Gallium–Indium–Zinc-Oxide-Based Thin-Film Transistors: Influence of the Source/Drain Material

During the last years, oxide semiconductors have shown that they will have a key role in the future of electronics. In fact, several research groups have already presented working devices with remarkable electrical and optical properties based on these materials, mainly thin-film transistors (TFTs). Most of these TFTs use indium-tin oxide (ITO) as the material for source/drain electrodes. This paper focuses on the investigation of different materials to replace ITO in inverted-staggered TFTs based on gallium-indium-zinc oxide (GIZO) semiconductor. The analyzed electrode materials were indium-zinc oxide, Ti, Al, Mo, and Ti/Au, with each of these materials used in two different kinds of devices: one was annealed after GIZO channel deposition but prior to source/drain deposition, and the other was annealed at the end of device production. The results show an improvement on the electrical properties when the annealing is performed at the end (for instance, with Ti/Au electrodes, mobility rises from 19 to 25 cm2/V ldr s, and turn-on voltage drops from 4 to 2 V). Using time-of-flight secondary ion mass spectrometry (TOF-SIMS), we could confirm that some diffusion exists in the source/drain electrodes/semiconductor interface, which is in close agreement with the obtained electrical properties. In addition to TOF-SIMS results for relevant elements, electrical characterization is presented for each kind of device, including the extraction of source/drain series resistances and TFT intrinsic parameters, such as (intrinsic mobility) and VTi (intrinsic threshold voltage).

[1]  Pedro Barquinha,et al.  Influence of the semiconductor thickness on the electrical properties of transparent TFTs based on indium zinc oxide , 2006 .

[2]  R. M. Wolf,et al.  A ferroelectric transparent thin‐film transistor , 1996 .

[3]  Alessandro Carpentiero,et al.  Contact resistance in organic thin film transistors , 2009 .

[4]  E. Fortunato,et al.  Role of order and disorder on the electronic performances of oxide semiconductor thin film transistors , 2007 .

[5]  Randy Hoffman,et al.  Transparent thin-film transistors with zinc indium oxide channel layer , 2005 .

[6]  Jerzy Kanicki,et al.  Performance of thin hydrogenated amorphous silicon thin‐film transistors , 1991 .

[7]  Marco Sampietro,et al.  Modeling of organic thin film transistors: Effect of contact resistances , 2007 .

[8]  E. Fortunato,et al.  Fully Transparent ZnO Thin‐Film Transistor Produced at Room Temperature , 2005 .

[9]  R. McLean,et al.  Transparent ZnO thin-film transistor fabricated by rf magnetron sputtering , 2003 .

[10]  Randy Hoffman,et al.  High mobility transparent thin-film transistors with amorphous zinc tin oxide channel layer , 2005 .

[11]  Randy Hoffman,et al.  High-performance flexible zinc tin oxide field-effect transistors , 2005 .

[12]  Benjamin J. Norris,et al.  ZnO-based transparent thin-film transistors , 2003 .

[13]  Gerold W. Neudeck,et al.  An experimental study of the source/drain parasitic resistance effects in amorphous silicon thin film transistors , 1992 .

[14]  H. Ohta,et al.  Thin-Film Transistor Fabricated in Single-Crystalline Transparent Oxide Semiconductor , 2003, Science.

[15]  Masashi Kawasaki,et al.  High Mobility Thin Film Transistors with Transparent ZnO Channels , 2003 .

[16]  C. Daniel Frisbie,et al.  Potentiometry of an operating organic semiconductor field-effect transistor , 2001 .

[17]  T. Kamiya,et al.  High-mobility thin-film transistor with amorphous InGaZnO4 channel fabricated by room temperature rf-magnetron sputtering , 2006 .

[18]  Thomas N. Jackson,et al.  Contact resistance extraction in pentacene thin film transistors , 2003 .

[19]  Jerzy Kanicki,et al.  Influence of the Amorphous Silicon Thickness on Top Gate Thin-Film Transistor Electrical Performances , 2001 .