The cooling performance of a natural draft dry cooling tower under crosswind and an enclosure approach to cooling efficiency enhancement

Abstract Cooling performance of a natural draft dry cooling tower degrades in presence of crosswind. Upon an in service natural draft dry cooling tower of a 660 MW unit in China, a computational fluid dynamics approach with validation is adopted to investigate the cooling performance at various wind speeds. The first order viscous force based resistance mechanism is used in simulating the air flow resistance for the radiators. Numerical results confirm previous findings that the cooling performance of the natural draft dry cooling tower degrades with the increment of wind velocity when wind velocity is higher than 4 m/s, but the performance reduction is relatively less. The circumferential non-uniform ventilation and the vortices inside the tower contribute the most to the degrading of the cooling performance when crosswind is present. To enhance the overall cooling performance, an enclosure with an opening at the windward side is proposed to increase the pressure level outside the side and back radiators. Numerical results show that such an enclosure could enhance the cooling performance at all investigated wind speeds, with 36% increase of the ventilation rate and about 7 °C decrement of the cycling water temperature at 20 m/s.

[1]  John Kaiser Calautit,et al.  A passive cooling wind catcher with heat pipe technology: CFD, wind tunnel and field-test analysis , 2016 .

[2]  Sun Feng-zhong.  Performance evaluation and its comparison of cooling towers before and after the installation of air deflectors , 2009 .

[3]  Zhiqiang Zhai,et al.  Improving cooling efficiency of dry-cooling towers under cross-wind conditions by using wind-break methods , 2006 .

[4]  Victor M. Zavala,et al.  Stochastic optimization approach to water management in cooling-constrained power plants , 2013 .

[5]  Yan Li,et al.  Numerical study on the cooling performance of natural draft dry cooling tower with vertical delta radiators under constant heat load , 2015 .

[6]  K. Ting,et al.  Optimal Reynolds number for the fully developed laminar forced convection in a helical coiled tube , 2006 .

[7]  Giovanna Barigozzi,et al.  Performance prediction and optimization of a waste-to-energy cogeneration plant with combined wet and dry cooling system , 2014 .

[8]  Hal Gurgenci,et al.  Windbreak walls reverse the negative effect of crosswind in short natural draft dry cooling towers into a performance enhancement , 2013 .

[9]  O. Joneydi Shariatzadeh,et al.  Evolution in the Design of V-Shaped Highly Conductive Pathways Embedded in a Heat-Generating Piece , 2015 .

[10]  Masud Behnia,et al.  The performance of natural draft dry cooling towers under crosswind: CFD study , 2004 .

[11]  M. Goodarzi,et al.  Heat rejection enhancement in natural draft cooling tower using radiator-type windbreakers , 2013 .

[12]  Detlev G. Kroger,et al.  Air-cooled heat exchangers and cooling towers : thermal-flow performance evaluation and design , 2004 .

[13]  Lei Chen,et al.  Effects of ambient winds on the thermo-flow performances of indirect dry cooling system in a power plant , 2013 .

[14]  M. Goodarzi,et al.  Alternative geometry for cylindrical natural draft cooling tower with higher cooling efficiency under crosswind condition , 2014 .

[15]  Sadegh Poozesh,et al.  Optimal discrete distribution of heat flux elements for in-tube laminar forced convection , 2013 .

[16]  Hamid Maleki,et al.  Effects of Cu and Ag nano-particles on flow and heat transfer from permeable surfaces , 2015 .

[17]  Giovanna Barigozzi,et al.  Wet and dry cooling systems optimization applied to a modern waste-to-energy cogeneration heat and power plant , 2011 .

[18]  Mohammad Ali Goudarzi.  Proposing a new technique to enhance thermal performance and reduce structural design wind loads for natural drought cooling towers , 2013 .

[19]  Sivakumar Kumaresan,et al.  Effect of cold inflow on chimney height of natural draft cooling towers , 2012 .

[20]  Shengwei Wang,et al.  Design optimization and optimal control of grid-connected and standalone nearly/net zero energy buildings , 2015 .

[21]  Chaoshui Xu,et al.  A simplified coupled hydro-thermal model for enhanced geothermal systems , 2015 .

[22]  Chen You.  Numerical Analysis of the Cooling Performance of Wet Cooling Tower With Cross Wall , 2009 .

[23]  Boyin Zhang,et al.  A study of the unfavorable effects of wind on the cooling efficiency of dry cooling towers , 1995 .

[24]  Pooya Hoseinpoori,et al.  Energy and cost optimization of a plate and fin heat exchanger using genetic algorithm , 2011 .

[25]  Masud Behnia,et al.  The Effect of Windbreak Walls on the Thermal Performance of Natural Draft Dry Cooling Towers , 2005 .

[26]  Guo Fu-min.  Numerical simulation of the indirect air cooling tower layout optimization , 2013 .

[27]  M. Hajmohammadi,et al.  Essential reformulations for optimization of highly conductive inserts embedded into a rectangular chip exposed to a uniform heat flux , 2014 .

[28]  Chechet Biliyok,et al.  Efficiency improvements for the coal-fired power plant retrofit with CO2 capture plant using chilled ammonia process , 2015 .

[29]  M. Goodarzi.  A proposed stack configuration for dry cooling tower to improve cooling efficiency under crosswind , 2010 .

[30]  Xiaoze Du,et al.  Dimensional characteristics of wind effects on the performance of indirect dry cooling system with vertically arranged heat exchanger bundles , 2013 .

[31]  Kenneth E. Torrance,et al.  Experiments on Chimney-Enhanced Free Convection , 1999 .

[32]  Suoying He,et al.  Experimental study of crosswind effects on the performance of small cylindrical natural draft dry cooling towers , 2015 .

[33]  Chi Ming Chu.  Use of Chilton-Colburn Analogy to Estimate Effective Plume Chimney Height of a Forced Draft, Air-Cooled Heat Exchanger , 2006 .

[34]  Shi Yue-tao.  Experimental Study of Cross Walls Effect on the Performance of Wet Cooling Towers , 2012 .

[35]  John Kaiser Calautit,et al.  Comparison between evaporative cooling and a heat pipe assisted thermal loop for a commercial wind tower in hot and dry climatic conditions , 2013 .

[36]  Detlev G. Kröger,et al.  Effect of wind on performance of a dry-cooling tower , 1993 .

[37]  Yang Shanrang.  The Development of Air-cooled power plant technology in China , 2012 .

[38]  P. Kyle,et al.  An integrated assessment of global and regional water demands for electricity generation to 2095 , 2013 .

[39]  Detlev G. Kröger,et al.  Computational Fluid Dynamics Analysis of Cooling Tower Inlets , 2011 .

[40]  Yan Li,et al.  Numerical study on the cooling performance of dry cooling tower with vertical two-pass column radiators under crosswind , 2015 .