A method for the calculation of the adsorbed phase volume and pseudo-saturation pressure from adsorption isotherm data on activated carbon.

We propose a new method for evaluating the adsorbed phase volume during physisorption of several gases on activated carbon specimens. We treat the adsorbed phase as another equilibrium phase which satisfies the Gibbs equation and hence assume that the law of rectilinear diameters is applicable. Since invariably the bulk gas phase densities are known along measured isotherms, the constants of the adsorbed phase volume can be regressed from the experimental data. We take the Dubinin-Astakhov isotherm as the model for verifying our hypothesis since it is one of the few equations that accounts for adsorbed phase volume changes. In addition, the pseudo-saturation pressure in the supercritical region is calculated by letting the index of the temperature term in Dubinin's equation to be temperature dependent. Based on over 50 combinations of activated carbons and adsorbates (nitrogen, oxygen, argon, carbon dioxide, hydrocarbons and halocarbon refrigerants) it is observed that the proposed changes fit experimental data quite well.

[1]  F. Dreisbach,et al.  High Pressure Adsorption Data of Methane, Nitrogen, Carbon Dioxide and their Binary and Ternary Mixtures on Activated Carbon , 1999 .

[2]  Ibrahim I. El-Sharkawy,et al.  Evaluation of Adsorption Parameters and Heats of Adsorption through Desorption Measurements , 2007 .

[3]  M. Douglas LeVan,et al.  Transition to Henry’s law in ultra-low concentration adsorption equilibrium for n-pentane on BPL activated carbon , 2008 .

[4]  K. Srinivasan,et al.  Adsorption of 1,1,1,2-Tetrafluoroethane on Activated Charcoal , 2001 .

[5]  K. Ng,et al.  Isotherms and thermodynamics for the adsorption of n-butane on pitch based activated carbon , 2008 .

[6]  Y. Ogino,et al.  Physical adsorption of gases at high pressure. IV. An improvement of the Dubinin—Astakhov adsorption equation , 1976 .

[7]  W. S. Loh,et al.  Adsorption Parameter and Heat of Adsorption of Activated Carbon/HFC-134a Pair , 2010 .

[8]  Ibrahim I. El-Sharkawy,et al.  Adsorption of Equal Mass Fraction Near an Azeotropic Mixture of Pentafluoroethane and 1,1,1-Trifluoroethane on Activated Carbon , 2008 .

[9]  R. Staudt,et al.  A Note on Gravimetric Measurements of Gas-Adsorption Equilibria , 1993 .

[10]  K. Srinivasan,et al.  Thermal modeling of activated carbon based adsorptive natural gas storage system , 2005 .

[11]  P. Harting,et al.  Highest Pressure Adsorption Equilibria Data: Measurement with Magnetic Suspension Balance and Analysis with a New Adsorbent/Adsorbate-Volume , 2002 .

[12]  D. Do,et al.  Adsorption analysis : equilibria and kinetics , 1998 .

[13]  W. S. Loh,et al.  Improved Isotherm Data for Adsorption of Methane on Activated Carbons , 2010 .

[14]  S. H. Kim,et al.  Adsorption equilibria of methane, ethane, ethylene, nitrogen, and hydrogen onto activated carbon , 2003 .

[15]  Yaping Zhou,et al.  Linearization of adsorption isotherms for high-pressure applications , 1998 .

[16]  Ming Li,et al.  Supercritical Methane Adsorption Equilibrium Data on Activated Carbon with Prediction by the Adsorption Potential Theory , 2004 .

[17]  Y. Belmabkhout,et al.  High-pressure adsorption isotherms of N2, CH4, O2, and Ar on different carbonaceous adsorbents , 2004 .

[18]  Li Ming,et al.  Determination of the adsorbate density from supercritical gas adsorption equilibrium data , 2003 .

[19]  Yufeng He,et al.  Adsorption equilibrium of binary methane/ethane mixtures in BPL activated carbon: isotherms and calorimetric heats of adsorption. , 2004, Langmuir : the ACS journal of surfaces and colloids.

[20]  Kim Choon Ng,et al.  Theoretical insight of physical adsorption for a single-component adsorbent+adsorbate system: I. Thermodynamic property surfaces. , 2009, Langmuir : the ACS journal of surfaces and colloids.

[21]  J. A. Schwarz,et al.  A modified approach for estimating pseudo-vapor pressures in the application of the Dubinin-Astakhov equation , 1995 .

[22]  R. L. Robinson,et al.  Adsorption of Methane, Nitrogen, Carbon Dioxide, and Their Binary Mixtures on Dry Activated Carbon at 318.2 K and Pressures up to 13.6 MPa , 2003 .

[23]  D. Do,et al.  Porous Texture Characterization from Gas-Solid Adsorption , 2008 .

[24]  Yaping Zhou,et al.  Determination of the Adsorbed Phase Volume and Its Application in Isotherm Modeling for the Adsorption of Supercritical Nitrogen on Activated Carbon. , 2001, Journal of colloid and interface science.

[25]  D. Do,et al.  Adsorption of supercritical fluids in non-porous and porous carbons: analysis of adsorbed phase volume and density , 2003 .

[26]  Yaping Zhou,et al.  Experimental and Modeling Study of the Adsorption of Supercritical Methane on a High Surface Activated Carbon , 2000 .

[27]  Xiaolin Wang,et al.  Adsorption Measurements of Methane on Activated Carbon in the Temperature Range (281 to 343) K and Pressures to 1.2 MPa , 2010 .

[28]  Adsorption of CO2 on Activated Carbon: Simultaneous Determination of Integral Heat and Isotherm of Adsorption , 1996 .

[29]  M. Dubinin,et al.  The Potential Theory of Adsorption of Gases and Vapors for Adsorbents with Energetically Nonuniform Surfaces. , 1960 .

[30]  G. Weireld,et al.  High-Pressure and High-Temperature Excess Adsorption Isotherms of N2, CH4, and C3H8 on Activated Carbon , 2002 .

[31]  M. Dubinin,et al.  Physical Adsorption of Gases and Vapors in Micropores , 1975 .

[32]  M. McLinden,et al.  NIST Standard Reference Database 23 - NIST Thermodynamic and Transport Properties REFPROP, Version 7.0 , 2002 .

[33]  James A. Schwarz,et al.  Analysis of high pressure adsorption of gases on activated carbon by potential theory , 1988 .

[34]  W. S. Loh,et al.  Experimental Adsorption Isotherm of Methane onto Activated Carbon at Sub- and Supercritical Temperatures , 2010 .

[35]  K. Sing,et al.  Adsorption by Powders and Porous Solids: Principles, Methodology and Applications , 1998 .

[36]  E. A. Guggenheim.  The Principle of Corresponding States , 1945 .

[37]  N. D. Banker,et al.  Performance analysis of activated carbon + HFC-134a adsorption coolers , 2004 .

[38]  K. Srinivasan,et al.  Adsorption of Nitrogen on Activated Carbon-Refit of Experimental Data and Derivation of Properties Required for Design of Equipment , 2009 .