Char structure characterised by Raman spectroscopy and its correlations with combustion reactivity

Raman spectroscopy was applied to characterise the microstructure of coal chars generated under various heat treatment conditions, which was correlated with the combustion reactivity measured by thermogravimetric analysis. The Raman spectra were fitted with the combination of 4 Lorentzian bands and 1 Gaussian band. It was found that the increase of char microstructural order under heat treatment can be characterised by Raman parameters, in particular the band area ratios, indicated by the increase in IG/IAll and the decrease in ID1/IG, ID2/IG, ID3/IG and ID4/IG with increasing treatment temperature and/or time. The combustion reactivity of the chars from demineralised coals was found to have good correlations with the band area ratios, independent of coal type and heat treatment condition. It was found that the presence of inorganic matter in coal chars marginally affected the evolution of the average char microstructure. However, it did affect the char reactivity evolution. It was confirmed that the thermal deactivation of coal char during heat treatment was dependent not only on the ordering of char crystalline structure but also on the loss of catalytic activity of the inorganic matter.

[1]  Y. Kaburagi,et al.  Full width at half maximum intensity of the G band in the first order Raman spectrum of carbon material as a parameter for graphitization , 2006 .

[2]  K. Arai,et al.  Catalytic reforming of coal tar pitch in supercritical fluid , 1991 .

[3]  F. Tuinstra,et al.  Raman Spectrum of Graphite , 1970 .

[4]  Ezra Bar-Ziv,et al.  Further development of Raman Microprobe spectroscopy for characterization of char reactivity , 2007 .

[5]  B. Feng,et al.  Structural ordering of coal char during heat treatment and its impact on reactivity , 2002 .

[6]  P. A. Jensen,et al.  The Influence of Inorganic Materials on the Thermal Deactivation of Fuel Chars , 2001 .

[7]  J. Lahaye,et al.  Fundamental issues in control of carbon gasification reactivity , 1991 .

[8]  P. Salatino,et al.  Diagnostics of carbon gasification by raman microprobe spectroscopy , 2000 .

[9]  P. Salatino,et al.  Heat treatment-induced loss of combustion reactivity of a coal char: the effect of exposure to oxygen , 2004 .

[10]  Y. Sekine,et al.  New evaluation method of carbonaceous structure on coal steam gasification , 2005 .

[11]  Y. Sekine,et al.  Reactivity and structural change of coal char during steam gasification , 2005 .

[12]  R. McCreery,et al.  Raman Spectroscopy of Carbon Materials: Structural Basis of Observed Spectra , 1990 .

[13]  J. Heintzenberg,et al.  NIR FT Raman spectroscopic study of flame soot , 1999 .

[14]  Chun-Zhu Li,et al.  FT-Raman spectroscopic study of the evolution of char structure during the pyrolysis of a Victorian brown coal , 2006 .

[15]  J. Robertson,et al.  Interpretation of Raman spectra of disordered and amorphous carbon , 2000 .

[16]  J. Gibbins,et al.  Coal Char Thermal Deactivation under Pulverized Fuel Combustion Conditions , 2000 .

[17]  C. H. Bartholomew,et al.  Catalysis of Char Oxidation by Calcium Minerals: Effects of Calcium Compound Chemistry on Intrinsic Reactivity of Doped Spherocarb and Zap Chars , 1994 .

[18]  P. Salatino,et al.  Evolution of Reactivity of Highly Porous Chars from Raman Microscopy , 2000 .

[19]  J. Rouzaud,et al.  Carbon films: Structure and microtexture (optical and electron microscopy, Raman spectroscopy) , 1983 .

[20]  Robert H. Hurt,et al.  A Kinetic Model of Carbon Burnout in Pulverized Coal Combustion , 1998 .

[21]  A. Jensen,et al.  Kinetic Analysis of Char Thermal Deactivation , 2000 .

[22]  T. Kyotani,et al.  Quantitative evaluation of structural transformations in raw coals on heat-treatment using HRTEM technique , 2001 .

[23]  Eric M. Suuberg,et al.  Thermally Induced Changes in Reactivity of Carbons , 1991 .

[24]  J. Casado,et al.  Raman spectroscopic characterization of some commercially available carbon black materials , 1995 .

[25]  R. Hurt,et al.  A methodology for analysis of 002 lattice fringe images and its application to combustion-derived carbons , 2000 .

[26]  R. Hurt,et al.  Evolution of char chemistry, crystallinity, and ultrafine structure during pulverized-coal combustion☆☆☆ , 1995 .

[27]  J. Gibbins,et al.  Structural ordering in high temperature coal chars and the effect on reactivity , 1999 .

[28]  J. Rouzaud,et al.  Maturation grade of coals as revealed by Raman spectroscopy: progress and problems. , 2005, Spectrochimica acta. Part A, Molecular and biomolecular spectroscopy.

[29]  Reinhard Niessner,et al.  Raman microspectroscopy of soot and related carbonaceous materials: Spectral analysis and structural information , 2005 .

[30]  P. Salatino,et al.  Assessment of Thermodeactivation during Gasification of a Bituminous Coal Char , 1999 .

[31]  P. Russo,et al.  The relevance of thermal annealing to the evolution of coal char gasification reactivity , 1997 .

[32]  T. W. Żerda,et al.  High pressure Raman and neutron scattering study on structure of carbon black particles , 2000 .

[33]  R. Hurt,et al.  Residual carbon from pulverized-coal-fired boilers. 2. Morphology and physicochemical properties , 1995 .

[34]  Robert H. Hurt,et al.  Thermal Annealing of Chars from Diverse Organic Precursors under Combustion-like Conditions , 2000 .

[35]  J. Laureyns,et al.  Comparative performance of X-ray diffraction and Raman microprobe techniques for the study of carbon materials , 1998 .

[36]  Catherine A. Johnson,et al.  Applications of laser Raman microprobe spectroscopy to the characterization of coals and cokes , 1983 .

[37]  Yun Yu,et al.  Swelling Behavior of a Chinese Bituminous Coal at Different Pyrolysis Temperatures , 2005 .

[38]  J. Heintzenberg,et al.  Soot characterization in atmospheric particles from different sources by NIR FT Raman spectroscopy , 1999 .

[39]  J. Moulijn,et al.  Correlation between Raman spectroscopic data and the temperature-programmed oxidation reactivity of coals and carbons , 1990 .

[40]  C. H. Bartholomew,et al.  Effects of CaO, High-Temperature Treatment, Carbon Structure, and Coal Rank on Intrinsic Char Oxidation Rates , 1996 .

[41]  J. Laureyns,et al.  Raman microprobe studies on carbon materials , 1994 .

[42]  T. Kyotani,et al.  Effect of Microstructural Changes on Gasification Reactivity of Coal Chars during Low Temperature Gasification , 2002 .

[43]  Robert H. Hurt,et al.  Residual carbon from pulverized coal fired boilers: 1. Size distribution and combustion reactivity , 1995 .

[44]  A. Ishitani,et al.  Raman spectra of graphite edge planes , 1988 .