Numerical simulation of laminar to turbulent nanofluid flow and heat transfer over a backward-facing step

This paper presents a numerical study of heat transfer to turbulent and laminar Cu/water flow over a backward-facing step. Mathematical model based on finite volume method with a FORTRAN code is used to solve the continuity, momentum, energy and turbulence equations. Turbulence was modeled by the shear stress transport (SST) K-ω Model. In this simulation, three volume fractions of nanofluid (0%, 2% and 4%), a varying Reynolds number from 50 to 200 for the laminar range and 5000 to 20,000 for the turbulent range, an expansion ratio of 2 and constant heat flux of 4000 W/m2 were considered. The results show the effect of nanofluid volume fraction on enhancing the Nusselt number in the laminar and turbulent ranges. The effect of expansion ratio was clearly observed at the downstream inlet region where the peak of the Nusselt number profile was referred to as enhanced heat transfer due to the generated recirculation flow. An increase of pressure drop was evident with an increasing Reynolds number and decreasing nanofluid volume fraction, while the maximum pressure drop was detected in the downstream inlet region. A rising Reynolds number caused an increasing Nusselt number, and the highest heat transfer augmentation in the present investigation was about 26% and 36% for turbulent and laminar range, respectively compared with pure water.

[1]  Hsuan-Tsung Hsieh,et al.  Turbulent separated convection flow adjacent to backward-facing step—effects of step height , 2006 .

[2]  K. Khanafer,et al.  A critical synthesis of thermophysical characteristics of nanofluids , 2011 .

[3]  R. J. Goldstein,et al.  Laminar Separation, Reattachment, and Transition of the Flow Over a Downstream-Facing Step , 1970 .

[4]  R. Saidur,et al.  Buoyancy-assisted mixed convective flow over backward-facing step in a vertical duct using nanofluids , 2012 .

[5]  C. Chon,et al.  Empirical correlation finding the role of temperature and particle size for nanofluid (Al2O3) thermal conductivity enhancement , 2005 .

[6]  Salim Newaz Kazi,et al.  An experimental study of heat transfer to turbulent separation fluid flow in an annular passage , 2011 .

[7]  B. Armaly,et al.  Experimental and theoretical investigation of backward-facing step flow , 1983, Journal of Fluid Mechanics.

[8]  E. G. Filetti,et al.  Heat Transfer in Separated, Reattached, and Redevelopment Regions Behind a Double Step at Entrance to a Flat Duct , 1967 .

[9]  Young I Cho,et al.  Separation and reattachment of non-newtonian fluid flows in a sudden expansion pipe , 1990 .

[10]  Goodarz Ahmadi,et al.  Investigation of nanofluid mixed convection in a shallow cavity using a two-phase mixture model , 2014 .

[11]  Mazlan Abdul Wahid,et al.  Combined Convection Heat Transfer of Nanofluids Flow over Forward Facing Step in a Channel Having a Blockage , 2013 .

[12]  Yuh-Ming Ferng,et al.  Investigating flow and heat transfer characteristics in a fuel bundle with split-vane pair grids by CFD methodology , 2014 .

[13]  Ahmad Badarudin Bin Mohamad Badry.  Numerical simulation of heat transfer to separation air flow in an annular pipe , 2012 .

[14]  V. V. Sychev.  Laminar separation , 1972 .

[15]  Mazlan Abdul Wahid,et al.  Effect of Vertical Baffle Installation on Forced Convective Heat Transfer in Channel Having a Backward Facing Step , 2013 .

[16]  A. Behzadmehr,et al.  A new model for calculating the effective viscosity of nanofluids , 2009 .

[17]  C. T. Nguyen,et al.  New temperature dependent thermal conductivity data for water-based nanofluids , 2009 .

[18]  O. Manca,et al.  A numerical study of nanofluid forced convection in ribbed channels , 2012 .

[19]  Kannan M. Munisamy,et al.  The effect of step height of microscale backward-facing step on mixed convection nanofluid flow and heat transfer characteristics , 2014 .

[20]  Bassem F. Armaly,et al.  Reattachment of Three-Dimensional Flow Adjacent to Backward-Facing Step , 2002 .

[21]  Cha'o-Kuang Chen,et al.  Natural convection heat transfer and entropy generation in wavy-wall enclosure containing water-based nanofluid , 2013 .

[22]  Mohammad Reza Safaei,et al.  Numerical study of laminar mixed convection heat transfer of power-law non-Newtonian fluids in square enclosures by finite volume method , 2011 .

[23]  Mohammad Reza Safaei,et al.  Numerical investigation of laminar and turbulent mixed convection in a shallow water-filled enclosure by various turbulence methods , 2011 .

