The use of variable speed drives for cost–effective energy savings in South African mine cooling systems

An industrial energy efficiency improvement through the introduction of modern technology is an important demand-side management initiative. Cooling systems on South African mines have been identified as large electricity consumers. There is significant potential for energy efficiency improvement by the widespread introduction of variable speed drive (VSD) technology. An energy audit was conducted on 20 large mine cooling systems and potential savings and feasibility indicators were calculated. A pilot implementation study was also done on one mine to experimentally validate the estimated savings. In this paper, the results of the audit, the potential savings and the pilot study results are presented. It is shown that large-scale implementation of VSDs on mine cooling system pumps and fans is economically viable. A total annual electrical energy saving of 144,721MWh, or 32.2%, can be achieved. An annual cost saving of US$6,938,148 and CO2 emissions reduction of 132Mton is possible. The implementation of VSDs on mine chiller compressors will also result in large energy savings, but is not economically feasible at present. Results of the pilot study indicate an electricity savings of 29.9%. The results are important to decision makers and indicate the significant impact that widespread VSD usage on mine cooling systems can have on South African mine sustainability.

[1]  Malcolm J. McPherson,et al.  Subsurface Ventilation and Environmental Engineering , 1993 .

[2]  Lijun Zhang,et al.  Optimization of mine ventilation fan speeds according to ventilation on demand and time of use tariff , 2015 .

[3]  R. Carlson.  The correct method of calculating energy savings to justify adjustable frequency drives on pumps , 1999, Industry Applications Society 46th Annual Petroleum and Chemical Technical Conference (Cat.No. 99CH37000).

[4]  H. Crowther,et al.  Optimizing Chillers & Towers , 2004 .

[5]  Aimee McKane,et al.  Assessing the Energy Efficiency Potential of Industrial Motor Systems , 2014 .

[6]  Abraham Jacobus Schutte.  Demand-side energy management of a cascade mine surface refrigeration system , 2007 .

[7]  Edward Henry Mathews,et al.  A versatile energy management system for large integrated cooling systems , 2013 .

[8]  F. W. Yu,et al.  Environmental performance and economic analysis of all-variable speed chiller systems with load-based speed control , 2009 .

[9]  Christopher Swart.  Optimising the operation of underground mine refrigeration plants and ventilation fans for minimum electricity cost , 2003 .

[10]  G. Irvine,et al.  The use of variable frequency drives as a final control element in the petroleum industry , 2000, Conference Record of the 2000 IEEE Industry Applications Conference. Thirty-Fifth IAS Annual Meeting and World Conference on Industrial Applications of Electrical Energy (Cat. No.00CH37129).

[11]  Rahman Saidur,et al.  A review on electrical motors energy use and energy savings , 2010 .

[12]  Muhammad H. Rashid,et al.  Power electronics handbook , 2001 .

[13]  Johanna Johansson.  Intelligent drives on the rise again , 2009 .

[14]  Xiaohua Xia,et al.  Optimal control of operation efficiency of belt conveyor systems , 2010 .

[15]  A. Van der Walt,et al.  Considerations in the design of integrated systems for distributing refrigeration in deep mines , 1978 .

[16]  Leon Liebenberg,et al.  Case study: Energy savings for a deep-mine water reticulation system , 2012 .

[17]  Rahman Saidur,et al.  Developing energy performance standard, label and test procedures and impacts analysis for commercial chillers , 2011 .

[18]  Syed M. Zubair,et al.  Performance analysis of a chilled water system with various pumping schemes , 2012 .

[19]  Roula Inglesi-Lotz,et al.  South Africa’s electricity consumption: A sectoral decomposition analysis , 2011 .

[20]  Pragasen Pillay,et al.  Grappling with a half-hearted policy: The case of renewable energy and the environment in South Africa , 2008 .

[21]  Saad Mekhilef,et al.  Applications of variable speed drive (VSD) in electrical motors energy savings , 2012 .

[22]  Savvas A. Tassou,et al.  VARIABLE-SPEED CAPACITY CONTROL IN REFRIGERATION SYSTEMS , 1996 .

[23]  Paula Fonseca,et al.  Energy-efficient motor systems in the industrial and in the services sectors in the European Union: characterisation, potentials, barriers and policies , 2003 .

[24]  M. Barak,et al.  Energy saving in agricultural buildings through fan motor control by variable frequency drives , 2008 .

[25]  Johannes Van der Bijl.  Sustainable DSM on deep mine refrigeration systems : a novel approach , 2007 .

[26]  Jiangfeng Zhang,et al.  Energy Efficiency and Control Systems–from a POET Perspective , 2010 .

[27]  Syed Mustaffah,et al.  Variable speed drives as energy efficient strategy in pulp and paper industry , 2006 .

[28]  Saad Mekhilef,et al.  A review on energy saving strategies in industrial sector , 2011 .

[29]  Kojo Menyah,et al.  Energy consumption, pollutant emissions and economic growth in South Africa , 2010 .

[30]  Anibal T. de Almeida,et al.  Ecoanalysis of Variable-Speed Drives for Flow Regulation in Pumping Systems , 2011, IEEE Transactions on Industrial Electronics.

[31]  Jukka Tolvanen,et al.  Saving energy with variable speed drives , 2008 .

[32]  Nasrudin Abd Rahim,et al.  A review on compressed-air energy use and energy savings , 2010 .

[33]  Edson da Costa Bortoni.  Are my motors oversized , 2009 .

[34]  H. Amusa,et al.  Aggregate demand for electricity in South Africa: An analysis using the bounds testing approach to cointegration , 2009 .

[35]  Engin Özdemir.  Energy conservation opportunities with a variable speed controller in a boiler house , 2004 .

[36]  G. Dalmaz.  Variable Speed Pumping: A Guide to Successful Applications , 2002 .

[37]  A.G. Jack,et al.  Efficiency trends in electric machines and drives , 2008 .

[38]  D Stephenson,et al.  Distribution of water in deep gold mines in South Africa , 1983 .

[39]  Edward Henry Mathews,et al.  Case study: the effects of a variable flow energy saving strategy on a deep-mine cooling system , 2013 .

[40]  Xiaohua Xia,et al.  Optimal operation scheduling of a pumping station with multiple pumps , 2013 .

[41]  Nasrudin Abd Rahim,et al.  Analysis of electrical motors load factors and energy savings in an Indian cement industry , 2011 .

[42]  Nicholas M. Odhiambo,et al.  Electricity consumption and economic growth in South Africa: A trivariate causality test , 2009 .

[43]  Xiaohua Xia,et al.  Modeling and energy efficiency optimization of belt conveyors , 2011 .

[44]  Nasrudin Abd Rahim,et al.  Energy savings and emissions reductions for rewinding and replacement of industrial motor , 2011 .

[45]  Anibal T. de Almeida,et al.  Induction motor downsizing as a low-cost strategy to save energy , 2012 .

[46]  M. Newborough,et al.  Auditing energy use in cities , 2001 .

[47]  Teuku Meurah Indra Mahlia,et al.  Chillers energy consumption, energy savings and emission analysis in an institutional buildings , 2011 .