Influence of GaN cap on robustness of AlGaN/GaN HEMTs

DC-Step-Stress-Tests of GaN HEMTs have been performed on wafers with and without GaN-cap. The tests consist of a step ramping of drain-source voltage VDS by 5V every two hours at off-state. The irreversible evolution of leakage current starting at a certain drain voltage has been taken as a criterion for the onset of device degradation. It has been stated that there is a stability limit for VDS depending on the epitaxial design. It has been found that wafers with GaN cap show much higher critical voltages as compared to non-capped epitaxial designs. Electroluminescence measurements have been performed to localize defects after DC-Step-Stress-Tests up to 80V for wafer without GaN cap and 120V for wafer with GaN cap.

[1]  G. P. Li,et al.  Electroluminescence characteristics of GaN HEMT at off-state , 2008 .

[2]  Tangali S. Sudarshan,et al.  Prebreakdown and breakdown effects in AlGaN/GaN heterostructure field effect transistors , 1998 .

[3]  Hiroshi Ito,et al.  High-energy and recombination-induced electroluminescence of InAlAs/InGaAs HEMT's lattice-matched to InP substrates , 1997 .

[4]  Takada Yoshiharu,et al.  Reliability Study of AlGaN/GaN HEMTs Device , 2007 .

[5]  G. Pataut,et al.  Study of passivation defects by electroluminescence in AlGaN/GaN HEMTS on SiC , 2007, Microelectron. Reliab..

[6]  J. Wurfl,et al.  Punchthrough-Voltage Enhancement of AlGaN/GaN HEMTs Using AlGaN Double-Heterojunction Confinement , 2008, IEEE Transactions on Electron Devices.

[7]  R. Gaddi,et al.  Electroluminescence analysis of HFET's breakdown , 1999, IEEE Electron Device Letters.

[8]  Tetsuya Suemitsu,et al.  Electroluminescence characterization of AlGaN/GaN high-electron-mobility transistors , 2001 .

[9]  G. Martel,et al.  Preliminary reliability assessment and failure physical analysis on AlGaN/GaN HEMTs COTS , 2007, Microelectron. Reliab..

[10]  T. Enoki,et al.  Electroluminescence of InAlAs/InGaAs HEMTs lattice-matched to InP substrates , 1995, IEEE Electron Device Letters.

[11]  T. Li,et al.  Reliability of large periphery GaN-on-Si HFETs , 2005, [Reliability of Compound Semiconductors] ROCS Workshop, 2005..

[12]  J. D. del Alamo,et al.  Critical Voltage for Electrical Degradation of GaN High-Electron Mobility Transistors , 2008, IEEE Electron Device Letters.

[13]  J. D. del Alamo,et al.  Mechanisms for Electrical Degradation of GaN High-Electron Mobility Transistors , 2006, 2006 International Electron Devices Meeting.