Observation of valence band crossing: the thermoelectric properties of CaZn2Sb2–CaMg2Sb2 solid solution

CaAl2Si2 type Zintl phases have long been known to be promising thermoelectric materials. Here we report for the first time on the thermoelectric properties of CaMg2Sb2 along with the transport properties of CaZn2Sb2–CaMg2Sb2 solid solution. The charge carrier tuning in this system was carried out by substituting divalent Ca2+ with monovalent Na+. To check a possible band convergence, we applied an effective mass analysis to our samples and found an abrupt doubling of the samples' effective masses as the composition switches from Zn-rich to Mg-rich. We further analyzed the effect that alloy scattering plays in the lattice thermal conductivity of our samples with a Modified Klemens model. We showed that the reduction seen in the lattice thermal conductivity of the alloyed samples can be well explained based on the mass difference of Mg and Zn in the poly-anionic metal site. Our best p-doped sample with a composition of Ca.99Na.01MgZnSb2 displays a relatively high peak zT of 0.87 at 850 K.

[1]  G. J. Snyder,et al.  Rapid consolidation of powdered materials by induction hot pressing. , 2011, The Review of scientific instruments.

[2]  G. J. Snyder,et al.  Achieving zT > 1 in Inexpensive Zintl Phase Ca9Zn4+xSb9 by Phase Boundary Mapping , 2017 .

[3]  J. Fleurial,et al.  Nonstoichiometry in the Zintl Phase Yb1−δZn2Sb2 as a Route to Thermoelectric Optimization , 2014 .

[4]  Heng Wang,et al.  Thermoelectric alloys between PbSe and PbS with effective thermal conductivity reduction and high figure of merit , 2014 .

[5]  Joseph Callaway,et al.  Effect of Point Imperfections on Lattice Thermal Conductivity , 1960 .

[6]  G. J. Snyder,et al.  Grain boundary dominated charge transport in Mg3Sb2-based compounds , 2018 .

[7]  Zhifeng Ren,et al.  Thermoelectric properties of Na-doped Zintl compound: Mg 3− x Na x Sb 2 , 2015 .

[8]  Anubhav Jain,et al.  Effective mass and Fermi surface complexity factor from ab initio band structure calculations , 2017, npj Computational Materials.

[9]  Paul G. Klemens,et al.  Thermal Resistance due to Point Defects at High Temperatures , 1960 .

[10]  J. Burdett,et al.  Fragment formalism in main-group solids: applications to aluminum boride (AlB2), calcium aluminum silicide (CaAl2Si2), barium-aluminum (BaAl4), and related materials , 1990 .

[11]  G. J. Snyder,et al.  Defect-controlled electronic properties in AZn₂Sb₂ Zintl phases. , 2014, Angewandte Chemie.

[12]  G. J. Snyder,et al.  Zintl phases for thermoelectric devices. , 2007, Dalton transactions.

[13]  Zhiwei Chen,et al.  Vacancy scattering for enhancing the thermoelectric performance of CuGaTe2 solid solutions , 2016 .

[14]  Eric S. Toberer,et al.  Zintl Chemistry for Designing High Efficiency Thermoelectric Materials , 2010 .

[15]  Eric S. Toberer,et al.  Electronic structure and transport in thermoelectric compounds AZn2Sb2 (A = Sr, Ca, Yb, Eu). , 2010, Dalton transactions.

[16]  B. Abeles.  Lattice Thermal Conductivity of Disordered Semiconductor Alloys at High Temperatures , 1963 .

[17]  J. Watling,et al.  A study of the impact of dislocations on the thermoelectric properties of quantum wells in the Si/SiGe materials system , 2011 .

[18]  Heng Wang,et al.  Temperature dependent band gap in PbX (X = S, Se, Te) , 2013 .

[19]  Sossina M. Haile,et al.  Zintl Phases as Thermoelectric Materials: Tuned Transport Properties of the Compounds CaxYb1–xZn2Sb2 , 2005 .

[20]  Heng Wang,et al.  Measuring thermoelectric transport properties of materials , 2015 .

[21]  G. J. Snyder,et al.  Thermoelectric Enhancement in BaGa2Sb2 by Zn Doping , 2015 .

[22]  G. Meisner,et al.  Strain field fluctuation effects on lattice thermal conductivity of ZrNiSn-based thermoelectric compounds , 2004 .

[23]  Stéphane Gorsse,et al.  Microstructure engineering design for thermoelectric materials : an approach to minimize thermal diffusivity , 2010 .

[24]  O. Delaire,et al.  Thermoelectric transport properties of CaMg 2 Bi 2 , EuMg 2 Bi 2 , and YbMg 2 Bi 2 , 2012, 1201.2561.

[25]  G. J. Snyder,et al.  Complex thermoelectric materials. , 2008, Nature materials.

[26]  G. J. Snyder,et al.  Ca3AlSb3: an inexpensive, non-toxic thermoelectric material for waste heat recovery , 2011 .

[27]  Bo B. Iversen,et al.  Simultaneous improvement of power factor and thermal conductivity via Ag doping in p-type Mg3Sb2 thermoelectric materials , 2017 .

[28]  G. J. Snyder,et al.  High Band Degeneracy Contributes to High Thermoelectric Performance in p‐Type Half‐Heusler Compounds , 2014 .

[29]  Z. Ren,et al.  Thermoelectric properties of Bi-based Zintl compounds Ca1−xYbxMg2Bi2 , 2016 .

[30]  K. Berland,et al.  The role of grain boundary scattering in reducing the thermal conductivity of polycrystalline XNiSn (X = Hf, Zr, Ti) half-Heusler alloys , 2017, Scientific Reports.

[31]  David J. Singh,et al.  Thermoelectric properties of AMg2X2, AZn2Sb2 (A = Ca, Sr, Ba; X = Sb, Bi), and Ba2ZnX2 (X = Sb, Bi) Zintl compounds , 2017 .

[32]  Heng Wang,et al.  Convergence of electronic bands for high performance bulk thermoelectrics , 2011, Nature.

[33]  Eric S. Toberer,et al.  Phase Boundary Mapping to Obtain n-type Mg3Sb2-Based Thermoelectrics , 2017 .

[34]  G. J. Snyder,et al.  Grain boundary engineering with nano-scale InSb producing high performance In x Ce y Co 4 Sb 12+z skutterudite thermoelectrics , 2017 .

[35]  Xiangxin Guo,et al.  Enhanced Thermoelectric Figure of Merit of Zintl Phase YbCd2–xMnxSb2 by Chemical Substitution† , 2011 .

[36]  G. J. Snyder,et al.  Lattice Dislocations Enhancing Thermoelectric PbTe in Addition to Band Convergence , 2017, Advanced materials.

[37]  Y. Lan,et al.  Higher thermoelectric performance of Zintl phases (Eu0.5Yb0.5)1−xCaxMg2Bi2 by band engineering and strain fluctuation , 2016, Proceedings of the National Academy of Sciences.

[38]  Hyun-Sik Kim,et al.  High thermoelectric performance in (Bi0.25Sb0.75)2Te3 due to band convergence and improved by carrier concentration control , 2017 .

[39]  G. J. Snyder,et al.  A high temperature apparatus for measurement of the Seebeck coefficient. , 2011, The Review of scientific instruments.

[40]  P. Klemens.  The Scattering of Low-Frequency Lattice Waves by Static Imperfections , 1955 .

[41]  Marco Buongiorno Nardelli,et al.  Convergence of multi-valley bands as the electronic origin of high thermoelectric performance in CoSb3 skutterudites. , 2015, Nature materials.