Assessment of the effectiveness of an industrial unit of mechanical-biological treatment of municipal solid waste.

An assessment of the French municipal solid waste (MSW) mechanical-biological treatment (MBT) unit of Mende was performed in terms of mass reduction, biogas emissions reduction and biostability of the biologically treated waste. The MBT unit consists of mechanical sorting operations, an aerobic rotating bioreactor, forced-aeration process in open-air tunnels (stabilization), ripening platforms and a sanitary landfill site for waste disposal in separated cells. On the overall plant, results showed a dry matter reduction of 18.9% and an oxidative organic matter reduction of 39.0%. A 46.2% biogas production decrease could also be observed. Concerning the biotreatment steps, high reductions were observed: 88.1% decrease of biogas potential and 57.7% decrease of oxidative organic matter content. Nevertheless, the usually considered stabilization indices (biogas potential, respirometric index) remained higher than recommended by the German or Austrian regulation for landfilling. Mass balance performed on each step of the treatment line showed that several stages needed improvement (especially mechanical sorting operations) as several waste fractions containing potentially biodegradable matter were landfilled with very few or no biological treatment.

[1]  Fabrizio Adani,et al.  In search of a reliable technique for the determination of the biological stability of the organic matter in the mechanical-biological treated waste. , 2009, Journal of hazardous materials.

[2]  R Stegmann,et al.  Potential emissions from two mechanically-biologically pretreated (MBT) wastes. , 2009, Waste management.

[3]  Carsten Cuhls,et al.  Green house gas emissions from composting and mechanical biological treatment , 2008, Waste management & research : the journal of the International Solid Wastes and Public Cleansing Association, ISWA.

[4]  J M Tiedje,et al.  General method for determining anaerobic biodegradation potential , 1984, Applied and environmental microbiology.

[5]  Adriana Artola,et al.  A methodology to determine gaseous emissions in a composting plant. , 2009, Waste management.

[6]  William E. Eleazer,et al.  Methane Potential of Food Waste and Anaerobic Toxicity of Leachate Produced During Food Waste Decomposition , 1997 .

[7]  Rainer Wallmann,et al.  Comparison of selected aerobic and anaerobic procedures for MSW treatment. , 2005, Waste management.

[8]  R Lornage,et al.  Performance of a low cost MBT prior to landfilling: study of the biological treatment of size reduced MSW without mechanical sorting. , 2007, Waste management.

[9]  F. Achour.  Caractérisation de la matière organique dans les ordures ménagères : recherche d'indicateurs de stabilité , 2008 .

[10]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[11]  J. M. Owens,et al.  Biochemical Methane Potential of Municipal Solid Waste (MSW) Components , 1993 .

[12]  Teresa Gea,et al.  Comparison of aerobic and anaerobic stability indices through a MSW biological treatment process. , 2008, Waste management.

[13]  T. Hansen,et al.  Method for determination of methane potentials of solid organic waste. , 2004, Waste management.

[14]  Teresa Gea,et al.  Performance of different systems for the composting of the source-selected organic fraction of municipal solid waste , 2008 .

[15]  Matthew R. Allen,et al.  Trace organic compounds in landfill gas at seven U.K. waste disposal sites , 1997 .

[16]  R. Bayard,et al.  Mass balance to assess the efficiency of a mechanical-biological treatment. , 2008, Waste management.

[17]  G Matejka,et al.  Indicating the parameters of the state of degradation of municipal solid waste. , 2006, Journal of hazardous materials.

[18]  I. Angelidaki,et al.  Assessment of the anaerobic biodegradability of macropollutants , 2004 .

[19]  R. P. Beaven,et al.  Sardinia 2005 Tenth International Waste Management and Landfill Symposium , 2005 .

[20]  Fulvia Tambone,et al.  Dynamic respiration index as a descriptor of the biological stability of organic wastes. , 2004, Journal of environmental quality.

[21]  Eric Evans,et al.  Standardized test for evaluation of compost self-heating , 1995 .

[22]  P. Mccarty,et al.  Bioassay for monitoring biochemical methane potential and anaerobic toxicity , 1979 .

[23]  E. Redon,et al.  Fractionation of the organic matter contained in leachate resulting from two modes of landfilling: an indicator of waste degradation. , 2008, Journal of hazardous materials.

[24]  D. Komilis.  A kinetic analysis of solid waste composting at optimal conditions. , 2006, Waste management.

[25]  S T Wagland,et al.  Test methods to aid in the evaluation of the diversion of biodegradable municipal waste (BMW) from landfill. , 2009, Waste management.

[26]  Barbara Scaglia,et al.  An index for quantifying the aerobic reactivity of municipal solid wastes and derived waste products. , 2008, The Science of the total environment.

[27]  J. A. Alburquerque,et al.  Composting of animal manures and chemical criteria for compost maturity assessment. A review. , 2009, Bioresource technology.

[28]  Raffaello Cossu,et al.  Test methods for assessing the biological stability of biodegradable waste. , 2008, Waste management.

[29]  R. Bayard,et al.  Effect of biological pretreatment of coarse MSW on landfill behaviour: laboratory study. , 2008, Water science and technology : a journal of the International Association on Water Pollution Research.

[30]  Antoni Sánchez,et al.  Air filled porosity measurements by air pycnometry in the composting process: a review and a correlation analysis. , 2009, Bioresource technology.

[31]  B. Platt,et al.  Recycling boosts the local economy , 1995 .