Clogging in subsurface-flow treatment wetlands: Occurrence and contributing factors

Abstract Clogging is a major operational and maintenance issue associated with the use of subsurface flow wetlands for wastewater treatment, and can ultimately limit the lifetime of the system. This review considers over two decades of accumulated knowledge regarding clogging in both vertical and horizontal subsurface flow treatment wetlands. The various physical, chemical and biological factors responsible for clogging are identified and discussed. The occurrence of clogging is placed into the context of various design and operational parameters such as wastewater characteristics, upstream treatment processes, intermittent or continuous operation, influent distribution, and media type. This information is then used to describe how clogging develops within, and subsequently impacts, common variants of subsurface flow treatment wetland typically used in the U.S., U.K., France and Germany. Comparison of these systems emphasized that both hydraulic loading rate and solids loading rate need to be considered when designing systems to operate robustly, i.e. hydraulic overloading makes horizontal-flow tertiary treatment systems in the U.K. more susceptible to clogging problems than vertical-flow primary treatment systems in France. Future research should focus on elucidating the underlying mechanisms of clogging as they relate to the design, operation, and maintenance of subsurface flow treatment wetlands.

[1]  O Lahav,et al.  Ammonium removal using a novel unsaturated flow biological filter with passive aeration. , 2001, Water research.

[2]  John W. Day,et al.  The impact of wastewater effluent on accretion and decomposition in a subsiding forested wetland , 2002, Wetlands.

[3]  Minimizing land requirement and evaporation in small wastewater treatment systems , 2006 .

[4]  Y Q Zhao,et al.  Anti-sized reed bed system for animal wastewater treatment: a comparative study. , 2004, Water research.

[5]  Branko Velimirov,et al.  Degradation of Emergent and Submerged Macrophytesin an Oxbow Lake of an Embanked Backwater System: Implications for the Terrestrialization Process , 2001 .

[6]  G. Parkin,et al.  Treatment of landfill leachate using an aerated, horizontal subsurface-flow constructed wetland. , 2007, The Science of the total environment.

[7]  M. B. Green,et al.  Constructed reed beds: Appropriate technology for small communities , 1995 .

[8]  R. Dick,et al.  AN ASSESSMENT OF THE ROOT ZONE METHOD OF WASTEWATER TREATMENT , 1991 .

[9]  Esther Llorens,et al.  Practical method based on saturated hydraulic conductivity used to assess clogging in subsurface flow constructed wetlands , 2009 .

[10]  Joan García Serrano,et al.  Depuración con Humedales Construidos. Guía Práctica de Diseño, Construcción y Explotación de Sistemas de Humedales de Flujo Subsuperficial , 2008 .

[11]  P. Cross,et al.  Pro-poor strategies for urban water supply and sanitation services delivery in Africa. , 2005, Water science and technology : a journal of the International Association on Water Pollution Research.

[12]  T. Parr,et al.  FACTORS AFFECTING REED (PHRAGMITES AUSTRALIS) GROWTH IN UK REED BED TREATMENT SYSTEMS , 1990 .

[13]  Philippe C. Baveye,et al.  Environmental impact and mechanisms of the biological clogging of saturated soils and aquifer materials , 1998 .

[14]  Peter F Breen,et al.  Rootzone dynamics in constructed wetlands receiving wastewater: a comparison of vertical and horizontal flow systems , 1995 .

[15]  Manuel Soto,et al.  Performance of an anaerobic digester-constructed wetland system for a small community , 2008 .

[16]  Jan Vymazal,et al.  Natural and constructed wetlands : nutrients, metals and management , 2005 .

[17]  P Griffin,et al.  Complementary methods to investigate the development of clogging within a horizontal sub-surface flow tertiary treatment wetland. , 2010, Water research.

[18]  Günter Langergraber,et al.  Modeling of Processes in Subsurface Flow Constructed Wetlands: A Review , 2008 .

[19]  D. C. Mays,et al.  Hydrodynamic aspects of particle clogging in porous media. , 2005, Environmental science & technology.

[20]  P. F. Cooper,et al.  Constructed wetlands in water pollution control. , 1990 .

[21]  S. Murat-Błażejewska,et al.  Soil clogging phenomena in constructed wetlands with subsurface flow , 1997 .

[22]  Chris C. Tanner,et al.  Accumulation of organic solids in gravel-bed constructed wetlands , 1995 .

[23]  Philippe Baveye,et al.  Relationship between Transport of Bacteria and Their Clogging Efficiency in Sand Columns , 1992, Applied and environmental microbiology.

[24]  G. R. Steiner,et al.  General design, construction, and operation guidelines: Constructed wetlands wastewater treatment systems for small users including individual residences. Second edition , 1993 .

[25]  C Boutin,et al.  How to treat raw sewage with constructed wetlands: an overview of the French systems. , 2005, Water science and technology : a journal of the International Association on Water Pollution Research.

