A low-cost medium-resolution rangefinder based on the self-mixing effect in a VCSEL

This paper focuses on a compact self-aligned noncontact laser rangefinder using a vertical-cavity surface-emitting laser (VCSEL) exposed to optical feedback. By directly modulating the injection current, a number of mode hops occur due to the optical power reinjected in the laser cavity by reflections from the target located in front of the sensor. These reflections are detected by a simple signal processing of the current produced by the monitoring photodiode placed in the same package as the laser. The distance between the target and the laser is proportional to the number of mode hops. Distance measurement can be achieved simply by counting the number of mode hops during a period of the current modulation. The advantage of using a VCSEL over other laser sources is its very low price compared to expensive distributed Bragg reflector (DBR) laser diodes. The resolution obtainable, even if lower than with a DBR source, may, however, be sufficient for most purposes. To our knowledge, it is the first time a VCSEL is used in such a sensor.

[1]  Thierry Bosch,et al.  Real-time parametric estimation of velocity using optical feedback interferometry , 2001, IEEE Trans. Instrum. Meas..

[2]  C. Wieman,et al.  Laser vibrometer based on optical-feedback-induced frequency modulation of a single-mode laser diode. , 1996, Applied optics.

[3]  Thierry M. Bosch,et al.  Self-mixing interference inside a laser diode: application for displacement, velocity, and distance measurement , 1998, Optics & Photonics.

[4]  M. H. Koelink,et al.  Laser Doppler velocimeter based on the self-mixing effect in a fiber-coupled semiconductor laser: theory. , 1992, Applied optics.

[5]  L. Goldberg,et al.  Current-induced frequency modulation in diode lasers , 1982 .

[6]  K. Fritsch,et al.  Remote displacement measurements using a laser diode , 1985 .

[7]  Silvano Donati,et al.  Reconstruction of displacement waveforms with a single-channel laser-diode feedback interferometer , 1997 .

[8]  T. Giallorenzi,et al.  Diode laser sensor , 1980 .

[9]  G. Bourdet,et al.  Absolute distance measurements by CO(2) laser multiwavelength interferometry. , 1979, Applied optics.

[10]  Kohroh Kobayashi,et al.  Tuning ranges for 1.5 μm wavelength tunable DBR lasers , 1988 .

[11]  T. Bosch,et al.  Selected papers on laser distance measurements , 1995 .

[12]  Risto Myllylä,et al.  Imaging distance measurements using TOF lidar , 1998 .

[13]  N. Servagent,et al.  A displacement sensor for spectrum analysis using the optical feedback in a single-mode laser diode , 1997, IEEE Instrumentation and Measurement Technology Conference Sensing, Processing, Networking. IMTC Proceedings.

[14]  Noël Servagent,et al.  Optical feedback effects on the spectral linewidth of semiconductor laser sensors using self-mixing interference , 1998 .

[15]  Daan Lenstra,et al.  Theory of a single-mode laser with weak optical feedback , 1983 .

[16]  Silvano Donati,et al.  Optical feedback interferometry for sensing application , 2001 .

[17]  Silvano Donati,et al.  Applications of diode laser feedback interferometry , 1998 .

[18]  Kenneth T. V. Grattan,et al.  Self-mixing interference inside a single-mode diode laser for optical sensing applications , 1994 .

[19]  Thierry Bosch,et al.  A laser displacement sensor using the self-mixing effect for modal analysis and defect detection , 1997 .

[20]  Eric Gagnon,et al.  Laser range imaging using the self-mixing effect in a laser diode , 1999, IEEE Trans. Instrum. Meas..

[21]  K. Petermann.  Laser Diode Modulation and Noise , 1988 .

[22]  M. Sorel,et al.  A phase-modulated feedback method for testing optical isolators assembled into the laser diode package , 1996, IEEE Photonics Technology Letters.

[23]  M. Camac,et al.  Absolute distance measurements by variable wavelength interferometry. , 1981, Applied optics.

[24]  W. Koechner.  Optical Ranging System Employing a High Power Injection Laser Diode , 1968, IEEE Transactions on Aerospace and Electronic Systems.

[25]  Thierry Bosch,et al.  Distance measurement using the self-mixing effect in a three-electrode distributed Bragg reflector laser diode , 2000 .

[26]  Noël Servagent,et al.  Influence of a weak optical feedback on the spectral characteristics of a semiconductor laser for sensing applications , 1998, Other Conferences.

[27]  Dana Stone Clarke.  The Development of an Optical Triangulation Pipe Profiling Instrument , 1999 .

[28]  B. S. Goldstein,et al.  Gallium arsenide injection laser radar , 1967 .

[29]  Z. Sztankay,et al.  Pulsed GaAs laser terrain profiler , 1977, IEEE Journal of Quantum Electronics.

[30]  S Shinohara,et al.  Simultaneous measurement of velocity and length of moving surfaces by a speckle velocimeter with two self-mixing laser diodes. , 1999, Applied optics.

[31]  G. Beheim,et al.  Range finding using frequency-modulated laser diode. , 1986, Applied optics.

[32]  F. Favre,et al.  Theoretical analysis of external optical feedback on DFB semiconductor lasers , 1987 .

[33]  Silvano Donati,et al.  Synchronization of chaotic injected-laser systems and its application to optical cryptography , 1996 .

[34]  C. W. Gillard,et al.  Progress In Absolute Distance Interferometry , 1982, Astronomical Telescopes and Instrumentation.

[35]  T Suzuki,et al.  Two-wavelength sinusoidal phase/modulating laser-diode interferometer insensitive to external disturbances. , 1991, Applied optics.