Total mesorectal excision using a soft and flexible robotic arm: a feasibility study in cadaver models

BackgroundSponsored by the European Commission, the FP7 STIFF-FLOP project aimed at developing a STIFFness controllable Flexible and Learn-able manipulator for surgical operations, in order to overcome the current limitations of rigid-link robotic technology. Herein, we describe the first cadaveric series of total mesorectal excision (TME) using a soft and flexible robotic arm for optic vision in a cadaver model.MethodsTME assisted by the STIFF-FLOP robotic optics was successfully performed in two embalmed male human cadavers. The soft and flexible optic prototype consisted of two modules, each measuring 60 mm in length and 14.3 mm in maximum outer diameter. The robot was attached to a rigid shaft connected to an anthropomorphic manipulator robot arm with six degrees of freedom. The controller device was equipped with two joysticks. The cadavers (BMI 25 and 28 kg/m2) were prepared according to the Thiel embalming method. The procedure was performed using three standard laparoscopic instruments for traction and dissection, with the aid of a 30° rigid optics in the rear for documentation.ResultsFollowing mobilization of the left colonic flexure and division of the inferior mesenteric vessels, TME was completed down to the pelvic floor. The STIFF-FLOP robotic optic arm seemed to acquire superior angles of vision of the surgical field in the pelvis, resulting in an intact mesorectum in both cases. Completion times of the procedures were 165 and 145 min, respectively. No intraoperative complications occurred. No technical failures were registered.ConclusionsThe STIFF-FLOP soft and flexible robotic optic arm proved effective in assisting a laparoscopic TME in human cadavers, with a superior field of vision compared to the standard laparoscopic vision, especially low in the pelvis. The introduction of soft and flexible robotic devices may aid in overcoming the technical challenges of difficult laparoscopic procedures based on standard rigid instruments.

[1]  Wei Wei,et al.  A Compact Two-armed Slave Manipulator for Minimally Invasive Surgery of the Throat , 2006, The First IEEE/RAS-EMBS International Conference on Biomedical Robotics and Biomechatronics, 2006. BioRob 2006..

[2]  Reymond Clavel,et al.  The Lagrange-based model of Delta-4 robot dynamics , 1992, Robotersysteme.

[3]  R. Veldkamp,et al.  Laparoscopic surgery versus open surgery for colon cancer : short-term outcomes of a randomised trial , 2022 .

[4]  J. Fleshman,et al.  A comparison of laparoscopically assisted and open colectomy for colon cancer. , 2004, The New England journal of medicine.

[5]  T. Nanayakkara,et al.  A VARIABLE STIFFNESS JOINT BY GRANULAR JAMMING , 2012 .

[6]  Philip Quirke,et al.  Short-term endpoints of conventional versus laparoscopic-assisted surgery in patients with colorectal cancer (MRC CLASICC trial): multicentre, randomised controlled trial , 2005, The Lancet.

[7]  B. Dousset,et al.  The Clinical Outcome of Surgical Therapy Study Group. A comparison of laparoscopically assisted and open colectomy for colon Cancer. N Engl J Med 2004;350:2050-2059 , 2004 .

[8]  M. Morino,et al.  Laparoscopy for extraperitoneal rectal cancer reduces short-term morbidity: Results of a systematic review and meta-analysis , 2013, United European gastroenterology journal.

[9]  Guang-Zhong Yang,et al.  An articulated universal joint based flexible access robot for minimally invasive surgery , 2011, 2011 IEEE International Conference on Robotics and Automation.

[10]  Daniel S. Miller,et al.  The annual report to the nation on the status of cancer, 1973–1997, with a special section on colorectal cancer , 2000, Cancer.

[11]  Robert J. Webster,et al.  Debulking From Within: A Robotic Steerable Cannula for Intracerebral Hemorrhage Evacuation , 2013, IEEE Transactions on Biomedical Engineering.

[12]  T. Robinson,et al.  Minimally invasive surgery , 1999, European Surgical Research.

[13]  S. C. Low,et al.  Natural orifice transgastric endoscopic wedge hepatic resection in an experimental model using an intuitively controlled master and slave transluminal endoscopic robot (MASTER) , 2010, Surgical Endoscopy.

