An Electrochemical, Low-Frequency Seismic Micro-Sensor Based on MEMS with a Force-Balanced Feedback System

Electrochemical seismic sensors are key components in monitoring ground vibration, which are featured with high performances in the low-frequency domain. However, conventional electrochemical seismic sensors suffer from low repeatability due to limitations in fabrication and limited bandwidth. This paper presents a micro-fabricated electrochemical seismic sensor with a force-balanced negative feedback system, mainly composed of a sensing unit including porous sensing micro electrodes immersed in an electrolyte solution and a feedback unit including a feedback circuit and a feedback magnet. In this study, devices were designed, fabricated, and characterized, producing comparable performances among individual devices. In addition, bandwidths and total harmonic distortions of the proposed devices with and without a negative feedback system were quantified and compared as 0.005–20 (feedback) Hz vs. 0.3–7 Hz (without feedback), 4.34 ± 0.38% (without feedback) vs. 1.81 ± 0.31% (feedback)@1 Hz@1 mm/s and 3.21 ± 0.25% (without feedback) vs. 1.13 ± 0.19% (feedback)@5 Hz@1 mm/s (ndevice = 6, n represents the number of the tested devices), respectively. In addition, the performances of the proposed MEMS electrochemical seismometers with feedback were compared to a commercial electrochemical seismic sensor (CME 6011), producing higher bandwidth (0.005–20 Hz vs. 0.016–30 Hz) and lower self-noise levels (−165.1 ± 6.1 dB vs. −137.7 dB at 0.1 Hz, −151.9 ± 7.5 dB vs. −117.8 dB at 0.02 Hz (ndevice = 6)) in the low-frequency domain. Thus, the proposed device may function as an enabling electrochemical seismometer in the fields requesting seismic monitoring at the ultra-low frequency domain.

[1]  Junbo Wang,et al.  Low Frequency Electrochemical Accelerometer with Low Noise Based on MEMS , 2012 .

[2]  Ezzat G. Bakhoum,et al.  Frequency-Selective Seismic Sensor , 2012, IEEE Transactions on Instrumentation and Measurement.

[3]  Jens Havskov,et al.  Instrumentation in Earthquake Seismology , 2005 .

[4]  Junbo Wang,et al.  A MEMS Based Electrochemical Vibration Sensor for Seismic Motion Monitoring , 2014, Journal of Microelectromechanical Systems.

[5]  Rui Tang,et al.  A micro seismometer based on molecular electronic transducer technology for planetary exploration , 2013 .

[6]  V. A. Chistyakov.  Portable seismic sensor , 2011 .

[7]  Ray M. Hurd,et al.  Principles of Very Low Power Electrochemical Control Devices , 1957 .

[8]  Denis Mougenot,et al.  MEMS-based 3D accelerometers for land seismic acquisition: Is it time? , 2004 .

[9]  Alessandro Bertolini,et al.  Monolithic folded pendulum accelerometers for seismic monitoring and active isolation systems , 2004, IEEE Symposium Conference Record Nuclear Science 2004..

[10]  Thomas M. Daley,et al.  Preseismic velocity changes observed from active source monitoring at the Parkfield SAFOD drill site , 2008, Nature.

[11]  Tsair-Chun Liang,et al.  Fiber optic sensor for detection of ground vibrations , 2012, Asia Pacific Optical Sensors Conference.

[12]  A. F. Wittenborn.  Analysis of a Logarithmic Solion Pressure Detector , 1958 .

[13]  Leszek R. Jaroszewicz,et al.  Usefulness of AFORS—autonomous fibre-optic rotational seismograph for investigation of rotational phenomena , 2012, Journal of Seismology.

[14]  Robert G. Walmsley,et al.  An ultra-low noise MEMS accelerometer for seismic imaging , 2011, 2011 IEEE SENSORS Proceedings.

[15]  Masahiro Kamata.  Front end fidelity for seismic acquisition. , 2011 .

[16]  Guogang Zhang,et al.  Dynamic characteristics of moving-coil geophone with large damping , 2010 .

[17]  Robert R. Stewart,et al.  Field data comparisons of MEMS accelerometers and analog geophones , 2008 .

[18]  D. G. Levchenko,et al.  Experience in seismic signal recording using broadband electrochemical seismic sensors , 2010 .

[19]  J. Schweizer,et al.  Monitoring avalanche activity using a seismic sensor , 2011 .

[20]  C. W. Larkam.  Theoretical Analysis of the Solion Polarized Cathode Acoustic Linear Transducer , 1965 .

[21]  Junbo Wang,et al.  A MEMS based electrochemical seismometer with a novel integrated sensing unit , 2016, 2016 IEEE 29th International Conference on Micro Electro Mechanical Systems (MEMS).

[22]  William C. Richie,et al.  Solion Infrasonic Microphone , 1963 .

[23]  J. Chen,et al.  Extending upper cutoff frequency of electrochemical seismometer by using extremely thin Su8 insulating spacers , 2013, 2013 IEEE SENSORS.