar desalination system using humidification-dehumidification process : experimental study and comparison with the theoretical results , 2008 .

[8]  Mohammed M. Farid,et al.  Solar desalination based on humidification process—I. Evaluating the heat and mass transfer coefficients , 1999 .

[9]  A. Gerlak.  Water , 2013, Ecological Restoration.

[10]  Alberto Picinardi.  Cogeneration of Cooling Energy and Fresh Water , 2012 .

[11]  Imed Houcine,et al.  Pilot plant testing of a new solar desalination process by a multiple-effect-humidification technique , 2006 .

[12]  L. Tadrist,et al.  Experimental investigation of evaporation performances of a desalination prototype using the aero-evapo-condensation process , 1997 .

[13]  K. Bourouni,et al.  Heat transfer and evaporation in geothermal desalination units , 1999 .

[14]  Mohammed M. Farid,et al.  A simulation study to improve the performance of a solar humidification-dehumidification desalination unit constructed in Jordan , 1997 .

[15]  Vasilis Bontozoglou,et al.  Desalination by mechanical compression of humid air , 1999 .

[16]  Mohammed M. Farid,et al.  Solar desalination with a humidification-dehumidification cycle: performance of the unit , 1998 .

[17]  Giuseppe Franchini,et al.  Freshwater and cooling cogeneration by solar energy , 2009 .

[18]  Cherif Bougriou,et al.  Determination of apparent heat transfer coefficient by condensation in an industrial finned-tube heat exchanger: prediction , 2005 .

[19]  Ri-Hua Xiong,et al.  A mathematical model for a thermally coupled humidification–dehumidification desalination process , 2006 .