Experimental Study and Genetic-Algorithm-Based Correlation on Pressure Drop and Heat Transfer Performances of a Cross-Corrugated Primary Surface Heat Exchanger

Heat transfer and pressure drop characteristics of a cross-corrugated (CC) primary surface heat exchanger with different CC passages (P/H=2, θ=60 and 120 deg, called CC2-60 and CC2-120, respectively) in two air sides have been experimentally investigated in this study. It is shown that the corrugation angle (θ) and the ratio of the wavelength P to height H (P/H) are the two key parameters of CC passages to influence the heat transfer and flow friction performances. The heat transfer and friction factor correlations for these two configurations are also obtained with Reynolds numbers ranging from Re =450―5500(CC2-60) and Re =570―6700(CC2-120). At a certain P/H, the Nusselt number, Nu, and the friction factor, f, are affected by the corrugation angle, θ. The heat transfer performance of CC2-120 are much better than that of CC2-60 while the pressure drop of the former is higher than that of the latter, especially at high Reynolds numbers region. The critical Reynolds numbers at which the flow mode transits from laminar to turbulent in the two different passages are also estimated. Furthermore, in this study a genetic algorithm (GA) has been used to determine the coefficients of heat transfer correlations by separation of total heat transfer coefficient without any information of measured wall temperatures. It is concluded that the GA-based separated heat transfer Nusselt number provides a good agreement with the experimental data; the averaged relative deviation by GA (1.95%) is lower than that by regression analysis (2.84%). The inversely yielding wall temperatures agree well with the measured data in turn supporting the reliability of experimental system and measurements. It is recommended that GA techniques can be used to handle more complicated problems and to obtain both-side heat transfer correlations simultaneously, where the conventional Wilson-plot method cannot be applied.

[1]  Giulio Croce,et al.  Numerical analysis of forced convection in plate and frame heat exchangers , 2002 .

[2]  Bengt Sundén,et al.  Evaluation of the Cross Corrugated and Some Other Candidate Heat Transfer Surfaces for Microturbine Recuperators , 2002 .

[3]  A. Majumdar,et al.  Monte Carlo Simulation of Silicon Nanowire Thermal Conductivity , 2005 .

[4]  R. M. Manglik,et al.  Enhanced heat transfer due to curvature-induced lateral vortices in laminar flows in sinusoidal corrugated-plate channels , 2004 .

[5]  W. Focke,et al.  The effect of the corrugation inclination angle on the thermohydraulic performance of plate heat exchangers , 1985 .

[6]  Qiuwang Wang,et al.  Heat transfer analysis for shell-and-tube heat exchangers with experimental data by artificial neural networks approach , 2007 .

[7]  V. Kottke,et al.  Comparison of heat and mass transfer in different heat exchanger geometries with corrugated walls , 2002 .

[8]  D. Carroll.  Chemical laser modeling with genetic algorithms , 1996 .

[9]  Colin F. McDonald.  Low-cost compact primary surface recuperator concept for microturbines , 2000 .

[10]  M. Collins,et al.  Investigation of flow and heat transfer in corrugated passages—I. Experimental results , 1996 .

[11]  Raj M. Manglik,et al.  Enhanced Heat Transfer Characteristics of Single-Phase Flows in a Plate Heat Exchanger with Mixed Chevron Plates , 1997 .

[12]  Qiuwang Wang,et al.  Genetic Algorithm Based Design and Optimization of an Outer-Fins and Inner-Fins Tube Heat Exchanger , 2007 .

[13]  Li-Zhi Zhang,et al.  Numerical Study of Periodically Fully Developed Flow and Heat Transfer in Cross-Corrugated Triangular Channels in Transitional Flow Regime , 2005 .

[14]  Mihir Sen,et al.  Heat transfer correlations by symbolic regression , 2006 .

[15]  David E. Goldberg,et al.  Genetic Algorithms in Search Optimization and Machine Learning , 1988 .

[16]  Qiuwang Wang,et al.  Optimization of Compact Heat Exchangers by a Genetic Algorithm , 2008 .

[17]  R. Poulter,et al.  Hydrodynamic and thermal characteristics of corrugated channels : Experimental approach , 2000 .

[18]  Bengt Sundén,et al.  A Comparison of Some Heat Transfer Surfaces for Small Gas Turbine Recuperators , 2001 .

[19]  Gongnan Xie,et al.  Experimental Study and Genetic-Algorithm-Based Correlation on Shell-Side Heat Transfer and Flow Performance of Three Different Types of Shell-and-Tube Heat Exchangers , 2007 .

[20]  Rodney L. McClain,et al.  Heat Rate Predictions in Humid Air-Water Heat Exchangers Using Correlations and Neural Networks , 2001 .

[21]  Li-Zhi Zhang,et al.  Convective mass transport in cross-corrugated membrane exchangers , 2005 .

[22]  Feng Zhenping,et al.  Genetic Algorithm Optimization for Primary Surfaces Recuperator of Microturbine , 2007 .

[23]  M. Collins,et al.  Investigation of flow and heat transfer in corrugated passages—II. Numerical simulations , 1996 .

[24]  Dr. Zbigniew Michalewicz,et al.  How to Solve It: Modern Heuristics , 2004 .

[25]  Simultaneous determination of in- and over-tube heat transfer correlations in heat exchangers by global regression , 2003 .

[26]  Qiuwang Wang,et al.  Application of a Genetic Algorithm for Thermal Design of Fin-and-Tube Heat Exchangers , 2008 .

[27]  R Poulter,et al.  Hydrodynamics and thermal characteristics of corrugated channels: computational approach , 2000 .

[28]  R. M. Manglik,et al.  Experimental Study of Turbulent Flow Heat Transfer and Pressure Drop in a Plate Heat Exchanger With Chevron Plates , 1999 .

[29]  Zbigniew Michalewicz,et al.  Test-case generator for nonlinear continuous parameter optimization techniques , 2000, IEEE Trans. Evol. Comput..

[30]  Nimai Kumar Mitra,et al.  NUMERICAL INVESTIGATION OF FLOW FIELD AND HEAT TRANSFER IN CROSS-CORRUGATED DUCTS , 1999 .

[31]  Paul H. Wright.  Introduction to Engineering , 1994 .

[32]  Hsueh-Chia Chang,et al.  Heat transfer enhancement in three-dimensional corrugated channel flow , 1998 .

[33]  S. P. Venkateshan,et al.  Comparison of Various Methods for Simultaneous Retrieval of Surface Emissivities and Gas Properties in Gray Participating Media , 2006 .