Energy and geotechnical behaviour of energy piles for different design solutions

Energy piles are heat capacity systems that have been increasingly exploited to provide both supplies of energy and structural support to civil structures. The energy and geotechnical behaviours of such foundations, which are governed by their response to thermo-mechanical loads, is currently not fully understood, especially considering the different design solutions for ground-coupled heat exchangers. This paper summarises the results of numerical sensitivity analyses that were performed to investigate the thermo-mechanical response of a full-scale energy pile for different (i) pipe configurations, (ii) foundation aspect ratios, (iii) mass flow rates of the fluid circulating in the pipes and (iv) fluid mixture compositions. This study outlines the impacts of the different solutions on the energy and geotechnical behaviour of the energy piles along with important forethoughts that engineers might consider in the design of such foundations. It was observed that the pipe configuration strongly influenced both the energy and the geotechnical performance of the energy piles. The foundation aspect ratio also played an important role in this context. The mass flow rate of the fluid circulating in the pipes remarkably influenced only the energy performance of the foundation. Usual mixtures of a water-antifreeze liquid circulating in the pipes did not markedly affect both the energy and the geotechnical performance of the pile.

[1]  J. McCartney,et al.  Analysis of Thermo-Active Foundations With U-Tube Heat Exchangers , 2011 .

[2]  T. Chakraborty,et al.  Cyclic Thermo-Mechanical Analysis of Energy Piles in Sand , 2015, Geotechnical and Geological Engineering.

[3]  E. Zanchini,et al.  Long-term performance of BHE (borehole heat exchanger) fields with negligible groundwater movement , 2010 .

[4]  Lyesse Laloui,et al.  Full-scale in situ testing of energy piles , 2013 .

[5]  C. K. Lee,et al.  Computer simulation of borehole ground heat exchangers for geothermal heat pump systems , 2008 .

[6]  Lyesse Laloui,et al.  Energy geostructures: innovation in underground engineering , 2013 .

[7]  Lyesse Laloui,et al.  Towards a secure basis for the design of geothermal piles , 2014 .

[8]  Krzysztof Kupiec,et al.  Heat transfer in horizontal ground heat exchangers , 2015 .

[9]  J. Claesson,et al.  SIMULATION MODEL FOR THERMALLY INTERACTING HEAT EXTRACTION BOREHOLES , 1988 .

[10]  J. C. Jaeger,et al.  Conduction of Heat in Solids , 1952 .

[11]  A. Abdel-azim.  Fundamentals of Heat and Mass Transfer , 2011 .

[12]  Michele De Carli,et al.  Thermal performance of two types of energy foundation pile: Helical pipe and triple U-tube , 2013 .

[13]  Lyesse Laloui,et al.  Geotechnical Analysis of Heat Exchanger Piles , 2011 .

[14]  C. Guney Olgun,et al.  Multilayer finite line source model for vertical heat exchangers , 2014 .

[15]  Yaping Chen,et al.  Numerical simulation on flow field in circumferential overlap trisection helical baffle heat exchanger , 2013 .

[16]  Philippe Pasquier,et al.  Fast fluid and ground temperature computation for geothermal ground-loop heat exchanger systems , 2008 .

[17]  Paolo Conti,et al.  Proposal of a Holistic Design Procedure for Ground Source Heat Pump Systems , 2013 .

[18]  W. Wang,et al.  Coupled Axisymmetric Thermo-Poro-Mechanical Finite Element Analysis of Energy Foundation Centrifuge Experiments in Partially Saturated Silt , 2015, Geotechnical and Geological Engineering.

[19]  Philippe Pasquier,et al.  The effect of borehole inclination on fluid and ground temperature for GLHE systems , 2009 .

[20]  C. Ng,et al.  Numerical modelling of energy piles in saturated sand subjected to thermo-mechanical loads , 2015 .

[21]  C. Guney Olgun,et al.  Analysis of Friction Induced Thermo-Mechanical Stresses on a Heat Exchanger Pile in Isothermal Soil , 2015, Geotechnical and Geological Engineering.

[22]  L. Lamarche,et al.  New solutions for the short-time analysis of geothermal vertical boreholes , 2007 .

[23]  Moncef Krarti,et al.  Performance of Thermoactive Foundations for Commercial Buildings , 2012 .

[24]  D. Marcotte,et al.  On the estimation of thermal resistance in borehole thermal conductivity test , 2008 .

[25]  Yanzhong Li,et al.  Simulation study on the thermal performance of vertical U-tube heat exchangers for ground source heat pump system , 2015 .

[26]  G. Hellström,et al.  Multipole method to compute the conductive heat flows to and between pipes in a composite cylinder , 1987 .

[27]  Frank P. Incropera,et al.  Fundamentals of Heat and Mass Transfer , 1981 .

[28]  Z. Fang,et al.  A finite line‐source model for boreholes in geothermal heat exchangers , 2002 .

[29]  Mehmet Esen,et al.  Temperature distributions in pavement and bridge slabs heated by using vertical ground-source heat pump systems , 2013 .

[30]  R. Al-Khoury,et al.  Efficient finite element formulation for geothermal heating systems. Part I: steady state , 2005 .

[31]  Paolo Conti,et al.  Analysis of thermodynamic losses in ground source heat pumps and their influence on overall system performance , 2014 .

[32]  C. Guney Olgun,et al.  Equivalent energy wave for long-term analysis of ground coupled heat exchangers , 2015 .

