The Impact of Volute Aspect Ratio on the Performance of a Mixed Flow Turbine

Current trends in the automotive industry towards engine downsizing mean turbocharging now plays a vital role in engine performance. A turbocharger increases charge air density using a turbine to extract waste energy from the exhaust gas to drive a compressor. Most turbocharger applications employ a radial inflow turbine. However, mixed flow turbines can offer non-zero blade angles, reducing leading edge (LE) separation at low velocity ratios. The current paper investigates the performance of a mixed flow turbine with three different volute aspect ratio (AR) designs (AR = 0.5, 1 and 2). With constant A/r (ratio of volute area to centroid radius), the AR = 0.5 volute design produced a 4.3% increase in cycle averaged mass flow parameter (MFP) compared to the AR = 2 design. For the purpose of performance comparison, it was necessary to manipulate the volute A/r’s to ensure constant MFP for aerodynamic similarity. With the volute A/r’s manipulated to ensure constant MFP for aerodynamic similarity, the maximum variation of cycle averaged normalized efficiency measured between the designs was 1.47%. Purely in the rotor region, the variation in normalized cycle averaged efficiency was 1%. The smallest tested volute aspect ratio showed a significant increase in volute loss while the ARs of 1 and 2 showed similar levels of loss. The smallest AR volute showed significant secondary flow development in the volute. The resulting variation in LE incidence was found to vary as a result.

[1]  Martin Böhle,et al.  Influence of Degree of Reaction on Turbine Performance for Pulsating Flow Conditions , 2014 .

[2]  Florian R. Menter,et al.  A Scale-Adaptive Simulation Model using Two-Equation Models , 2005 .

[3]  D. Filsinger,et al.  Investigation of the effects of flow conditions at rotor inlet on mixed flow turbine performance for automotive applications , 2016 .

[4]  W. R. Dean,et al.  Note on the motion of fluid in a curved pipe , 1959 .

[5]  Srithar Rajoo,et al.  An investigation of volute cross-sectional shape on turbocharger turbine under pulsating conditions in internal combustion engine , 2015 .

[6]  S. P. Lee,et al.  The influence of secondary flow structures in a turbocharger turbine housing in steady state and pulsating flow conditions , 2016, 2016 7th International Conference on Mechanical and Aerospace Engineering (ICMAE).

[7]  W. R. Dean XVI. Note on the motion of fluid in a curved pipe , 1927 .

[8]  David Japikse,et al.  Introduction to Turbomachinery , 1994 .

[9]  Alister Simpson,et al.  A Comparison of the Flow Structures and Losses Within Vaned and Vaneless Stators for Radial Turbines , 2009 .

[10]  Miloud Abidat,et al.  Prediction of the steady and non-steady flow performance of a highly loaded mixed flow turbine , 1998 .

[11]  N. C. Baines,et al.  Design of a Highly Loaded Mixed Flow Turbine , 1992 .

[12]  Srithar Rajoo,et al.  Mixed Flow Turbine Research: A Review , 2008 .

[13]  Ricardo Martinez-Botas,et al.  The Pulsating Flow Field in a Mixed Flow Turbocharger Turbine: An Experimental and Computational Study , 2004 .

[14]  Mohamed Amine Meghnine,et al.  Influence of the volute cross-sectional shape on mixed inflow turbine performances , 2017 .

[15]  Srithar Rajoo,et al.  Unsteady behaviours of a volute in turbocharger turbine under pulsating conditions , 2017 .

[16]  W. R. Dean LXXII. The stream-line motion of fluid in a curved pipe (Second paper) , 1928 .

[17]  Sergio Hoyas,et al.  Set-Up Analysis and Optimization of CFD Simulations for Radial Turbines , 2013 .

[18]  Ricardo Martinez-Botas,et al.  Mixed Flow Turbines: Inlet and Exit Flow Under Steady and Pulsating Conditions , 2000 .

[19]  Laszlo Fuchs,et al.  Numerical Computation of the Pulsatile Flow in a Turbocharger With Realistic Inflow Conditions From an Exhaust Manifold , 2009 .

[20]  Ricardo Martinez-Botas,et al.  Numerical Study of the Internal Flow Field Characteristics in Mixed Flow Turbines , 2002 .

[21]  Mahfoudh Cerdoun,et al.  Analyses of steady and unsteady flows in a turbocharger’s radial turbine , 2015 .

[22]  Srithar Rajoo,et al.  Influence of Volute Cross-Sectional Shape of a Nozzleless Turbocharger Turbine Under Pulsating Flow Conditions , 2014 .

[23]  Athanasia Kalpakli Vester,et al.  Vortices in turbulent curved pipe flow-rocking, rolling and pulsating motions , 2014 .

[24]  Peter Newton An Experimental and Computational Study of Pulsating Flow within a Double Entry Turbine with Different Nozzle Settings , 2013 .

[25]  John Allport,et al.  Analysis of a tilted turbine housing volute design under pulsating inlet conditions , 2017 .