Electrical test methods for on-line fuel cell ohmic resistance measurement

Abstract The principles and trade-offs of four electrical test methods suitable for on-line measurement of the ohmic resistance (RΩ) of fuel cells is presented: current interrupt, AC resistance, high frequency resistance (HFR), and electrochemical impedance spectroscopy (EIS). The internal resistance of a proton exchange membrane (PEM) fuel cell determined with the current interrupt, HFR and EIS techniques is compared. The influence of the AC amplitude and frequency of the HFR measurement on the observed ohmic resistance is examined, as is the ohmic resistance extracted from the EIS data by modeling the spectra with a transmission line model for porous electrodes. The ohmic resistance of a H2/O2 PEM fuel cell determined via the three methods was within 10–30% of each other. The current interrupt technique consistently produced measured cell resistances that exceeded those of the other two techniques. For the HFR technique, the frequency at which the measurement was conducted influenced the measured resistance (i.e., higher frequency providing smaller RΩ), whereas the AC amplitude did not effect the observed value. The difference in measured ohmic resistance between these techniques exceeds that reasonably accounted for by measurement error. The source of the discrepancy between current interrupt and impedance-based methods is attributed to the difference in the response of a non-uniformly polarized electrode, such as a porous electrode with non-negligible ohmic resistance, to a large perturbation (current interrupt event) as compared to a small perturbation (impedance measurement).

[1]  T. Springer,et al.  Characterization of polymer electrolyte fuel cells using ac impedance spectroscopy , 1996 .

[2]  T. Zawodzinski,et al.  The Effects of Processing Conditions and Chemical Composition on Electronic and Ionic Resistivities of Fuel Cell Electrode Composites , 2003 .

[3]  Tatsuo Nishina,et al.  Characterization of a 100 cm2 Class Molten Carbonate Fuel Cell with Current Interruption , 1998 .

[4]  S. Srinivasan,et al.  Measurements of proton conductivity in the active layer of PEM fuel cell gas diffusion electrodes , 1998 .

[5]  M. Mathias,et al.  Measurement of Catalyst Layer Electrolyte Resistance in PEFCs Using Electrochemical Impedance Spectroscopy , 2005 .

[6]  D. Britz,et al.  iR elimination in electrochemical cells , 1978 .

[7]  E. Barsoukov,et al.  Impedance spectroscopy : theory, experiment, and applications , 2005 .

[8]  John Newman,et al.  Mathematical Modeling of the Lithium‐Aluminum, Iron Sulfide Battery II . The Influence of Relaxation Time on the Charging Characteristics , 1981 .

[9]  G. G. Stokes.  "J." , 1890, The New Yale Book of Quotations.

[10]  M. Murthy.  Proton Conducting Membrane Fuel Cells III : proceedings of the International Symposium , 2005 .

[11]  John Newman,et al.  Ohmic Potential Measured by Interrupter Techniques , 1970 .

[12]  Günther G. Scherer,et al.  In Situ Membrane Resistance Measurements in Polymer Electrolyte Fuel Cells by Fast Auxiliary Current Pulses , 1995 .

[13]  Allen J. Bard,et al.  Electrochemical Methods: Fundamentals and Applications , 1980 .

[14]  Fernando H. Garzon,et al.  Determination of Ionic and Electronic Resistivities in Carbon/Polyelectrolyte Fuel-Cell Composite Electrodes , 2002 .

[15]  Qingzhi Guo,et al.  Study of Ionic Conductivity Profiles of the Air Cathode of a PEMFC by AC Impedance Spectroscopy , 2003 .

[16]  A. T. Kuhn,et al.  Techniques for the determination of ohmic drop in half-cells and full cells: A review , 1977 .

[17]  P. Pickup,et al.  CHARACTERIZATION OF IONIC CONDUCTIVITY PROFILES WITHIN PROTON EXCHANGE MEMBRANE FUEL CELL GAS DIFFUSION ELECTRODES BY IMPEDANCE SPECTROSCOPY , 1999 .

[18]  Göran Lindbergh,et al.  Investigation of Porous Electrodes by Current Interruption Application to Molten Carbonate Fuel Cell Cathodes , 1995 .

[19]  B. Andreaus,et al.  Analysis of performance losses in polymer electrolyte fuel cells at high current densities by impedance spectroscopy , 2002 .

[20]  Compensation,et al.  The Measurement and Correction of Electrolyte Resistance in Electrochemical Tests , 1990 .