Numerical study of flow and heat transfer characteristics in hot water stores

Abstract The flow and heat transfer characteristics in a cylindrical hot water store during the charging process under adiabatic thermal boundary conditions were studied numerically in the present paper. The charging efficiency was used to evaluate the thermal stratification. The emphasis was put on the effects of charging temperature differences, charging velocities, charging flow rates and length to diameter ratios on the charging efficiency. The results were summarized both in dimensional and dimensionless forms. They indicate that the charging efficiency depends mainly on the modified Richardson number RiH,f and Peclet number PeH,f, which present the combined effects of charging temperature difference and charging velocity on the charging efficiency. If RiH,f is larger than 0.25, the charging efficiency is above 97%. At a given Richardson number the increase of Peclet number leads to a higher charging efficiency. For H/D less than 4, the increase of the height to diameter ratio H/D can improve the charging efficiency as well. The effect of the Fourier number (or charging flow rate) on the charging efficiency, however, is relatively small. A correlation of the numerical results was obtained for the design of effective hot water stores.

[1]  Y. Jaluria,et al.  Decay of thermal stratification in a water body for solar energy storage , 1982 .

[2]  C. Miller,et al.  An experimental and numerical study on the effect of the wall in a thermocline-type cylindrical enclosure—I Experments , 1982 .

[3]  H. H. Rachford,et al.  The Numerical Solution of Parabolic and Elliptic Differential Equations , 1955 .

[4]  B. J. Sliwinski,et al.  STRATIFICATION IN THERMAL STORAGE DURING CHARGING , 1978 .

[5]  Z. Lavan,et al.  Experimental study of thermally stratified hot water storage tanks , 1977 .

[6]  Hoseon Yoo,et al.  Theoretical model of the charging process for stratified thermal storage tanks , 1993 .

[7]  K. Torrance,et al.  Kinematically consistent velocity fields for hydrodynamic calculations in curvilinear coordinates , 1975 .

[8]  G. Merker,et al.  Advanced numerical computation of two-dimensional time-dependent free convection in cavities , 1980 .

[9]  S. Frankel.  Convergence rates of iterative treatments of partial differential equations , 1950 .

[10]  R. Shyu,et al.  Thermal Analysis of Stratified Storage Tanks , 1989 .

[11]  van J Jacob Berkel,et al.  Mixing in thermally stratified energy stores , 1996 .

[12]  S. Wu,et al.  Numerical Study of Flow and Temperature Stratifications in a Liquid Thermal Storage Tank , 1985 .

[13]  J. Nelson,et al.  Effect of wall conductivity on thermal stratification , 1992 .

[14]  K.G.T. Hollands,et al.  A review of low-flow, stratified-tank solar water heating systems , 1989 .

[15]  A. Cabelli,et al.  Storage tanks: a numerical experiment , 1977 .

[16]  D. Young.  Iterative methods for solving partial difference equations of elliptic type , 1954 .