Sub-critical long-term operation of industrial scale hollow-fibre membranes in a submerged anaerobic MBR (HF-SAnMBR) system

Abstract The aim of this study was to evaluate the long-term performance of hollow-fibre (HF) membranes used to treat urban wastewater in a submerged anaerobic MBR when operating sub-critically. To this end, a demonstration plant with two industrial scale HF ultrafiltration membrane modules was operated under different conditions. The main factor affecting membrane performance was the concentration of mixed liquor total solids (MLTS). The reversible fouling rate remained low even when MLTS levels (about 25 g L −1 ) in the membrane tank were high. No chemical cleaning was conducted whilst operating the plant for more than one year because no irreversible fouling problems were detected. The almost complete absence of irreversible fouling was mainly attributed to: operating at sub-critical filtration conditions; establishing a proper membrane operating mode; and to the characteristics of the anaerobic environment. No chemical precipitation problems were observed in the membranes due to the relatively low operating pH (always below 7) of the sludge. The biogas sparging encouraged high levels of dissolved CO 2 in the sludge, resulting in pH levels below 7 and alkalinity values around 600 mg CaCO 3 L −1 .

[1]  V. Jegatheesan,et al.  Assessments of critical flux in a pilot-scale membrane bioreactor. , 2011, Bioresource technology.

[2]  Hongjun Lin,et al.  Influence of elevated pH shocks on the performance of a submerged anaerobic membrane bioreactor , 2010 .

[3]  B. Lewa,et al.  Anaerobic membrane bioreactor ( AnMBR ) for domestic wastewater treatment , 2009 .

[4]  Simon Judd,et al.  Membrane Fouling in Membrane Bioreactors for Wastewater Treatment , 2002 .

[5]  Gatze Lettinga,et al.  High rate sulfate reduction in a submerged anaerobic membrane bioreactor (SAMBaR) at high salinity , 2005 .

[6]  B. Helmreich,et al.  Pilot-scale anaerobic submerged membrane bioreactor (AnSMBR) treating municipal wastewater: the fouling phenomenon and long-term operation. , 2011, Water science and technology : a journal of the International Association on Water Pollution Research.

[7]  J Ferrer,et al.  Sub-critical filtration conditions of commercial hollow-fibre membranes in a submerged anaerobic MBR (HF-SAnMBR) system: the effect of gas sparging intensity. , 2012, Bioresource technology.

[8]  Thomas M. Peters,et al.  Membrane bioreactors in wastewater treatment , 2000 .

[9]  M. Pidou,et al.  Impact of membrane configuration on fouling in anaerobic membrane bioreactors , 2011 .

[10]  José Ferrer,et al.  Struvite precipitation assessment in anaerobic digestion processes , 2008 .

[11]  H. Ng,et al.  Feasibility of submerged anaerobic membrane bioreactor (SAMBR) for treatment of low-strength wastewater. , 2008, Water science and technology : a journal of the International Association on Water Pollution Research.

[12]  A Seco,et al.  A pilot-scale study of struvite precipitation in a stirred tank reactor: conditions influencing the process. , 2008, Bioresource technology.

[13]  S. Judd,et al.  Efficacy of relaxation, backflushing, chemical cleaning and clogging removal for an immersed hollow fibre membrane bioreactor. , 2012, Water research.

[14]  J. Allison,et al.  MINTEQA2/PRODEFA2, a geochemical assessment model for environmental systems: Version 3. 0 user's manual , 1991 .

[15]  D. Jeison,et al.  Cake formation and consolidation: Main factors governing the applicable flux in anaerobic submerged membrane bioreactors (AnSMBR) treating acidified wastewaters , 2007 .

[16]  Steven J Skerlos,et al.  Perspectives on anaerobic membrane bioreactor treatment of domestic wastewater: a critical review. , 2012, Bioresource technology.

[17]  Izzet Ozturk,et al.  Potentials of anaerobic membrane bioreactors to overcome treatment limitations induced by industrial wastewaters. , 2012, Bioresource technology.

[18]  Brigitte Helmreich,et al.  Anaerobic submerged membrane bioreactor (AnSMBR) for municipal wastewater treatment under mesophilic and psychrophilic temperature conditions. , 2011, Bioresource technology.

[19]  J. Lina,et al.  Factors affecting sludge cake formation in a submerged anaerobic membrane bioreactor , 2010 .

[20]  David C. Stuckey,et al.  Treatment of Dilute Wastewaters Using a Novel Submerged Anaerobic Membrane Bioreactor , 2006 .

[21]  G. Oron,et al.  pH effects on the adherence and fouling propensity of extracellular polymeric substances in a membra , 2011 .

[22]  Hongjun Lin,et al.  Sludge properties and their effects on membrane fouling in submerged anaerobic membrane bioreactors (SAnMBRs). , 2009, Water research.

[23]  David M. Bagley,et al.  Anaerobic Membrane Bioreactors: Applications and Research Directions , 2006 .

[24]  Simon Judd,et al.  Criticality of Flux and Aeration for a Hollow Fiber Membrane Bioreactor , 2010 .

[25]  L. Dvořák,et al.  The impact of different operating conditions on membrane fouling and EPS production. , 2011, Bioresource technology.

[26]  David C. Stuckey,et al.  Flux and performance improvement in a submerged anaerobic membrane bioreactor (SAMBR) using powdered activated carbon (PAC) , 2008 .

[27]  Jeonghwan Kim,et al.  Anaerobic treatment of municipal wastewater with a staged anaerobic fluidized membrane bioreactor (SAF-MBR) system. , 2012, Bioresource technology.

[28]  Jeff Penny,et al.  Hollow fiber membrane life in membrane bioreactors (MBR) , 2012 .

[29]  Matthias Wessling,et al.  An improved flux-step method to determine the critical flux and the critical flux for irreversibility in a membrane bioreactor , 2009 .

[30]  Simon Judd,et al.  The MBR Book: Principles and Applications of Membrane Bioreactors for Water and Wastewater Treatment , 2006 .

[31]  B. Helmreich,et al.  Anaerobic submerged membrane bioreactor (AnSMBR) treating low-strength wastewater under psychrophilic temperature conditions , 2012 .

[32]  Pierre Aimar,et al.  Model for colloidal fouling of membranes , 1995 .

[33]  R. Field,et al.  Critical flux concept for microfiltration fouling , 1995 .