Design and construction of geocell foundation to support the embankment on settled red mud

This paper presents the case history of the construction of a 3 m high embankment on the geocell foundation over the soft settled red mud. Red mud is a waste product from the Bayer process of Aluminum industry. Geotechnical problems of the site, the design of the geocell foundation based on experimental investigation and the construction sequences of the geocell foundations in the field are discussed in the paper. Based on the experimental studies, an analytical model was also developed to estimate the load carrying capacity of the soft clay bed reinforced with geocell and combination of geocell and geogrid. The results of the experimental and analytical studies revealed that the use of combination of geocell and the geogrid is always beneficial than using the geocell alone. Hence, the combination of geocell and geogrid was recommended to stabilize the embankment base. The reported embankment is located in Lanjigharh (Orissa) in India. Construction of the embankment on the geocell foundation has already been completed. The constructed embankmenthas already sustained two monsoon rains without any cracks and seepage.

[1]  Mahmoud Ghazavi,et al.  Interference effect of shallow foundations constructed on sand reinforced with geosynthetics , 2008 .

[2]  G. Madhavi Latha,et al.  Effect of reinforcement form on the bearing capacity of square footings on sand , 2009 .

[3]  Ching-Chuan Huang,et al.  Bearing capacity of reinforced horizontal sandy ground , 1990 .

[4]  J. W. Cowland,et al.  Performance of a road embankment on soft clay supported on a Geocell mattress foundation , 1993 .

[5]  Jun-jie Zheng,et al.  A simplified method for analysis of a piled embankment reinforced with geosynthetics , 2009 .

[6]  Robert M. Koerner,et al.  Designing with Geosynthetics , 1986 .

[7]  H. O. Magnani,et al.  Behaviour of two reinforced test embankments on soft clay , 2009 .

[8]  Xuejun Wen,et al.  Model studies on geogrid- or geocell-reinforced sand cushion on soft soil , 2008 .

[9]  T. G. Sitharam,et al.  Model studies of embedded circular footing on geogrid-reinforced sand beds , 2004 .

[10]  S. N. Moghaddas Tafreshi,et al.  Behaviour of footings on reinforced sand subjected to repeated loading – Comparing use of 3D and planar geotextile , 2010 .

[11]  Jinchun Chai,et al.  Measured and predicted performance of prefabricated vertical drains (PVDs) with and without vacuum preloading , 2010 .

[12]  Xiaoming Yang.  Numerical Analyses of Geocell-Reinforced Granular Soils under Static and Repeated Loads , 2010 .

[13]  Dennes T. Bergado,et al.  2D and 3D numerical simulations of reinforced embankments on soft ground , 2008 .

[14]  Minghua Zhao,et al.  Bearing capacity of geocell reinforcement in embankment engineering , 2010 .

[15]  Jie Han,et al.  Investigation of factors influencing behavior of single geocell-reinforced bases under static loading , 2010 .

[16]  V G Havanagi,et al.  An approach to shorten the construction period of high embankment on soft soil improved with PVD , 2009 .

[17]  Sujit Kumar Dash,et al.  Bearing capacity of circular footing on geocell–sand mattress overlying clay bed with void , 2009 .

[18]  Jun-jie Zheng,et al.  The performance of an embankment on soft ground reinforced with geosynthetics and pile walls , 2009 .

[19]  Mustafa Laman,et al.  Large scale field tests on geogrid-reinforced granular fill underlain by clay soil , 2013 .

[20]  Allen Lunzhu Li,et al.  Effects of viscous behavior of geosynthetic reinforcement and foundation soils on the performance of reinforced embankments , 2008 .

[21]  Andrew Dawson,et al.  Combined use of geocell reinforcement and rubber–soil mixtures to improve performance of buried pipes , 2012 .

[22]  Liping Wang,et al.  Centrifuge model tests of geotextile-reinforced soil embankments during an earthquake , 2011 .

[23]  Robert L. Parsons,et al.  Performance of geocell-reinforced recycled asphalt pavement (RAP) bases over weak subgrade under cyclic plate loading , 2012 .

[24]  F Tatsuoka,et al.  PREDICTION OF BEARING CAPACITY IN LEVEL SANDY GROUND REINFORCED WITH STRIP REINFORCEMENT ---PROCEEDINGS OF THE INTERNATIONAL SYMPOSIUM ON THEORY AND PRACTICE OF EARTH REINFORCEMENT, FUKUOKA, KYUSHU, JAPAN, 5-7 OCTOBER 1988 , 1988 .

