Effect of heat-treatment and sample preparation on physical properties of XLPE DC cable insulation material

Power cables with extruded crosslinked polyethylene (XLPE) insulation are used in HVAC and HVDC applications. These cables usually go through a degassing process to remove the methane formed in XLPE during the cross-linking reactions. In case of HVDC cables, the general belief is that the polar peroxide decomposition products (PDP) content significantly influences the conduction and space charge behavior of XLPE. This belief is mainly based on the results of experiments made on thin XLPE samples with different heat-treatments; but since heat-treatment also influences the morphology of the polymer, it is necessary to consider this effect as well. It is common to use polyethylene terephthalate (PET) film as a protective layer during sample press molding. Studies on the influence of the pressing film on the electrical properties of the sample are rare. In this work, the results of a series of experiments performed on 0.5 mm thick XLPE plaque samples in reference to additive free LDPE samples with different heat-treatment times are presented. Beside the PDP content, the morphology, DC conductivity and polarization properties are studied and analyzed. It was found that the pressing film used during sample preparation has a significant effect on the results and if not corrected, it may lead to wrong conclusions about the influence of the PDP content. Eliminating the effect of the pressing film, no clear correlation between the DC conductivity, dielectric loss and the PDP content was observed. The relation between the PDP content and DC conductivity is not found to be obvious, hence this correlation may need to be further evaluated.

[1]  R. N. Hampton,et al.  The role of degassing in XLPE power cable manufacture , 2006, IEEE Electrical Insulation Magazine.

[2]  Nuriziani Hussin,et al.  The effects of crosslinking byproducts on the electrical properties of low density polyethylene , 2011 .

[3]  D. Vesely.  Diffusion of liquids in polymers , 2008 .

[4]  K. Eriksson,et al.  DC TRANSMISSION BASED ON VOLTAGE SOURCE CONVERTERS , 1999 .

[5]  Tingxi Sun,et al.  Investigation on insulation material morphological structure of 110 and 220 kV XLPE retired cables for reusing , 2014, IEEE Transactions on Dielectrics and Electrical Insulation.

[6]  Marc Jeroense,et al.  HVDC Cable Systems—Highlighting Extruded Technology , 2014, IEEE Transactions on Power Delivery.

[7]  H. Ghorbani,et al.  Effect of heat treatment on morphology and dielectric properties of PE cable insulation material , 2017 .

[8]  S. Moyses,et al.  Annealing in Low Density Polyethylene at Several Temperatures , 2004 .

[9]  Jung-Ki Park,et al.  Effects of sample preparation conditions and short chains on space charge formation in LDPE , 1996 .

[10]  H. Ghorbani,et al.  Conductivity measurement of plaque samples obtained from the insulation of high voltage extruded cables , 2017 .

[11]  T. Takada,et al.  Space charge distribution in multi-ply LDPE , 1992, [Proceedings] 1992 Annual Report: Conference on Electrical Insulation and Dielectric Phenomena.

[12]  B. Wunderlich,et al.  Heat capacities of linear high polymers , 1970 .

[13]  Pierre Huldén.  Conductivity measurement on thick insulating plaque samples , 2014 .

[14]  V. Mathot,et al.  Heat capacity, enthalpy and crystallinity of polymers from DSC measurements and determination of the DSC peak base line , 1989 .

[15]  Y. Ohki,et al.  Effects of byproducts of dicumyl peroxide on space charge formation in polyethylene , 2001, ICSD'01. Proceedings of the 20001 IEEE 7th International Conference on Solid Dielectrics (Cat. No.01CH37117).

[16]  A. K. Kelkar,et al.  Degradation and Recyclability of Poly (Ethylene Terephthalate) , 2012 .

[17]  Hossein Ghorbani,et al.  Characterization of Conduction and Polarization Properties of HVDC Cable XLPE Insulation Materials , 2016 .

[18]  T. Mizutani,et al.  Space charge behavior of LDPE with a blocking electrode , 2002, Annual Report Conference on Electrical Insulation and Dielectric Phenomena.

[19]  A. Gray.  Polymer crystallinity determinations by DSC , 1970 .

[20]  George Chen,et al.  Simultaneous space charge and conduction current measurements in solid dielectrics under high dc electric field , 2006 .

[21]  G. Chen,et al.  Heat treatment of cross-linked polyethylene and its effect on morphology and space charge evolution , 2005, IEEE Transactions on Dielectrics and Electrical Insulation.

[22]  V. Mathot.  Temperature dependence of some thermodynamic functions for amorphous and semi-crystalline polymers , 1984 .

[23]  Tanbhir Hoq.  Effect of Heat Treatment on Morphology and Dielectric Properties of Polyethylene , 2014 .