High-resolution electron backscatter diffraction: An emerging tool for studying local deformation

Electron backscatter diffraction (EBSD) is a widely available and relatively easy-to-use scanning-electron-microscopy-based diffraction technique. Recently, Wilkinson, Meaden, and Dingley presented two papers on a new cross-correlation-based analysis of EBSD patterns which allow variations in the elastic strain and lattice rotation tensors to be measured at a sensitivity of about 10×4 at high spatial resolution. This paper briefly describes the basis of the technique and how the resulting lattice curvatures can be used to estimate the geometrically necessary dislocation (GND) content in a sample. To illustrate the utility of the method for microscale deformation studies the following examples are described: first, nanoindentation near a grain boundary in α-Ti; second, transformation-induced GNDs in a dual-phase steel; third, thermally-induced and mechanically-induced deformation near carbides in a superalloy; fourth, GND accumulation during fatigue of a polycrystalline Ti–6Al–4V alloy.

[1]  R. Cook,et al.  Comparison of nanoscale measurements of strain and stress using electron back scattered diffraction and confocal Raman microscopy , 2008 .

[2]  W. S. Owen,et al.  Can a simple heat treatment help to save Detroit , 1980 .

[3]  R. Fortunier,et al.  Accuracy assessment of elastic strain measurement by EBSD , 2009, Journal of microscopy.

[4]  W. Pantleon.  Resolving the geometrically necessary dislocation content by conventional electron backscattering diffraction , 2008 .

[5]  H. Bhadeshia,et al.  Very strong bainite , 2004 .

[6]  Edward M. Lehockey,et al.  Mapping Residual Plastic Strain in Materials Using Electron Backscatter Diffraction , 2000 .

[7]  J. Nye.  Some geometrical relations in dislocated crystals , 1953 .

[8]  Wilkinson.  Advances in SEM-based diffraction studies of defects and strains in semiconductors , 2000, Journal of electron microscopy.

[9]  D. Fullwood,et al.  Bragg's Law diffraction simulations for electron backscatter diffraction analysis. , 2009, Ultramicroscopy.

[10]  A. Wilkinson,et al.  Measurement of plastic strain of polycrystalline material by electron backscatter diffraction , 2005 .

[11]  D. Field,et al.  Analysis of local orientation gradients in deformed single crystals. , 2005, Ultramicroscopy.

[12]  D. Parks,et al.  Crystallographic aspects of geometrically-necessary and statistically-stored dislocation density , 1999 .

[13]  A. Wilkinson,et al.  Quantification of plastic strain of stainless steel and nickel alloy by electron backscatter diffraction , 2006 .

[14]  A. Wilkinson.  High resolution measurements of strain and tilt distributions in SiGe mesas using electron backscatter diffraction , 2006 .

[15]  A. Wilkinson,et al.  Mapping strains at the nanoscale using electron back scatter diffraction , 2009 .

[16]  D. Dingley,et al.  Progressive steps in the development of electron backscatter diffraction and orientation imaging microscopy , 2004, Journal of microscopy.

[17]  E. Kroener.  Continuum Theory of Dislocation and Self-Stresses , 1971 .

[18]  Kaoru Inoue,et al.  Depth profiles of strain in AlGaN/GaN heterostructures grown on Si characterized by electron backscatter diffraction technique , 2007, IEICE Electron. Express.

[19]  D. Raabe,et al.  Investigation of the indentation size effect through the measurement of the geometrically necessary dislocations beneath small indents of different depths using EBSD tomography , 2009 .

[20]  David J. Dingley,et al.  High resolution mapping of strains and rotations using electron backscatter diffraction , 2006 .

[21]  Carol Trager-Cowan,et al.  Many-beam dynamical simulation of electron backscatter diffraction patterns. , 2007, Ultramicroscopy.

[22]  Zhong Zhong,et al.  Comparison of diffraction methods for measurement of surface damage in superalloys , 2006 .

[23]  A. Wilkinson,et al.  High-resolution elastic strain measurement from electron backscatter diffraction patterns: new levels of sensitivity. , 2006, Ultramicroscopy.

[24]  A. Rollett,et al.  Viewpoint: experimental recovery of geometrically necessary dislocation density in polycrystals , 2003 .

[25]  A. Winkelmann.  Dynamical effects of anisotropic inelastic scattering in electron backscatter diffraction. , 2008, Ultramicroscopy.

[26]  W. King,et al.  Observations of lattice curvature near the interface of a deformed aluminium bicrystal , 2000 .

[27]  G. Miyamoto,et al.  Precise measurement of strain accommodation in austenite matrix surrounding martensite in ferrous alloys by electron backscatter diffraction analysis , 2009 .

[28]  A. Wilkinson,et al.  The effect of crystal orientation on the indentation response of commercially pure titanium: experiments and simulations , 2010, Proceedings of the Royal Society A: Mathematical, Physical and Engineering Sciences.