[26]  Aracelly Caselles-Osorio,et al.  Effect of physico-chemical pretreatment on the removal efficiency of horizontal subsurface-flow constructed wetlands. , 2007, Environmental pollution.

[27]  Jaume Puigagut,et al.  Fractionation, Biodegradability and Particle-Size Distribution of Organic Matter in Horizontal Subsurface-Flow Constructed Wetlands , 2008 .

[28]  Charles R. O'Melia,et al.  Clarification of Clean-Bed Filtration Models , 1995 .

[29]  Scott Wallace,et al.  Small Scale Constructed Wetland Treatment Systems: Feasibility, Design Criteria and O&m Requirements , 2006 .

[30]  Charles R. O'Melia,et al.  Water and waste water filtration. Concepts and applications , 1971 .

[31]  G. R. Steiner,et al.  PERFORMANCE OF CONSTRUCTED WETLAND TREATMENT SYSTEMS AT BENTON, HARDIN, AND PEMBROKE, KENTUCKY, DURING THE EARLY VEGETATION ESTABLISHMENT PHASE , 1990 .

[32]  T. Asano,et al.  Size distributions of particulate contaminants in wastewater and their impact on treatability , 1991 .

[33]  Raimund Haberl,et al.  Characterisation of microbial biocoenosis in vertical subsurface flow constructed wetlands. , 2007, The Science of the total environment.

[34]  Peter K. Kitanidis,et al.  Simulations of two‐dimensional modeling of biomass aggregate growth in network models , 2001 .

[35]  Peter Vanrolleghem,et al.  Impact of Prior Physico-Chemical Treatment on the Clogging Process of Subsurface Flow Constructed Wetlands: Model-Based Evaluation , 2007 .

[36]  Tammo S. Steenhuis,et al.  Hydraulic conductivity of gravel and sand as substrates in rock-reed filters , 1995 .

[37]  Hans Brix,et al.  SEWAGE TREATMENT IN CONSTRUCTED REED BEDS — DANISH EXPERIENCES , 1989 .

[38]  Rafael Mujeriego,et al.  Spatial variations of temperature, redox potential, and contaminants in horizontal flow reed beds , 2003 .

[39]  D McNevin,et al.  Indicators of biofilm development and activity in constructed wetlands microcosms. , 2004, Water research.

[40]  D Goetz,et al.  The impact of sewage composition on the soil clogging phenomena of vertical flow constructed wetlands. , 2003, Water science and technology : a journal of the International Association on Water Pollution Research.

[41]  Jan Vymazal,et al.  Wastewater Treatment in Constructed Wetlands with Horizontal Sub-Surface Flow , 2008 .

[42]  Raimund Haberl,et al.  Constructed wetlands for pollution control: Processes, performance, design and operation , 2000 .

[43]  U. Pauly,et al.  PERFORMANCE DATA OF A WASTEWATER AND SLUDGE TREATMENT PLANT DERIVED FROM THE ROOT ZONE METHOD SET AGAINST THE BACKGROUND OF DETENTION TIMES , 1990 .

[44]  G Merlin,et al.  Influence of surface layer on hydrology and biology of gravel bed vertical flow constructed wetlands. , 2005, Water science and technology : a journal of the International Association on Water Pollution Research.

[45]  Philip Davies,et al.  A method for the in-situ determination of the hydraulic conductivity of gravels as used in constructed wetlands for wastewater treatment , 2009 .

[46]  Paul Palazolo,et al.  Preliminary Evaluation of Biological and Physical–Chemical Chromium Removal Mechanisms in Gravel Media Used in Constructed Wetlands , 2011 .

[47]  Paul Stoodley,et al.  Relation between the structure of an aerobic biofilm and transport phenomena , 1995 .

[48]  D. Brown,et al.  Reciprocating constructed wetlands for treating industrial, municipal and agricultural wastewater. , 2001, Water science and technology : a journal of the International Association on Water Pollution Research.

[49]  Stephen J. Allen,et al.  An Alternative Arrangement of Gravel Media in Tidal Flow Reed Beds Treating Pig Farm Wastewater , 2007 .

[50]  Tony Howes,et al.  Hydraulic tracer studies in a pilot scale subsurface flow constructed wetland , 1997 .

[51]  J. A. Álvarez,et al.  Anaerobic digesters as a pretreatment for constructed wetlands , 2008 .

[52]  Andrew Baird,et al.  An assessment of the piezometer method for measuring the hydraulic conductivity of a Cladium mariscus—Phragmites australis root mat in a Norfolk (UK) fen , 2004 .

[53]  Chris C. Tanner,et al.  Organic matter accumulation during maturation of gravel-bed constructed wetlands treating farm dairy wastewaters , 1998 .

