Greenhouse microclimate and dehumidification effectiveness under different ventilator configurations

In this paper, the efficiency of two different greenhouse ventilation opening configurations on greenhouse microclimate during dehumidification process with simultaneously heating and ventilation was analysed by means of computational fluid dynamics (CFD) using a commercial program based on the finite volume method. The numerical model was firstly validated against experimental data collected in a tunnel greenhouse identical with the one used in simulations. A good qualitative and quantitative agreement was found between the numerical results and the experimental measurements. The results of the simulations performed for an outside wind direction perpendicular to the greenhouse axis show clearly the influence of ventilation opening configurations on the velocity, temperature and humidity distributions inside the greenhouse. With the first ventilation configuration (roll-up type) maximum air velocity inside the greenhouse was reached in the greenhouse near the ground, with the lowest values observed near the greenhouse roof. As a result, temperature and humidity decreased first near the ground and afterwards in the rest of the greenhouse volume during the dehumidification process. The exactly opposite pattern was observed with the second configuration (pivoting door type). The maximum air velocities were observed near the greenhouse roof where air temperature and humidity were decreased first during the dehumidification process. Energetically the first configuration is proven to be better since the ratio of latent to sensible exchanges during the dehumidification process was higher than the first configuration.

[1]  T. Boulard,et al.  Mean and turbulent air flows and microclimatic patterns in an empty greenhouse tunnel , 2000 .

[2]  G. Bot.  Greenhouse climate: from physical processes to a dynamic model , 1983 .

[3]  C. Kittas,et al.  Quantification du taux d'aération d'une serre à ouvrant continu en toiture , 1995 .

[4]  Antonios Mistriotis,et al.  Numerical estimation of the internal and external aerodynamic coefficients of a tunnel greenhouse structure with openings , 2002 .

[5]  Thierry Boulard,et al.  Simulation of climatic conditions in full-scale greenhouse fitted with insect-proof screens , 2003 .

[6]  Thierry Boulard,et al.  Characterization and Modelling of the Air Fluxes induced by Natural Ventilation in a Greenhouse , 1999 .

[7]  Thierry Boulard,et al.  Effect of Vent Arrangement on Windward Ventilation of a Tunnel Greenhouse , 2004 .

[8]  T. Takakura,et al.  Wind tunnel testing on airflow and temperature distribution of a naturally ventilated greenhouse. , 1984 .

[9]  H. F. de Zwart,et al.  Dehumidification of Greenhouses at Northern Latitudes , 2003 .

[10]  K. E. Cockshull,et al.  Effects of humidity on the growth and flowering of cut-flower chrysanthemums (Dendranthema grandiflora Tzvelev) , 1996 .

[11]  Thierry Boulard,et al.  Numerical simulation of the airflow and temperature distribution in a tunnel greenhouse equipped with insect-proof screen in the openings , 2002 .

[12]  T. W. Davies,et al.  Using CFD to model the internal climate of greenhouses: past, present and future , 2002 .

[13]  Limi Okushima,et al.  A SUPPORT SYSTEM FOR NATURAL VENTILATION DESIGN OF GREENHOUSES BASED ON COMPUTATIONAL AERODYNAMICS , 1989 .

[14]  Leiv M. Mortensen,et al.  Effects of air humidity on growth, flowering, keeping quality and water relations of four short-day greenhouse species. , 2000 .

[15]  Shaojin Wang,et al.  AIRFLOW PATTERNS AND ASSOCIATED VENTILATION FUNCTION IN LARGE-SCALE MULTI-SPAN GREENHOUSES , 1999 .

[16]  J. B Campen,et al.  Determination of greenhouse-specific aspects of ventilation using three-dimensional Computational Fluid Dynamics , 2003 .

[17]  C. Kittas,et al.  Air flow and associated sensible heat exchanges in a naturally ventilated greenhouse , 1997 .

[18]  Thierry Boulard,et al.  SE—Structures and Environment: AirFlows and Temperature Patterns induced in a Confined Greenhouse , 2001 .

[19]  L. M. Mortensen,et al.  Effect of relative humidity on growth and flowering of some greenhouse plants , 1986 .

[20]  Thierry Boulard,et al.  Natural Ventilation and Microclimatic Performance of a Large-scale Banana Greenhouse , 2001 .

[21]  B. Launder,et al.  The numerical computation of turbulent flows , 1990 .

[22]  Shaojin Wang,et al.  Experimental and numerical studies on the heterogeneity of crop transpiration in a plastic tunnel , 2002 .

[23]  Thierry Boulard,et al.  NATURAL VENTILATION BY THERMAL EFFECT IN A ONEHALF SCALE MODEL MONO-SPAN GREENHOUSE , 1998 .

[24]  D. Hand.  EFFECTS OF ATMOSPHERIC HUMIDITY ON GREENHOUSE CROPS , 1988 .

[25]  J. C. Bakker.  Analysis of humidity effects on growth and production of glasshouse fruit vegetables. , 1991 .

[26]  Kjeld Svidt,et al.  Modeling of Air Inlets in CFD Prediction of Airflow in Ventilated Animal Houses , 2002 .

[27]  Pietro Picuno,et al.  Computational analysis of ventilation in greenhouses at zero- and low-wind speeds. , 1997 .

[28]  T. Boulard,et al.  Natural Ventilation of a Greenhouse with Continuous Roof Vents: Measurements and Data Analysis , 1995 .

[29]  L. Mortensen,et al.  Effects of air humidity, lighting period and lamp type on growth and vase life of roses , 1998 .

[30]  Y. Elad,et al.  Effects of air temperature, relative humidity and canopy wetness on gray mold of cucumbers in unheated greenhouses , 1990, Phytoparasitica.

[31]  Y. Elad,et al.  Biological control of Botrytis-incited diseases and powdery mildews in greenhouse crops , 1996 .

[32]  M. Kindelan,et al.  Dynamic Modeling of Greenhouse Environment , 1980 .

[33]  A. J. Udink ten Cate,et al.  A METHOD TO DETERMINE VENTILATION IN GREENHOUSES , 1984 .

[34]  Thierry Boulard,et al.  SIMULATION OF AIR FLUX AND TEMPERATURE PATTERNS IN A LARGE SCALE GREENHOUSE EQUIPPED WITH INSECT PROOF NETS , 2002 .

[35]  Belkacem Draoui,et al.  Quantification of the ventilation of a greenhouse with a roof opening , 1995 .