Piezoelectric polarization-induced two dimensional electron gases in AlGaN/GaN heteroepitaxial structures: Application for micro-pressure sensors

Abstract The wurtzite group-III nitrides exhibit piezoelectric polarization along their c -axis. Differential piezoelectric and spontaneous polarizations in strained AlGaN/GaN heterostructure grown on [0 0 0 1] sapphire substrates induce two-dimensional electron gas (2DEG) at the AlGaN/GaN hetero-interface. By using a simple two-terminal device in a bending configuration, we demonstrate a linear dependence of the 2DEG channel conductance with applied bending strain. A detailed analysis of the elastic strain distribution in the multilayer structure indicates that the applied strain dependence of the conductance is directly proportional to the electron mobility of 2DEG. Thus, the bending test provides a new technique for measuring the electron mobility in this structure. For a mesa-structure device with a partially relaxed applied strain in the top AlGaN layer, the theory further predicts a reversal in the applied strain dependence of the channel conductance for strain relaxation greater than 15% and this prediction is confirmed by the experiment. Finally, the feasibility of fabricating a micro-pressure sensor using a 150 μm diameter thin flexible AlGaN/GaN circular membrane with an interdigitated-fingers device on a (1 1 1) Si substrate is demonstrated. The measured pressure sensitivity is 0.07 mS/bar.

[1]  Michael S. Shur,et al.  The influence of the strain‐induced electric field on the charge distribution in GaN‐AlN‐GaN structure , 1993 .

[2]  Guan-Ting Chen,et al.  Effect of external strain on the conductivity of AlGaN/GaN high electron mobility transistors , 2003 .

[3]  Lester F. Eastman,et al.  The role of dislocation scattering in n-type GaN films , 1998 .

[4]  John C. Roberts,et al.  Pressure-induced changes in the conductivity of AlGaN∕GaN high-electron mobility-transistor membranes , 2004 .

[5]  R. Dimitrov,et al.  Two dimensional electron gases induced by spontaneous and piezoelectric polarization in undoped and doped AlGaN/GaN heterostructures , 2000 .

[6]  Jenshan Lin,et al.  TOPICAL REVIEW: GaN-based diodes and transistors for chemical, gas, biological and pressure sensing , 2004 .

[7]  Joan M. Redwing,et al.  Piezoelectric charge densities in AlGaN/GaN HFETs , 1997 .

[8]  M. Shur.  Physics of Semiconductor Devices , 1969 .

[9]  Peter M. Asbeck,et al.  Measurement of piezoelectrically induced charge in GaN/AlGaN heterostructure field-effect transistors , 1997 .

[10]  S. Coleman,et al.  A THz transverse electromagnetic mode two-dimensional interconnect layer incorporating quasi-optics , 2003 .

[11]  Lester F. Eastman,et al.  Two-dimensional electron gases in Ga-face and N-face AlGaN/GaN heterostructures grown by plasma-induced molecular beam epitaxy and metalorganic chemical vapor deposition on sapphire , 2000 .

[12]  Lester F. Eastman,et al.  Two-dimensional electron gases induced by spontaneous and piezoelectric polarization charges in N- and Ga-face AlGaN/GaN heterostructures , 1999 .

[13]  T. C. McGill,et al.  GaN Schottky diodes for piezoelectric strain sensing , 2003 .

[14]  Hadis Morkoç,et al.  Valence‐band discontinuities of wurtzite GaN, AlN, and InN heterojunctions measured by x‐ray photoemission spectroscopy , 1996 .