[33]  P. Conti,et al.  Seasonal Thermal Performance of Geothermal Piles , 2012 .

[34]  Daniel Pahud,et al.  Numerical evaluation of thermal response tests , 2007 .

[35]  Benamar Bouhacina,et al.  Numerical investigation of a novel tube design for the geothermal borehole heat exchanger , 2015 .

[36]  Bernard Souyri,et al.  Geothermal helical heat exchangers: Comparison and use of two-dimensional axisymmetric models , 2014 .

[37]  Daniel Pahud,et al.  Comparison of the thermal performance of double U-pipe borehole heat exchangers measured in situ , 2001 .

[38]  Xu Zhang,et al.  Thermal performance and ground temperature of vertical pile-foundation heat exchangers: A case study , 2008 .

[39]  Lyesse Laloui,et al.  Numerical study on the suitability of centrifuge testing for capturing the thermal-induced mechanical behavior of energy piles , 2015 .

[40]  Lyesse Laloui,et al.  Experimental and numerical investigations of the behaviour of a heat exchanger pile , 2006 .

[41]  Enshen Long,et al.  Numerical simulation of ground heat exchangers based on dynamic thermal boundary conditions in solid zone , 2013 .

[42]  T. Chakraborty,et al.  Thermal analysis of energy piles in sand , 2015 .

[43]  Stanislaw Kajl,et al.  A review of methods to evaluate borehole thermal resistances in geothermal heat-pump systems , 2010 .

[44]  C. Guney Olgun,et al.  Thermo-mechanical radial expansion of heat exchanger piles and possible effects on contact pressures at pile–soil interface , 2014 .

[45]  Johan Claesson,et al.  Conductive heat extraction to a deep borehole: Thermal analyses and dimensioning rules , 1988 .

[46]  C. Olgun,et al.  The Thermal Behaviour of Three Different Auger Pressure Grouted Piles Used as Heat Exchangers , 2015, Geotechnical and Geological Engineering.

[47]  Michele De Carli,et al.  Performance analysis of short helical borehole heat exchangers via integrated modelling of a borefield and a heat pump: A case study , 2013 .

[48]  Mikko Malaska,et al.  Evaluation of thermo-mechanical behaviour of composite energy piles during heating/cooling operations , 2014 .

[49]  Hongxing Yang,et al.  A new model and analytical solutions for borehole and pile ground heat exchangers , 2010 .

[50]  Bernard Souyri,et al.  Geothermal helical heat exchangers: Coupling with a reversible heat pump in western Europe , 2015 .

[51]  C. Guney Olgun,et al.  Numerical Modeling of Vertical Geothermal Heat Exchangers Using Finite Difference and Finite Element Techniques , 2015, Geotechnical and Geological Engineering.

[52]  M. E. Suryatriyastuti,et al.  Understanding the temperature-induced mechanical behaviour of energy pile foundations , 2012 .

[53]  G. Hellström.  Ground heat storage : thermal analyses of duct storage systems , 1991 .

[54]  V. Gnielinski.  New equations for heat and mass transfer in turbulent pipe and channel flow , 1976 .

[55]  M. Moreni,et al.  Comportement d'un pieu bi-fonction, fondation et échangeur de chaleur , 2003 .

[56]  Daniel Pahud,et al.  Measured thermal performances of the energy pile system of the Dock Midfield at Zurich airport , 2007 .

[57]  R. Al-Khoury,et al.  Efficient finite element formulation for geothermal heating systems. Part II: transient , 2006 .

[58]  J. McCartney,et al.  Analysis of Thermo-Active Foundations With U-Tube Heat Exchangers , 2012 .

[59]  Tolga Y. Ozudogru,et al.  3D Numerical Modeling of Vertical Geothermal Heat Exchangers , 2014 .

[60]  Tatyana V. Bandos,et al.  Finite line-source model for borehole heat exchangers: effect of vertical temperature variations , 2009 .

[61]  Louis Lamarche,et al.  A new contribution to the finite line-source model for geothermal boreholes , 2007 .

[62]  Lyesse Laloui,et al.  Numerical study of the response of a group of energy piles under different combinations of thermo-mechanical loads , 2016 .

[63]  Fleur Loveridge,et al.  Energy Pile Performance and Preventing Ground Freezing , 2012 .

[64]  Lyesse Laloui,et al.  Numerical analysis of the geotechnical behaviour of energy piles , 2015 .

[65]  Jeffrey D. Spitler,et al.  A short time step response factor model for vertical ground loop heat exchangers , 1999 .

[66]  Bertrand François,et al.  Efficiency of various grouting materials for borehole heat exchangers , 2014 .

[67]  Thompson,et al.  Numerical Analysis of Thermal Behavior and Fluid Flow in Geothermal Energy Piles , 2013 .

[68]  Konstantinos Papakostas,et al.  On the evaluation of design parameters effects on the heat transfer efficiency of energy piles , 2011 .

[69]  O. J. Zobel,et al.  Heat conduction with engineering, geological, and other applications , 1955 .

[70]  C. G. Olgun,et al.  Design and Operational Considerations of Geothermal Energy Piles , 2011 .

[71]  S. Haaland.  Simple and Explicit Formulas for the Friction Factor in Turbulent Pipe Flow , 1983 .

[72]  Lyesse Laloui,et al.  Behaviour of a group of energy piles , 2015 .

[73]  Sherif L. Abdelaziz,et al.  Long-term performance of heat exchanger piles , 2015 .