Upward gas–liquid two-phase flow after a U-bend in a large-diameter serpentine pipe

Abstract We present an experimental study on the flow behaviour of gas and liquid in the upward section of a vertical pipe system with an internal diameter of 101.6 mm and a serpentine geometry. The experimental matrix consists of superficial gas and liquid velocities in ranges of 0.15–30 m/s and from 0.07 to 1.5 m/s, respectively, which cover bubbly to annular flow. The effects on the flow behaviours downstream of the 180° return bend are significantly reduced when the flow reaches an axial distance of 47 pipe diameters from the U-bend. Therefore, reasonably developed flow is attained at this development length downstream of the bend. Other published measurements for large-diameter film thickness show similar trends with respect to the superficial gas velocity. However, the trends differ from those of small-diameter pipes, with which the film thickness decreases much faster with increasing gas flow. As a result, only a few of the published correlations for small pipe data agreed with the experimental data for large pipe film thickness. We therefore modified one of the best-performing correlations, which produced a better fit. Qualitative and statistical analyses show that the new correlation provides improved predictions for two-phase flow film thickness in large-diameter pipes.

[1]  Barry J. Azzopardi,et al.  A Study of Flow Patterns for Gas/Liquid Flow in Small Diameter Tubes , 2007 .

[2]  B. Azzopardi,et al.  Simultaneous Investigation of Entrained Liquid Fraction, Liquid Film Thickness and Pressure Drop in Vertical Annular Flow , 2011 .

[3]  P. Andreussi,et al.  A physically based correlation for drop size in annular flow , 1991 .

[4]  Timothy A. Shedd,et al.  Wave behavior in horizontal annular air–water flow , 2008 .

[5]  Barry J. Azzopardi,et al.  Two-phase air–water flow through a large diameter vertical 180o return bend , 2012 .

[6]  B. Azzopardi,et al.  The effect of pipe diameter on the structure of gas/liquid flow in vertical pipes , 2010 .

[7]  P. Kosky.  Thin liquid films under simultaneous shear and gravity forces , 1971 .

[8]  M. Ishii,et al.  Flow regime transition criteria for upward two-phase flow in vertical tubes , 1984 .

[9]  Uwe Hampel,et al.  Experimental characterization of vertical gas–liquid pipe flow for annular and liquid loading conditions using dual Wire-Mesh Sensor , 2015 .

[10]  M. E. Charles,et al.  Vertical two-phase flow part I. Flow pattern correlations , 1974 .

[11]  M. Ishii,et al.  Film thickness of vertical upward co-current adiabatic flow in pipes , 2015 .

[12]  T. Furukawa,et al.  Prediction of the effects of liquid viscosity on interfacial shear stress and frictional pressure drop in vertical upward gas–liquid annular flow , 1998 .

[13]  G. Hewitt,et al.  Studies of Two-Phase Flow Patterns by Simultaneous X-Ray and Flash Photography , 1969 .

[14]  Thomas J. Hanratty,et al.  Interfacial drag and film height for vertical annular flow , 1985 .

[15]  H. Cheng,et al.  A study of the bubble-to-slug transition in vertical gas-liquid flow in columns of different diameter , 1998 .

[16]  Kataoka Isao,et al.  Drift flux model for large diameter pipe and new correlation for pool void fraction , 1987 .

[17]  Timothy A. Shedd,et al.  Critical friction factor modeling of horizontal annular base film thickness , 2009 .

[18]  A. E. Dukler,et al.  Modelling flow pattern transitions for steady upward gas‐liquid flow in vertical tubes , 1980 .

[19]  R.V.A. Oliemans,et al.  Modelling of annular dispersed two-phase flow in vertical pipes , 1986 .

[20]  Shazia Farman Ali.  Two-phase flow in a large diameter vertical riser , 2009 .

[21]  L. Portela,et al.  Prediction of the interfacial shear-stress in vertical annular flow , 2009 .

[22]  Barry J. Azzopardi,et al.  The characteristics of gas/liquid flow in large risers at high pressures , 2008 .

[23]  H. Prasser,et al.  A new electrode-mesh tomograph for gas–liquid flows , 1998 .

[24]  D. B. Gibbons,et al.  Annular two phase flow in a large diameter tube , 1983 .

[25]  G. F. Hewitt,et al.  THE PREDICTION OF FLOWS IN PRODUCTION RISERS-TRUTH & MYTH ? , 2003 .

[26]  Kamiel S. Gabriel,et al.  A study of annular flow film characteristics in microgravity and hypergravity conditions , 2003 .

[27]  H. Prasser,et al.  Bubble size measurement using wire-mesh sensors , 2001 .

[28]  M. Ishii,et al.  Two-phase flow structure in large diameter pipes , 2012 .

[29]  Hoi Yeung,et al.  Interfacial shear in adiabatic downward gas/liquid co-current annular flow in pipes , 2016 .

[30]  Mohan Kelkar,et al.  Pipe Diameter Effect on Liquid Loading in Vertical Gas Wells , 2013 .

[31]  Eckhard Krepper,et al.  On the modelling of bubbly flow in vertical pipes , 2005 .

[32]  Frank-Peter Weiss,et al.  Evolution of the structure of a gas–liquid two-phase flow in a large vertical pipe , 2007 .

[33]  M. Ishii,et al.  Droplet entrainment correlation in vertical upward co-current annular two-phase flow , 2008 .

[34]  S. Jayanti,et al.  Flow development in vertical annular flow , 2001 .

[35]  Uwe Hampel,et al.  On the effect of liquid viscosity on interfacial structures within churn flow: Experimental study using wire mesh sensor , 2015 .

[36]  Shuichiro Miwa,et al.  Experimental study of two-phase flow structure in large diameter pipes , 2012 .

[37]  Thomas J. Hanratty,et al.  Drop sizes in annular gas‐liquid flows , 1977 .

[38]  Hoi Yeung,et al.  Gas/liquid flow behaviours in a downward section of large diameter vertical serpentine pipes , 2016 .

[39]  Barry J. Azzopardi,et al.  High-resolution gas–oil two-phase flow visualization with a capacitance wire-mesh sensor , 2010 .

[40]  兼康 西川,et al.  環状二相流におけるリップル領域の研究 : 第3報, 気液界面の性状と摩擦係数に及ぼす液粘性の影響 , 1978 .

[41]  Akira Ohnuki,et al.  Experimental study on transition of flow pattern and phase distribution in upward air–water two-phase flow along a large vertical pipe , 2000 .

[42]  Van der Meulen,et al.  Churn-annular gas-liquid flows in large diameter vertical pipes , 2012 .

[43]  Thomas J. Hanratty,et al.  The interfacial drag and the height of the wall layer in annular flows , 1976 .

[44]  R. M. MacGillivray.  Gravity and gas density effects on annular flow average film thickness and frictional pressure drop , 2004 .

[45]  L. Herranz,et al.  Review of droplet entrainment in annular flow: Interfacial waves and onset of entrainment , 2014 .