Characterization of plunging liquid jets: A combined experimental and numerical investigation

This paper presents a combined experimental and numerical study of the flow characteristics of round vertical liquid jets plunging into a cylindrical liquid bath. The main objective of the experimental work consists in determining the plunging jet flow patterns, entrained air bubble sizes and the influence of the jet velocity and variations of jet falling lengths on the jet penetration depth. The instability of the jet influenced by the jet velocity and falling length is also probed. On the numerical side, two different approaches were used, namely the mixture model approach and interface-tracking approach using the level-set technique with the standard two-equation turbulence model. The numerical results are contrasted with the experimental data. Good agreements were found between experiments and the two modelling approaches on the jet penetration depth and entraining flow characteristics, with interface tracking rendering better predictions. However, visible differences are observed as to the jet instability, free surface deformation and subsequent air bubble entrainment, where interface tracking is seen to be more accurate. The CFD results support the notion that the jet with the higher flow rate thus more susceptible to surface instabilities, entrains more bubbles, reflecting in turn a smaller penetration depth as a result of momentum diffusion due to bubble concentration and generated fluctuations. The liquid average velocity field and air concentration under tank water surface were compared to existing semi-analytical correlations. Noticeable differences were revealed as to the maximum velocity at the jet centreline and associated bubble concentration. The mixture model predicts a higher velocity than the level-set and the theory at the early stage of jet penetration, due to a higher concentration of air that cannot rise to the surface and remain trapped around the jet head. The location of the maximum air content and the peak value of air holdup are also predicted differently.

[1]  Dirk Lucas,et al.  CFD Approaches for Modelling Bubble Entrainment by an Impinging Jet , 2009 .

[2]  Isao Kataoka,et al.  Turbulence structure of air-water bubbly flow—I. measuring techniques , 1975 .

[3]  Djamel Lakehal,et al.  Interface tracking towards the direct simulation of heat and mass transfer in multiphase flows , 2002 .

[4]  Hubert Chanson,et al.  Environmental hydraulics of open channel flows , 2004 .

[5]  S. D. Kim,et al.  Bubble properties and local liquid velocity in the radial direction of cocurrent gas-liquid flow , 1991 .

[6]  Hubert Chanson,et al.  Air Bubble Entrainment in Free-Surface Turbulent Shear Flows , 1996 .

[7]  A. K. Biń.  Gas entrainment by plunging liquid jets , 1988 .

[8]  M. Manninen,et al.  On the mixture model for multiphase flow , 1996 .

[9]  V. F. Leavers.  Dynamic generalized Hough transform , 1990, Other Conferences.

[10]  Isao Kataoka,et al.  Turbulence structure of air-water bubbly flow—II. local properties , 1975 .

[11]  S. Osher,et al.  A level set approach for computing solutions to incompressible two-phase flow , 1994 .

[12]  Hubert Chanson,et al.  Air Entrainment in the Developing Flow Region of Plunging Jets—Part 2: Experimental , 1997 .

[13]  Eamon McKeogh,et al.  Air entrainment rate and diffusion pattern of plunging liquid jets , 1981 .

[14]  Violet F. Leavers.  Active intelligent vision using the dynamic generalized Hough Transform , 1990, BMVC.

[15]  Brian L. Smith,et al.  INTERFACE TRACKING FOR THE PREDICTION OF INTERFACIAL DYNAMICS AND HEAT/MASS TRANSFER IN MULTIPHASE FLOWS , 2001 .

[16]  Fabián J. Bonetto,et al.  An experimental study on air carryunder due to a plunging liquid jet , 1993 .

[17]  Djamel Lakehal,et al.  Multi-physics treatment in the vicinity of arbitrarily deformable gas-liquid interfaces , 2007, J. Comput. Phys..

[18]  I. Wood.  Air Bubble Entrainment in Free Surface Turbulent Shear Flow by Hurbert Chanson , 1997 .

[19]  Assad A. Oberai,et al.  A quantitative sub-grid air entrainment model for bubbly flows , 2009 .

[20]  R. Clift,et al.  Bubbles, Drops, and Particles , 1978 .

[21]  D. Lakehal,et al.  Interface-turbulence interactions in large-scale bubbling processes , 2007 .

[22]  Hubert Chanson,et al.  Physical modelling and similitude of air bubble entrainment at vertical circular plunging jets , 2004 .

[23]  Hubert Chanson,et al.  Air Entrainment in the Developing Flow Region of Plunging Jets—Part 1: Theoretical Development , 1997 .

[24]  Abraham M. Lenhoff,et al.  Dynamic breakup of liquid–liquid jets , 1994 .

[25]  James H. Duncan,et al.  Incipient air entrainment in a translating axisymmetric plunging laminar jet , 2002 .

[26]  Manabu Iguchi,et al.  Mean velocity and turbulence characteristics of water flow in the bubble dispersion region induced by plunging water jet , 1998 .

[27]  Eckhard Krepper,et al.  The inhomogeneous MUSIG model for the simulation of polydispersed flows , 2008 .