Inducing autoflocculation in the diatom Phaeodactylum tricornutum through CO2 regulation

The effect of pH on flocculation was studied using the diatom Phaeodactylum tricornutum and the green algae Scenedesmus cf. obliquus as surrogate species. There was a distinct, species-specific threshold of pH where flocculation started. P. tricornutum started to flocculate at pH 10.5 and S. cf. obliquus at pH 11.3. Above this threshold, settling rates up to 360 cm h−1 were observed for P. tricornutum and the concentrating factor was up to 60-fold. The combined effect of pH, turbulence, and cell density on flocculation of P. tricornutum was additionally studied in a factorial 53-design experiment. pH was the most important factor affecting flocculation, but at the pH threshold (pH 10.5), the concentrating factor was increased by increasing cell density and turbulence. Algae increases the pH during photosynthesis, and the P. tricornutum and S. cf. obliquus cultures increased the pH to a maximum of 10.8 and 9.5, respectively, after discontinuing the CO2 supply. For P. tricornutum, this was above the flocculation threshold, and rapid settling of this species due to increased pH was observed in a matter of hours after the CO2 supply was turned off. This could be used as a simple, low-cost, initial dewatering step for this species.

[1]  J. R. Benemann,et al.  Systems and economic analysis of microalgae ponds for conversion of CO{sub 2} to biomass. Final report , 1996 .

[2]  L. Vråle.  CHEMICAL PRECIPITATION OF WASTEWATER WITH LIME AND SEAWATER , 1979 .

[3]  C. Gudin,et al.  Bioconversion of solar energy into organic chemicals by microalgae , 1986 .

[4]  Q. Luo,et al.  Characteristics of a bioflocculant produced by Bacillus mucilaginosus and its use in starch wastewater treatment , 2002, Applied Microbiology and Biotechnology.

[5]  B. Koopman,et al.  Seawater induced algal flocculation , 1986 .

[6]  L. Aluwihare,et al.  A comparison of the chemical characteristics of oceanic DOM and extracellular DOM produced by marine algae , 1999 .

[7]  A. Sukenik,et al.  Algal autoflocculation—verification and proposed mechanism , 1984, Biotechnology and bioengineering.

[8]  W. Oswald,et al.  Enhanced nutrient removal in high-rate ponds , 1995 .

[9]  R. Guillard,et al.  Culture of Phytoplankton for Feeding Marine Invertebrates , 1975 .

[10]  George M. Ayoub,et al.  High-pH-magnesium coagulation-flocculation in wastewater treatment , 2003 .

[11]  R. Divakaran,et al.  Flocculation of algae using chitosan , 2002, Journal of Applied Phycology.

[12]  Peter J. Ashman,et al.  Microbial flocculation, a potentially low-cost harvesting technique for marine microalgae for the production of biodiesel , 2009, Journal of Applied Phycology.

[13]  Anusuya Willis,et al.  Adhesive modular proteins occur in the extracellular mucilage of the motile, pennate diatom Phaeodactylum tricornutum. , 2006, Biophysical journal.

[14]  K. Spilling.  Dense sub-ice bloom of dinoflagellates in the Baltic Sea, potentially limited by high pH , 2007 .

[15]  W. Smith,et al.  Culture of Marine Invertebrate Animals , 1975, Springer US.

[16]  S. Elmaleh,et al.  Algal flocculation-sedimentation by pH increase in a continuous reactor , 1994 .

[17]  P. Falkowski,et al.  Aquatic Photosynthesis: Second Edition , 1997 .

[18]  J. C. Goldman,et al.  The effect of pH in intensive microalgal cultures. I. Biomass regulation , 1982 .

[19]  J. de la Noüe,et al.  Harvesting of Scenedesmus obliquus in wastewaters: Auto‐ or bioflocculation? , 1987, Biotechnology and bioengineering.

[20]  Y. Chisti,et al.  Recovery of microalgal biomass and metabolites: process options and economics. , 2003, Biotechnology advances.

[21]  Dion Matthew Frederick Frampton,et al.  Production of microalgal concentrates by flocculation and their assessment as aquaculture feeds , 2006 .

[22]  D. Grizeau,et al.  Increased production of eicosapentaenoic acid by Skeletonema costatum cells after decantation at low temperature , 1999 .

[23]  H. Kirchmann,et al.  Increasing the pH of Wastewater to High Levels with Different Gases—CO2 Stripping , 2004 .

[24]  M. Gretz,et al.  DIATOM EXTRACELLULAR POLYMERIC SUBSTANCES: FUNCTION, FINE STRUCTURE, CHEMISTRY, AND PHYSIOLOGY , 1993 .

[25]  P. Henriksen,et al.  High pH and not allelopathy may be responsible for negative effects of Nodularia spumigena on other algae , 2006 .