[54]  Gerald A. Moshiri,et al.  Constructed Wetlands for Water Quality Improvement , 1993 .

[55]  C. Coombes.  REED BED TREATMENT SYSTEMS IN ANGLIAN WATER , 1990 .

[56]  M. Chimney,et al.  Decomposition of macrophyte litter in a subtropical constructed wetland in south Florida (USA) , 2006 .

[57]  Allan Batchelor,et al.  A critical evaluation of a pilot scale subsurface flow wetland: 10 years after commissioning , 1997 .

[58]  Marcos von Sperling,et al.  Performance evaluation of planted and unplanted subsurface-flow constructed wetlands for the post-treatment of UASB reactor effluents. , 2009, Water science and technology : a journal of the International Association on Water Pollution Research.

[59]  Nathalie Tufenkji,et al.  Modeling microbial transport in porous media: Traditional approaches and recent developments , 2007 .

[60]  K. Bowmer,et al.  Nutrient removal from effluents by an artificial wetland: Influence of rhizosphere aeration and preferential flow studied using bromide and dye tracers , 1987 .

[61]  Stewart W. Taylor,et al.  Biofilm growth and the related changes in the physical properties of a porous medium: 2. Permeability , 1990 .

[62]  Philippe C. Baveye,et al.  Saturated Hydraulic Conductivity Reduction Caused by Aerobic Bacteria in Sand Columns , 1992 .

[63]  P A Vanrolleghem,et al.  Impact of operational maintenance on the asset life of storm reed beds. , 2005, Water science and technology : a journal of the International Association on Water Pollution Research.

[64]  L. Nguyen,et al.  Organic matter composition, microbial biomass and microbial activity in gravel-bed constructed wetlands treating farm dairy wastewaters. , 2000 .

[65]  Terry J. Schulz,et al.  Variability of Hydraulic Response of Constructed Wetlands , 1993 .

[66]  P Cooper,et al.  The performance of vertical flow constructed wetland systems with special reference to the significance of oxygen transfer and hydraulic loading rates. , 2005, Water science and technology : a journal of the International Association on Water Pollution Research.

[67]  Jan Vymazal,et al.  Water and nutrient management in natural and constructed wetlands , 2011 .

[68]  Hans Brix,et al.  Use of constructed wetlands in water pollution control: historical development, present status, and future perspectives , 1994 .

[69]  Jan Vymazal,et al.  The use of subsurface-flow constructed wetlands for wastewater treatment in the Czech Republic , 1996 .

[70]  Brij B. Maini,et al.  Flow of dispersed particles through porous media — Deep bed filtration , 2009 .

[71]  R. Haberl,et al.  SEVEN YEARS OF RESEARCH WORK AND EXPERIENCE WITH WASTEWATER TREATMENT BY A REED BED SYSTEM , 1990 .

[72]  T. Krogstad,et al.  Phosphorus sorption and chemical characteristics of lightweight aggregates (LWA)-potential filter media in treatment wetlands , 1997 .

[73]  Charles R. Goldman,et al.  Use of artificial wetlands to remove nitrogen from waste water , 1984 .

[74]  Sherwood C. Reed,et al.  Natural Systems for Waste Management and Treatment , 1994 .

[75]  S. Friedlander,et al.  The coagulation of hydrosols by brownian motion and laminar shear flow , 1964 .

[76]  Diederik P L Rousseau,et al.  Reversing clogging in subsurface-flow constructed wetlands by hydrogen peroxide treatment: two case studies. , 2009, Water science and technology : a journal of the International Association on Water Pollution Research.

[77]  P Vandevivere,et al.  Effect of bacterial extracellular polymers on the saturated hydraulic conductivity of sand columns , 1992, Applied and environmental microbiology.

[78]  Thomas Højlund Christensen,et al.  CHARACTERIZATION OF THE DISSOLVED ORGANIC CARBON IN LANDFILL LEACHATE-POLLUTED GROUNDWATER , 1998 .

[79]  George Tchobanoglous,et al.  Small and decentralized wastewater management systems , 1998 .

[80]  P Cooper,et al.  The Constructed Wetland Association UK database of constructed wetland systems. , 2007, Water science and technology : a journal of the International Association on Water Pollution Research.

[81]  Catherine Boutin,et al.  DOMESTIC WASTEWATER TREATMENT WITH EMERGENT HYDROPHYTE BEDS IN FRANCE , 1990 .

[82]  P. Griffin,et al.  The advantages of a constructed reed bed based strategy for small sewage treatment works , 1998 .

[83]  K Kayser,et al.  Processes in vertical-flow reed beds: nitrification, oxygen transfer and soil clogging. , 2005, Water science and technology : a journal of the International Association on Water Pollution Research.

[84]  Jaume Puigagut,et al.  Solids accumulation in six full-scale subsurface flow constructed wetlands. , 2007, Water research.

