Oxidation of ash-free coal in a direct carbon fuel cell

Abstract The electro-oxidation behaviour of ash-free coal (AFC) was investigated by comparing biomass carbon and conventional hydrogen fuel. A coin-type direct carbon fuel cell (DCFC) based on molten carbonate fuel cell (MCFC) technology was employed. The investigation was carried out into active gas species in the anode, the fuel to carbonate ratio, gasification behaviour, and so on. Electrochemical methods of steady state polarization and step chronopotentiometry were used, and chemical methods, thermogravimetric analysis (TGA), and gas analysis with gas chromatography were also employed. The cells were operated at a fixed temperature of 850 °C, and their conditions were initially checked by hydrogen fuel. The cell performance of AFC was similar to carbon fuel but inferior to H 2 fuel at 150 mA cm −2 . The oxidation of AFC was progressed via the gasification of coal by heat, similar to carbon fuel. But the AFC showed H 2 and CO as major gas species in the anode, a different gas species than carbon fuel which had only CO as a main gas species. In addition, the gasification temperature of AFC was much lower than that of carbon fuel, indicating that the AFC fuel can reduce the operational temperature below that of the carbon fuel, down to at least 700 °C.

[1]  Justin Ruflin,et al.  Direct carbon fuel cell: A proposed hybrid design to improve commercialization potential , 2012 .

[2]  Turgut M. Gür,et al.  Direct carbon conversion in a helium fluidized bed fuel cell , 2008 .

[3]  M.-B. Song,et al.  Carbon Oxidation With Electrically Insulated Carbon Fuel in A Coin Type Direct Carbon Fuel Cell , 2011 .

[4]  Zhonghua Zhu,et al.  A comparative study of different carbon fuels in an electrolyte-supported hybrid direct carbon fuel cell , 2013 .

[5]  J. Selman,et al.  Analysis of the carbon anode in direct carbon conversion fuel cells , 2012 .

[6]  C. Lee.  Overpotential Behavior of Carbon Monoxide Fuel in a Molten Carbonate Fuel Cell , 2012 .

[7]  Alan F. Jankowski,et al.  Direct Conversion of Carbon Fuels in a Molten Carbonate Fuel Cell , 2004 .

[8]  Zongping Shao,et al.  A new carbon fuel cell with high power output by integrating with in situ catalytic reverse Boudouard reaction , 2009 .

[9]  S. Badwal,et al.  Electrochemical performance of ceria-gadolinia electrolyte based direct carbon fuel cells , 2011 .

[10]  D. G. Vutetakis,et al.  Electrochemical Oxidation of Molten Carbonate‐Coal Slurries , 1987 .

[11]  C. Jeon,et al.  Feasibility of using ash-free coal in a solid-oxide-electrolyte direct carbon fuel cell , 2012 .

[12]  Choong-Gon Lee,et al.  Gasification of bamboo carbon with molten alkali carbonates , 2011 .

[13]  Hai-Kyung Seo,et al.  Effect of gas-phase transport in molten carbonate fuel cell , 2003 .

[14]  D. Mckee,et al.  Gasification of graphite in carbon dioxide and water vapor—the catalytic effects of alkali metal salts , 1982 .

[15]  Guiling Wang,et al.  Direct carbon fuel cell: Fundamentals and recent developments , 2007 .

[16]  Hokyung Choi,et al.  Comparative studies on steam gasification of ash-free coals and their original raw coals , 2014 .

[17]  Yixiang Shi,et al.  Performance improvement of direct carbon fuel cell by introducing catalytic gasification process , 2010 .

[18]  M. Ihara,et al.  Reaction Mechanism of Solid Carbon Fuel in Rechargeable Direct Carbon SOFCs with Methane for Charging , 2008 .

[19]  S. Chuang,et al.  Analysis of gas products from direct utilization of carbon in a solid oxide fuel cell , 2012 .

[20]  Qinghua Liu,et al.  A carbon in molten carbonate anode model for a direct carbon fuel cell , 2010 .

[21]  J. Irvine,et al.  Ni/C Slurries Based on Molten Carbonates as a Fuel for Hybrid Direct Carbon Fuel Cells , 2009 .

[22]  Choong-Gon Lee,et al.  Gasification of ash-free coal prepared with microwave method , 2015, Korean Journal of Chemical Engineering.

[23]  M.-B. Song,et al.  Oxidation Behavior of Carbon in a Coin-Type Direct Carbon Fuel Cell , 2011 .

[24]  J. Irvine,et al.  Electrochemical oxidation of solid carbon in hybrid DCFC with solid oxide and molten carbonate binary electrolyte , 2008 .