Ethanol-type fermentation from carbohydrate in high rate acidogenic reactor.

It has been found, in this study, that a new ethanol-type fermentation can be obtained in a continuous flow, high-rate acidogenic reactor receiving molasses as the feed. The operating pH must be maintained at about 4.5 to avoid onset of propionic fermentation. The acidogenic reactor had a VSS level of 20 g/L and its organic loading was as high as 80 to 90 kg COD/m(3) d. The operating ORP was around -250 mV. The ethanol-type fermentation was characterized by a simultaneous production of acetic acid and ethanol, while the yield of propionic was minimal even at a high organic loading rate of 80 to 90 kg COD/m(3) d, and also, the hydrogen partial pressure was as high as 50 kPa. Thus, this study has shown that the production of propionic acid is not always related to high hydrogen partial pressure. When the operating pH was increased to 5.5, the yield of propionic acid became significant.

[1]  P. Rao,et al.  Sorption and leaching of three nonfumigant nematicides in soils , 1985 .

[2]  F. Mosey.  Mathematical Modelling of the Anaerobic Digestion Process: Regulatory Mechanisms for the Formation of Short-Chain Volatile Acids from Glucose , 1983 .

[3]  R. J. Zoetemeyer,et al.  Main characteristics and stoichiometric aspects of acidogenesis of soluble carbohydrate containing wastewaters , 1984 .

[4]  W. Vieth,et al.  Steady‐state and transient behavior in microbial methanification: I. Experimental results , 1985, Biotechnology and bioengineering.

[5]  H. Gijzen,et al.  High‐Rate two‐phase process for the anaerobic degradation of cellulose, employing rumen microorganisms for an efficient acidogenesis , 1988, Biotechnology and bioengineering.

[6]  M. Dohányos,et al.  Production and Utilization of Volatile Fatty Acids in Various Types of Anaerobic Reactors , 1985 .

[7]  J N Lester,et al.  Anaerobic acidogenesis of a complex wastewater: I. The influence of operational parameters on reactor performance , 1988, Biotechnology and bioengineering.

[8]  D. Metzler,et al.  Biochemistry: The Chemical Reactions of Living Cells , 1977 .

[9]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater. 14th edition. , 1976 .

[10]  G. Goma,et al.  Characterization of anaerobic microbial culture with high acidogenic activity , 1981 .

[11]  R. J. Zoetemeyer,et al.  Anaerobic digestion of glucose with separated acid production and methane formation , 1979 .

[12]  D. Roy,et al.  Acidogenesis in the two‐phase anaerobic process , 1985 .

[13]  K. Pinder,et al.  Acidogenic fermentation of lactose , 1987, Biotechnology and bioengineering.