[14]  Nabil Simaan,et al.  Robotic-assisted micro-surgery of the throat: The trans-nasal approach , 2013, 2013 IEEE International Conference on Robotics and Automation.

[15]  J. Macfarlane,et al.  Rectal cancer: the Basingstoke experience of total mesorectal excision, 1978-1997. , 1998, Archives of surgery.

[16]  R. Juza,et al.  Training current and future robotic surgeons simultaneously: initial experiences with safety and efficiency , 2014, Journal of Robotic Surgery.

[17]  M. Morino,et al.  Laparoscopy for rectal cancer reduces short-term mortality and morbidity: results of a systematic review and meta-analysis , 2013, Surgical Endoscopy.

[18]  Pierre E. Dupont,et al.  Stiffness Control of Surgical Continuum Manipulators , 2011, IEEE Transactions on Robotics.

[19]  Jacob Rosenberg,et al.  A randomized trial of laparoscopic versus open surgery for rectal cancer. , 2015, The New England journal of medicine.

[20]  Kaspar Althoefer,et al.  Design of a variable stiffness flexible manipulator with composite granular jamming and membrane coupling , 2012, 2012 IEEE/RSJ International Conference on Intelligent Robots and Systems.

[21]  S. Bardaro,et al.  Development of advanced endoscopes for Natural Orifice Transluminal Endoscopic Surgery (NOTES) , 2006, Minimally invasive therapy & allied technologies : MITAT : official journal of the Society for Minimally Invasive Therapy.

[22]  Antoni Castells,et al.  Laparoscopy-assisted colectomy versus open colectomy for treatment of non-metastatic colon cancer: a randomised trial , 2002, The Lancet.

[23]  J Dankelman,et al.  Scopes Too Flexible...and Too Stiff , 2010, IEEE Pulse.

[24]  H. Choset,et al.  Highly articulated robotic probe for minimally invasive surgery , 2008, 2008 30th Annual International Conference of the IEEE Engineering in Medicine and Biology Society.

[25]  W. Hop,et al.  Laparoscopic versus open surgery for rectal cancer (COLOR II): short-term outcomes of a randomised, phase 3 trial. , 2013, The Lancet. Oncology.

[26]  Daniel J Sargent,et al.  Effect of Laparoscopic-Assisted Resection vs Open Resection of Stage II or III Rectal Cancer on Pathologic Outcomes: The ACOSOG Z6051 Randomized Clinical Trial. , 2015, JAMA.

[27]  John Simes,et al.  Effect of Laparoscopic-Assisted Resection vs Open Resection on Pathological Outcomes in Rectal Cancer: The ALaCaRT Randomized Clinical Trial. , 2015, JAMA.

[28]  A. Lacy.  Colon cancer: laparoscopic resection. , 2005, Annals of oncology : official journal of the European Society for Medical Oncology.

[29]  Kaspar Althoefer,et al.  Shrinkable, stiffness-controllable soft manipulator based on a bio-inspired antagonistic actuation principle , 2014, 2014 IEEE/RSJ International Conference on Intelligent Robots and Systems.

[30]  Long Wang,et al.  Integration and preliminary evaluation of an Insertable Robotic Effectors Platform for Single Port Access Surgery , 2012, 2012 IEEE International Conference on Robotics and Automation.

[31]  Jaydev P. Desai,et al.  Toward a Meso-Scale SMA-Actuated MRI-Compatible Neurosurgical Robot , 2012, IEEE Transactions on Robotics.

[32]  Robotic transanal endoscopic microsurgery in benign rectal tumour , 2013, Journal of Robotic Surgery.

[33]  Nabil Simaan,et al.  Compliant Motion Control for Multisegment Continuum Robots With Actuation Force Sensing , 2014, IEEE Transactions on Robotics.

[34]  M. Morino,et al.  Laparoscopy for rectal cancer is oncologically adequate: a systematic review and meta-analysis of the literature , 2015, Surgical Endoscopy.

[35]  Arianna Menciassi,et al.  New STIFF-FLOP module construction idea for improved actuation and sensing , 2015, 2015 IEEE International Conference on Robotics and Automation (ICRA).