[24]  E. Abu-Nada.  Application of nanofluids for heat transfer enhancement of separated flows encountered in a backward facing step , 2008 .

[25]  R. A. Seban,et al.  Heat Transfer to Separated and Reattached Subsonic Turbulent Flows Obtained Downstream of a Surface Step , 1959 .

[26]  A. Ede,et al.  Effect on the Local Heat-Transfer Coefficient in a Pipe of an Abrupt Disturbance of the Fluid Flow: Abrupt Convergence and Divergence of Diameter Ratio 2/1: , 1956 .

[27]  Mohd Nashrul Mohd Zubir,et al.  Numerical simulation of heat transfer to separation air flow in an annular pipe , 2012 .

[28]  Ahmad Badarudin,et al.  Computational simulation of heat transfer to separation fluid flow in an annular passage , 2013 .

[29]  Rahman Saidur,et al.  Convective heat transfer and fluid flow study over a step using nanofluids: A review , 2011 .

[30]  Mohammad Reza Safaei,et al.  Numerical modeling of turbulence mixed convection heat transfer in air filled enclosures by finite volume method , 2011 .

[31]  H. Mohammed,et al.  Influence of Nanofluids on Mixed Convective Heat Transfer over a Horizontal Backward-Facing Step , 2011 .

[32]  Mohd Khairol Anuar Mohd Ariffin,et al.  Heat Transfer to Laminar Flow over a Double Backward-Facing Step , 2013 .

[33]  Hosni I. Abu-Mulaweh,et al.  Investigations on the Effect of Backward-Facing and Forward-Facing Steps on Turbulent Mixed-Convection Flow Over a Flat Plate , 2009 .

[34]  R. A. Seban.  The Effect of Suction and Injection on the Heat Transfer and Flow in a Turbulent Separated Airflow , 1966 .

[35]  Mohd Khairol Anuar Mohd Ariffin,et al.  Numerical study of turbulent heat transfer in separated flow: review , 2013 .

[36]  Chia-Jung Hsu.  Numerical Heat Transfer and Fluid Flow , 1981 .

[37]  Goodarz Ahmadi,et al.  Numerical Study of Entropy Generation in a Flowing Nanofluid Used in Micro- and Minichannels , 2013, Entropy.

[38]  Bader Al-Azmi,et al.  Mixed convection analysis of laminar pulsating flow and heat transfer over a backward-facing step , 2008 .

[39]  Norshah Hafeez Shuaib,et al.  Laminar forced convection flow over a backward facing step using nanofluids , 2010 .

[40]  A. Badarudin,et al.  A Review of Experimental Study of Turbulent Heat Transfer in Separated Flow , 2011 .

[41]  Mohd Khairol Anuar Mohd Ariffin,et al.  Heat Transfer and Turbulent Fluid Flow over Vertical Double Forward-Facing Step , 2014 .

[42]  Hussein A. Mohammed,et al.  The effect of nanofluids flow on mixed convection heat transfer over microscale backward-facing step , 2012 .

[43]  A. Ranjbar,et al.  Effect of Axial Conduction and Variable Properties on Two- Dimensional Conjugate Heat Transfer of Al2O3-EG/Water Mixture Nanofluid in Microchannel , 2012 .

[44]  F. Menter.  Two-equation eddy-viscosity turbulence models for engineering applications , 1994 .

[45]  Mohd Khairol Anuar Mohd Ariffin,et al.  Numerical Study of Turbulent Heat Transfer in Annular Pipe with Sudden Contraction , 2013 .

[46]  Ahmad Badarudin,et al.  CFD Simulation of Heat Transfer and Turbulent Fluid Flow over a Double Forward-Facing Step , 2013 .

[47]  Arash Karimipour,et al.  Numerical investigation of turbulence mixed convection heat transfer of water and drilling mud inside a square enclosure by finite volume method , 2012 .

[48]  Bassem F. Armaly,et al.  Reattachment of Three-Dimensional Flow Adjacent to Backward-Facing Step , 2002 .

[49]  Wolfgang Kinzelbach,et al.  Laminar separation on a forward facing step , 1999 .

[50]  S. J. Kline,et al.  Experimental Investigation of Subsonic Turbulent Flow Over Single and Double Backward Facing Steps , 1962 .

[51]  H. W. Iversen,et al.  An Investigation of Aircraft Heaters XXVII : Distribution of Heat-transfer Rate in the Entrance Section of a Circular Tube , 1948 .

[52]  H. Mohammed,et al.  Mixed Convection Over a Backward-Facing Step in a Vertical Duct Using Nanofluids—Buoyancy Opposing Case , 2014 .