An investigation into the effects of thermal history on the crystallisation behaviour of amorphous paracetamol.

The effects of thermal history and sample preparation on the polymorphic transformation profile from amorphous paracetamol have been investigated. The crystallisation behaviour of slow and quench cooled amorphous paracetamol was studied using DSC. Quench cooled paracetamol showed a glass transition (Tg) at 25.2 degrees C, a single exothermic transition at 64.9 degrees C and an endotherm at 167.7 degrees C. The initial degree of crystallinity was calculated as a function of time and recrystallisation circa 20 degrees C below Tg was demonstrated. Slow cooled material in pinholed or hermetic pans (sealed under nitrogen) showed a Tg at 25.1 degrees C, two exothermic transitions at circa 80-85 degrees C and 120-130 degrees C followed by melting at 156.9 degrees C; a single exotherm at 83 degrees C was observed for material sealed in hermetic pans under ambient conditions. Hot stage microscopy yielded complementary information on crystal growth and transformation profile. A transformation scheme is proposed which indicates that amorphous paracetamol may transform into Form III, II or I depending on the thermal history and the gaseous environment in which recrystallisation takes place. The study has demonstrated that the thermal history and encapsulation method may profoundly influence the polymorphic forms generated from amorphous paracetamol.

[1]  W. Ostwald.  Studien über die Bildung und Umwandlung fester Körper , 1897 .

[2]  Shun-Li Wang,et al.  Transformation of metastable forms of acetaminophen studied by thermal Fourier transform infrared (FT-IR) microspectroscopy. , 2002, Chemical & pharmaceutical bulletin.

[3]  M. Drache,et al.  Preparation and physical characterization of forms II and III of paracetamol , 1997 .

[4]  Bruno C. Hancock,et al.  Characteristics and significance of the amorphous state in pharmaceutical systems. , 1997, Journal of pharmaceutical sciences.

[5]  J. Gauchi,et al.  Polymorphism of paracetamol: relative stabilities of the monoclinic and orthorhombic phases inferred from topological pressure-temperature and temperature-volume phase diagrams. , 2005, Journal of pharmaceutical sciences.

[6]  E. Boldyreva,et al.  Effect of High Pressure on the Polymorphs of Paracetamol , 2002 .

[7]  Bruno C. Hancock,et al.  Molecular mobility of amorphous pharmaceuticals determined using differential scanning calorimetry , 2001 .

[8]  Lori R Hilden,et al.  Physics of amorphous solids. , 2004, Journal of pharmaceutical sciences.

[9]  P. Di Martino,et al.  Molecular mobility of the paracetamol amorphous form. , 2000, Chemical & pharmaceutical bulletin.

[10]  E. Boldyreva,et al.  DSC and adiabatic calorimetry study of the polymorphs of paracetamol , 2004 .

[11]  E. Boldyreva,et al.  Anisotropic crystal structure distortion of the monoclinic polymorph of acetaminophen at high hydrostatic pressures. , 2000, Acta crystallographica. Section B, Structural science.

[12]  S Malamataris,et al.  FT-IR and Raman spectroscopic methods for identification and quantitation of orthorhombic and monoclinic paracetamol in powder mixes. , 2002, Journal of pharmaceutical and biomedical analysis.

[13]  Paul F. McMillan,et al.  Relaxation in glassforming liquids and amorphous solids , 2000 .

[14]  J. C. Guyot,et al.  A new pure paracetamol for direct compression : the orthorhombic form. , 1996 .

[15]  Ravi M Shanker,et al.  Dielectric studies of molecular motions in amorphous solid and ultraviscous acetaminophen. , 2005, Journal of pharmaceutical sciences.

[16]  Li-Min Wang,et al.  Fragility and thermodynamics in nonpolymeric glass-forming liquids. , 2006, The Journal of chemical physics.

[17]  L. Carpentier,et al.  Dynamics of the Amorphous and Crystalline α-, γ-Phases of Indomethacin , 2006 .

[18]  B. Ivanova.  Monoclinic and orthorhombic polymorphs of paracetamol—solid state linear dichroic infrared spectral analysis , 2005 .

[19]  G Nichols,et al.  Physicochemical characterization of the orthorhombic polymorph of paracetamol crystallized from solution. , 1998, Journal of pharmaceutical sciences.

[20]  A. Buléon,et al.  Calorimetric analysis of the structural relaxation in partially hydrated amorphous polysaccharides. I. Glass transition and fragility , 2002 .

[21]  D. Capsoni,et al.  Solid-state characterization of paracetamol metastable polymorphs formed in binary mixtures with hydroxypropylmethylcellulose , 2003 .

[22]  Y Aso,et al.  Explanation of the crystallization rate of amorphous nifedipine and phenobarbital from their molecular mobility as measured by (13)C nuclear magnetic resonance relaxation time and the relaxation time obtained from the heating rate dependence of the glass transition temperature. , 2001, Journal of pharmaceutical sciences.

[23]  P. Royall,et al.  The relevance of the amorphous state to pharmaceutical dosage forms: glassy drugs and freeze dried systems. , 1999, International journal of pharmaceutics.

[24]  Elena V. Boldyreva,et al.  High-pressure-induced structural changes in molecular crystals preserving the space group symmetry: anisotropic distortion/isosymmetric polymorphism , 2003 .