Spontaneous imbibition of water into oil-wet carbonates

Contrary to sandstone reservoirs, the oil-wetting nature of carbonate reservoirs appears to increase as the reservoir temperature decreases. Thus, a carbonate reservoir at Tres<50 °C containing an oil with an acid number (AN) of about 1 mg KOH/g oil is very likely to behave as oil-wet. If, in addition, the reservoir is fractured with low permeability matrix blocks, water flooding of the reservoir is not recommended unless a wettability alteration process is possible. Normally, the oil recovery from this type of reservoirs by natural pressure depletion is low, and therefore the potential for improved oil recovery (IOR) is very high. The present paper reviews some recent work focused on improved oil recovery from oil-wet carbonates using surface-active chemicals to promote wettability alteration. Water will then spontaneously imbibe into the matrix blocks, and the oil recovery can be markedly increased. The following topics are discussed: • Relative affinities of crude oil components towards carbonates, and how to prepare homogeneous oil-wet cores from water-wet outcrop material; • The wettability alteration mechanism using CTAB, emphasizing ion-pair formation as a key factor; • The relative influence of capillary and gravity forces on the fluid flow during the imbibition process; • The efficiency of commercially available technical products at low price suitable for field applications.

[1]  D. Standnes.  Enhanced Oil Recovery from Oil-Wet Carbonate Rock by Spontaneous Imbibition of Aqueous Surfactant Solutions. , 2001 .

[2]  J. Longo,et al.  Adsorption of organic compounds on carbonate minerals , 1993 .

[3]  F. Orr,et al.  Low IFT drainage and imbibition , 1994 .

[4]  T. Austad,et al.  Chemical flooding of oil reservoirs 7. Oil expulsion by spontaneous imbibition of brine with and without surfactant in mixed-wet, low permeability chalk material , 1996 .

[5]  T. Yen,et al.  Some Notes on Wettability and Relative Permeabilities of Carbonate Reservoir Rocks, II , 1983 .

[6]  Norman R. Morrow,et al.  Recovery of oil by spontaneous imbibition , 2001 .

[7]  J. M. Krafft,et al.  Design of a Steam Pilot In A Fractured Carbonate Reservoir - Qarn Alam Field, Oman , 1995 .

[8]  T. Skauge,et al.  Effects of organic acids and bases, and oil composition on wettability , 1999 .

[9]  Walter G Chapman,et al.  The Effect of Water Dissolution on Oil Viscosity , 1995 .

[10]  F. Kalaydjian,et al.  Oil recovery by imbibition in low-permeability chalk , 1994 .

[11]  D. E. Kenyon,et al.  Laboratory Monitoring of Surfactant Imbibition Using Computerized Tomography , 2000 .

[12]  J. Buckley.  Mechanisms and consequences of wettability alteration by crude oils , 1996 .

[13]  Dag Chun Standnes,et al.  Nontoxic low-cost amines as wettability alteration chemicals in carbonates , 2003 .

[14]  D. Standnes,et al.  Wettability alteration in chalk 1. Preparation of core material and oil properties , 2000 .

[15]  L. Cuiec,et al.  Wettability change related to the adsorption of organic acids on calcite : Experimental and ab initio computational studies , 1998 .

[16]  Dag Chun Standnes,et al.  Wettability alteration in chalk 2. Mechanism for wettability alteration from oil-wet to water-wet using surfactants , 2000 .

[17]  Perry O. Roehl,et al.  Carbonate petroleum reservoirs , 1985 .