[25]  C. Taechakumthorn,et al.  Combined effect of PVDs and reinforcement on embankments over rate-sensitive soils , 2008 .

[26]  G. P. Karunaratne.  Prefabricated and electrical vertical drains for consolidation of soft clay , 2011 .

[27]  T. G. Sitharam,et al.  Behavior of Embedded Footings Supported on Geogrid Cell Reinforced Foundation Beds , 2005 .

[28]  R. H. Plaut,et al.  Analysis of geosynthetic reinforcement in pile-supported embankments. Part I: 3D plate model , 2010 .

[29]  Kousik Deb,et al.  Finite element analysis of geotextile-reinforced sand-bed subjected to strip loading , 2008 .

[30]  Sujit Kumar Dash,et al.  Model studies on circular footing supported on geocell reinforced sand underlain by soft clay , 2003 .

[31]  Chen Yun-min,et al.  An experimental investigation of soil arching within basal reinforced and unreinforced piled embankments , 2008 .

[32]  Chia-Cheng Fan,et al.  The mechanical behaviour and design concerns for a hybrid reinforced earth embankment built in limited width adjacent to a slope , 2011 .

[33]  Buddhima Indraratna,et al.  Soft ground improvement via vertical drains and vacuum assisted preloading , 2012 .

[34]  François Nicot,et al.  Uniaxial compressive behavior of scrapped tire and sand-filled wire netted geocell with a geotextile envelope , 2011 .

[35]  Sujit Kumar Dash,et al.  Strip footing on geocell reinforced sand beds with additional planar reinforcement , 2001 .

[36]  V. Choa,et al.  Improvement of ultra-soft soil using prefabricated vertical drains , 2006 .

[37]  B. Indraratna,et al.  Field Assessment of the Performance of a Ballasted Rail Track with and without Geosynthetics , 2010 .

[38]  Zhao Heng.  Research Progress in Two-direction Reinforced Composite Foundation Formed by Geocell Reinforced Mattress and Gravel Piles , 2009 .

[39]  Malcolm D. Bolton,et al.  Centrifugal and numerical modelling of reinforced embankments on soft clay installed with wick drains , 2001 .

[40]  Minna Karstunen,et al.  Modelling time-dependent behaviour of Murro test embankment , 2010 .

[41]  Ben Leshchinsky,et al.  Numerical modeling of behavior of railway ballasted structure with geocell confinement , 2013 .

[42]  C. Taechakumthorn,et al.  Design of reinforced embankments on soft clay deposits considering the viscosity of both foundation and reinforcement , 2011 .

[43]  Xian-Zhi Huang,et al.  Bearing capacity of square footing supported by a geobelt-reinforced crushed stone cushion on soft soil , 2013 .

[44]  F Schlosser,et al.  Soil Reinforcement: general report: session no. 5 , 1983 .

[45]  Xiaoming Yang,et al.  Accelerated pavement testing of unpaved roads with geocell-reinforced sand bases , 2012 .

[46]  S. N. Moghaddas Tafreshi,et al.  A comparison of static and cyclic loading responses of foundations on geocell-reinforced sand , 2012 .

[47]  Kumbakonam R. Rajagopal,et al.  MODEL STUDIES ON GEOCELL SUPPORTED EMBANKMENTS CONSTRUCTED OVER A SOFT CLAY FOUNDATION , 2000 .

[48]  Sujit Kumar Dash,et al.  Bearing capacity of strip footings supported on geocell-reinforced sand , 2001 .

[49]  D. T. Bergado,et al.  Innovations and performances of PVD and dual function geosynthetic applications , 2004 .

[50]  Jean Binquet,et al.  Bearing Capacity Tests on Reinforced Earth Slabs , 1975 .

[51]  Jie Han,et al.  3D coupled mechanical and hydraulic modeling of a geosynthetic-reinforced deep mixed column-supported embankment , 2009 .

[52]  S. Chandrakaran,et al.  Laboratory performance of unpaved roads reinforced with woven coir geotextiles , 2009 .

[53]  N. R. Krishnaswamy,et al.  Experimental and Theoretical Investigations on Geocell-Supported Embankments , 2006 .

[54]  Reza Ziaie Moayed,et al.  Numerical study on stability analysis of geocell reinforced slopes by considering the bending effect , 2013 .