Soot formation effects of oxygen concentration in the oxidizer stream of laminar coannular nonpremixed methane/air flames

Abstract This experimental investigation analyzes the soot formation effects of oxygen concentration in the oxidizer stream (O 2 + N 2 ) ventilating laminar jet nonpremixed methane flames. The base flame incorporates air as the oxidizer; two additional flames, with respective oxygen concentrations of 50% and 100% in the ventilating coflow, are also examined. The microstructure of soot collected from selected flame locations is determined combining thermophoretic sampling and transmission electron microscopy. A laser-light extinction technique is employed along with tomographic inversion to measure the soot volume fraction distributions within the three flames. The results indicate that soot surface growth and oxidation rates in the methane/50% oxygen flame are higher compared to the respective rates in the methane/air base flame. The rate of soot inception becomes stronger with increasing oxygen content in the oxidizer stream. Soot yields diminish with increasing oxygen concentration, as do luminous flame spatial dimensions. Soot aggregate data on the soot annulus suggest a higher degree of agglomeration under oxygen-enriched conditions. Finally, the fractal dimensions of selected soot aggregate samples are measured to be 1.64 (methane/air flame) and 1.65 (methane/50% oxygen flame), being similar to previously published values for carbonaceous soot.

[1]  C. Shaddix,et al.  Laser-induced incandescence measurements of soot production in steady and flickering methane, propane, and ethylene diffusion flames , 1996 .

[2]  C. Baukal,et al.  Oxygen-enhanced/natural gas flame radiation , 1997 .

[3]  J. Howard,et al.  Soot control by fuel additives , 1980 .

[4]  G. Faeth,et al.  Effects of Hydrodynamics on Soot Formation in Laminar Opposed-Jet Diffusion Flames , 1996 .

[5]  Christopher R. Shaddix,et al.  The elusive history of m∼= 1.57 – 0.56i for the refractive index of soot , 1996 .

[6]  Takashi Kashiwagi,et al.  Comparisons of the soot volume fraction using gravimetric and light extinction techniques , 1995 .

[7]  Robert J. Santoro,et al.  Soot particle measurements in diffusion flames , 1983 .

[8]  Ian M. Kennedy,et al.  Sooting Counterflow Diffusion Flames with Varying Oxygen Index , 1984 .

[9]  C. Megaridis,et al.  Soot microstructure in steady and flickering laminar methane/air diffusion flames , 1998 .

[10]  P. A. Bonczyk.  Suppression of soot in flames by alkaline-earth and other metal additives , 1988 .

[11]  Christopher R. Shaddix,et al.  Quantitative Measurements of Enhanced Soot Production in a Flickering Methane/Air Diffusion Flame , 1994 .

[12]  Dale W. Schaefer,et al.  Fractal Models and the Structure of Materials , 1988 .

[13]  Henning Bockhorn,et al.  Soot Formation in Combustion: Mechanisms and Models , 1994 .

[14]  C. Dasch,et al.  One-dimensional tomography: a comparison of Abel, onion-peeling, and filtered backprojection methods. , 1992, Applied optics.

[15]  W. Smith,et al.  Density of Carbon Black by Helium Displacement , 1943 .

[16]  C. Smith,et al.  The prediction of laminar jet diffusion flame sizes: Part II. Experimental verification , 1977 .

[17]  R. Axelbaum,et al.  The Effect of Flame Structure on Soot-Particle Inception in Diffusion Flames , 1995 .

[18]  M. Kitano,et al.  Fuel Mixing Effects on Flame Temperature and Soot Formation in Coflow Diffusion Flames , 1996 .

[19]  F. G. Roper.  The prediction of laminar jet diffusion flame sizes: Part I. Theoretical model , 1977 .

[20]  S. Turns.  Introduction to Combustion , 1995, Aerothermodynamics and Jet Propulsion.

[21]  Christopher R. Shaddix,et al.  Computations of enhanced soot production in time-varying CH4/air diffusion flames , 1996 .

[22]  Glassman,et al.  The Effect of Oxygen Concentration on Sooting Diffusion Flames , 1980 .

[23]  Constantine M. Megaridis,et al.  Morphology of flame-generated soot as determined by thermophoretic sampling , 1987 .

[24]  M. Choi,et al.  Measurement of dimensionless soot extinction constant using a gravimetric sampling technique , 1998 .

[25]  C. Sorensen,et al.  In situ optical structure factor measurements of an aggregating soot aerosol , 1988 .

[26]  Effects of the Lewis number of water vapor on the combustion and extinction of methanol drops , 1998 .

[27]  M. Megaridis Constantine,et al.  Comparison of Soot Growth and Oxidation in Smoking and Non–Smoking Ethylene Diffusion Flames , 1989 .

[28]  I. Glassman,et al.  Effect of Oxygen Addition to a Near-Sooting Ethene Inverse Diffusion Flame , 1992 .

[29]  Constantine M. Megaridis,et al.  Morphological Description of Flame-Generated Materials , 1990 .

[30]  F. Beretta,et al.  Optical Investigations on Soot Forming Methane-Oxygen Flames , 1972 .

[31]  C. Sorensen,et al.  Comparison of size and morphology of soot aggregates as determined by light scattering and electron microscope analysis , 1993 .