[85]  Aracelly Caselles-Osorio,et al.  Performance of experimental horizontal subsurface flow constructed wetlands fed with dissolved or particulate organic matter. , 2006, Water research.

[86]  H Brix,et al.  Danish guidelines for small-scale constructed wetland systems for onsite treatment of domestic sewage. , 2005, Water science and technology : a journal of the International Association on Water Pollution Research.

[87]  Takashi Asaeda,et al.  Seasonal fluctuations in live and dead biomass of Phragmites australis as described by a growth and decomposition model: implications of duration of aerobic conditions for litter mineralization and sedimentation , 2002 .

[88]  Hans Brix,et al.  Constructed Wetlands for Wastewater Treatment in Europe , 1998 .

[89]  Klaus Mauch,et al.  Soil clogging in vertical flow reed beds – mechanisms, parameters, consequences and.......solutions? , 1997 .

[90]  Perry L. McCarty,et al.  Mesoscale and Microscale Observations of Biological Growth in a Silicon Pore Imaging Element , 1999 .

[91]  P. Cooper,et al.  Reed bed treatment systems for sewage treatment in the United Kingdom - the first 10 years’ experience , 1995 .

[92]  Piotr Czupryński,et al.  Study of hydraulic parameters in heterogeneous gravel beds: Constructed wetland in Nowa Słupia (Poland) , 2006 .

[93]  L Nguyen.  Accumulation of organic matter fractions in a gravel-bed constructed wetland. , 2001, Water science and technology : a journal of the International Association on Water Pollution Research.

[94]  C. Campbell,et al.  Constructed Wetlands in the Sustainable Landscape , 1999 .

[95]  Martin Thullner,et al.  Comparison of bioclogging effects in saturated porous media within one- and two-dimensional flow systems , 2010 .

[96]  A Pressl,et al.  Evaluation of substrate clogging processes in vertical flow constructed wetlands. , 2003, Water science and technology : a journal of the International Association on Water Pollution Research.

[97]  Jan Vymazal,et al.  Wastewater Treatment, Plant Dynamics and Management in Constructed and Natural Wetlands , 2008 .

[98]  Aleksandra Drizo,et al.  Flow patterns of dairy wastewater constructed wetlands in a cold climate. , 2006, Water research.

[99]  R. Netter,et al.  HYDRAULIC INVESTIGATIONS ON PLANTED SOIL FILTERS , 1990 .

[100]  Hans Brix,et al.  Functions of Macrophytes in Constructed Wetlands , 1994 .

[101]  P Molle,et al.  Effect of reeds and feeding operations on hydraulic behaviour of vertical flow constructed wetlands under hydraulic overloads. , 2006, Water research.

[102]  Perry L. McCarty,et al.  Evaluation of steady‐state‐biofilm kinetics , 1980 .

[103]  Chongrak Polprasert,et al.  Assessment of effective specific surface area for free water surface constructed wetlands , 1999 .

[104]  R. Shutes,et al.  Reed beds and constructed wetlands for wastewater treatment , 1997 .

[105]  Chris C. Tanner,et al.  Growth and nutrition of Schoenoplectus validus in agricultural wastewaters , 1994 .

[106]  A. Sheoran,et al.  Heavy metal removal mechanism of acid mine drainage in wetlands: A critical review , 2006 .

[107]  Catherine Boutin,et al.  Development of a new generation of reed-bed filters in France: First results , 1997 .

[108]  Y Comeau,et al.  Effect of loading rate on performance of constructed wetlands treating an anaerobic supernatant. , 2007, Water science and technology : a journal of the International Association on Water Pollution Research.

[109]  Clodagh Murphy,et al.  The Evolution of Horizontal Subsurface Flow Reed Bed Design for Tertiary Treatment of Sewage Effluents in the UK , 2010 .

[110]  Malte Hermansson,et al.  The DLVO theory in microbial adhesion , 1999 .

[111]  H. K. French,et al.  Change in flow and transport patterns in horizontal subsurface flow constructed wetlands as a result of biological growth , 2006 .

[112]  P Griffin,et al.  Factors affecting the longevity of sub-surface horizontal flow systems operating as tertiary treatment for sewage effluent. , 2005, Water science and technology : a journal of the International Association on Water Pollution Research.

[113]  R. K. Rowe,et al.  Field observations of clogging in a landfill leachate collection system , 1999 .

[114]  Esther Llorens,et al.  Distribution and biodegradability of sludge accumulated in a full-scale horizontal subsurface-flow constructed wetland , 2009 .

[115]  John A. Heitmann,et al.  PERMEABILITY REDUCTION PHENOMENA IN PACKED BEDS, FIBER MATS, AND WET WEBS OF PAPER EXPOSED TO FLOW OF LIQUIDS AND SUSPENSIONS: A REVIEW , 2009 .