An economic evaluation of phosphorus recovery as struvite from digester supernatant.

Phosphorus can be recovered from wastewater through crystallisation of struvite, MgNH(4)PO(4).6H(2)O. Approximately 1 kg of struvite can be crystallised from 100 m(3) of wastewater. Crystallisation is profitable compared to chemical and biological removal of phosphorus due to savings from the reduction in (i) chemicals used for precipitation and sludge disposal; and (ii) downtime for cleaning unwanted struvite formed during chemical and biological removal. The struvite produced annually from a wastewater treatment plant that processed 100 m3/d, would be sufficient to apply on 2.6 ha of arable land, as fertilizer. If struvite were to be recovered from wastewater treatment plants worldwide, 0.63 million tons of phosphorus (as P(2)O(5)) could be harvested annually, reducing phosphate rock mining by 1.6%. Therefore, this technology could provide opportunities to recover phosphorus sustainably from waste streams and preserve phosphorus reserves.

[1]  Sun-Jin Hwang,et al.  Optimum doses of Mg and P salts for precipitating ammonia into struvite crystals in aerobic composting. , 2005, Bioresource technology.

[2]  N. A. Booker,et al.  Struvite Formation in Wastewater Treatment Plants: Opportunities for Nutrient Recovery , 1999 .

[3]  P. Bishop,et al.  Enhancing struvite crystallization from anaerobic supernatant , 2004 .

[4]  E. V. Münch,et al.  Controlled struvite crystallisation for removing phosphorus from anaerobic digester sidestreams. , 2001, Water research.

[5]  P. Bishop,et al.  A Strategy for Controlling Deposition of Struvite in Municipal Wastewater Treatment Plants , 2005, Water environment research : a research publication of the Water Environment Federation.

[6]  Y. Bashan,et al.  Recent advances in removing phosphorus from wastewater and its future use as fertilizer (1997-2003). , 2004, Water research.

[7]  P. Hobbs,et al.  Prospects for the Recovery of Phosphorus from Animal Manures: A Review , 1999 .

[8]  I. Steen,et al.  Phosphorus availability in the 21st century : Management of a non-renewable resource , 1998 .

[9]  D. Mavinic,et al.  Pilot-scale study of phosphorus recovery through struvite crystallization – II: Applying in-reactor supersaturation ratio as a process control parameter , 2003 .

[10]  Hu Hong-qing,et al.  The effect of direct application of phosphate rock on increasing crop yield and improving properties of red soil , 1996, Nutrient Cycling in Agroecosystems.

[11]  G. A. Momberg,et al.  The Removal of Phosphate by Hydroxyapatite and Struvite Crystallisation in South Africa , 1992 .

[12]  D. R. Raman,et al.  Laboratory and In-Situ Reductions of Soluble Phosphorus in Swine Waste Slurries , 2001, Environmental technology.

[13]  P. Battistoni,et al.  Phosphate removal in anaerobic liquors by struvite crystallization without addition of chemicals: Preliminary results , 1997 .

[14]  I. Steen,et al.  Why Recover Phosphorus for Recycling, and How? , 1999 .

[15]  J. V. Dijk,et al.  Phosphate Removal by Crystallization in a Fluidized Bed , 1985 .

[16]  D. Mavinic,et al.  Preliminary investigation into factors affecting controlled struvite crystallization at the bench scale , 2004 .

[17]  Kazuyoshi Suzuki,et al.  Removal of phosphate, magnesium and calcium from swine wastewater through crystallization enhanced by aeration. , 2002, Water research.

[18]  H. D. Stensel,et al.  Wastewater Engineering: Treatment and Reuse , 2002 .

[19]  M. Kraume,et al.  Enhanced biological phosphorus removal process implemented in membrane bioreactors to improve phosphorous recovery and recycling. , 2003, Water science and technology : a journal of the International Association on Water Pollution Research.

[20]  T. J. Wrigley,et al.  A laboratory study of struvite precipitation after anaerobic digestion of piggery wastes , 1992 .

[21]  J. Ober,et al.  Fertilizers: Sustaining Global Food Supplies , 1999 .

[22]  L. Norton,et al.  Effects of near-surface hydraulic gradients on nitrate and phosphorus losses in surface runoff. , 2004, Journal of environmental quality.

[23]  H. Tsuno,et al.  Removal and recovery of phosphate and ammonium as struvite from supernatant in anaerobic digestion. , 2003, Water science and technology : a journal of the International Association on Water Pollution Research.