Influence of Recirculation Flow Rate On The Performance of Anaerobic Packed-bed Bioreactors Treating Potato-Waste Leachate

The performance of anaerobic, packed-bed bioreactors treating leachate from potato waste was evaluated in terms of organic loading rate (OLR) as well as the recirculation flow rate. Two 1 litre bioreactors, filled with porous glass beads as biofilm carriers and with continuous recirculation flow rates of 10 ml min-1 and 20 ml min-1 respectively, were used in the experiment. The OLR applied to each bioreactor was increased stepwise from 4 to 12 kg chemical oxygen demand (COD) m-3d-1 by increasing feed flow rate. The methane yields decreased with increasing OLR in both bioreactors. The methane yield for the bioreactor with the lower recirculation flow rate ranged between 0.10 and 0.14 m3 CH4 kg COD-1 removed, while for the other bioreactor it was 0.14–0.20 m3 CH4 kg COD-1 removed. Both bioreactors demonstrated stable COD removal which was around 95% for the bioreactor with lower flow of recirculation while for the other it was 92%, over a range of OLRs of 4–8 kg COD m-3d-1. The bioreactor with the lower recirculation flow rate showed operational stability when a high OLR, namely 12 kg COD m-3d-1, was applied, while the other one became overloaded. There was an accumulation of volatile fatty acids which gave a corresponding drop in pH because the system had a low buffering capacity and this thus ultimately led to process failure. This study demonstrated the suitability of a packed bed bioreactor operated at lower recirculation flow rate for treating leachate from potato waste.

[1]  Jonatan Andersson,et al.  Evaluation of straw as a biofilm carrier in the methanogenic stage of two-stage anaerobic digestion of crop residues. , 2002, Bioresource technology.

[2]  Michel Roustan,et al.  Methane yield as a monitoring parameter for the start-up of anaerobic fixed film reactors. , 2002, Water research.

[3]  J. Guenthner.  The International Potato Industry , 2001 .

[4]  B Mattiasson,et al.  Evaluation of new methods for the monitoring of alkalinity, dissolved hydrogen and the microbial community in anaerobic digestion. , 2001, Water research.

[5]  O. Ayalon,et al.  Solid Waste Treatment as a High-Priority and Low- Cost Alternative for Greenhouse Gas Mitigation , 2001, Environmental management.

[6]  Hanqing Yu,et al.  Prediction of the Effect of Recirculation on the Effluent Quality of Anaerobic Filters by Empirical Models , 2000 .

[7]  B. Inanc,et al.  Propionic acid accumulation in anaerobic digestion of carbohydrates: an investigation on the role of hydrogen gas , 1999 .

[8]  Sergey Kalyuzhnyi,et al.  Anaerobic treatment of raw and preclarified potato-maize wastewaters in a USAB reactor , 1998 .

[9]  B. Mattiasson,et al.  Optimization of sulphide production in an anaerobic continuous biofilm process with sulphate reducing bacteria , 1997, Biotechnology Letters.

[10]  B. Schink.  Energetics of syntrophic cooperation in methanogenic degradation , 1997, Microbiology and molecular biology reviews : MMBR.

[11]  Richard E. Speece,et al.  Anaerobic Biotechnology for Industrial Wastewaters , 1996 .

[12]  D. L. Hawkes,et al.  On-line monitoring of anaerobic digestion: application of a device for continuous measurement of bicarbonate alkalinity , 1994 .

[13]  D. Defour,et al.  Field experience with different systems for biomass accumulation in anaerobic reactor technology , 1994 .

[14]  B. Kasapgil,et al.  Comparison of porous and non-porous media in upflow anaerobic filters when treating dairy wastewater , 1994 .

[15]  S. Nagai,et al.  Stability and performance of anaerobic fixed‐bed reactor packed with a saddle‐shaped slag biocarrier , 1992 .

[16]  Robert F. Hickey,et al.  Monitoring of the anaerobic methane fermentation process , 1990 .

[17]  J. G. Parker,et al.  An Integrated Low Cost System for Treatment of Potato Processing Wastewater Incorporating Anaerobic Fermentation and Phosphorus Removal , 1982 .

[18]  K. Wuhrmann,et al.  Kinetic parameters and relative turnovers of some important catabolic reactions in digesting sludge , 1978, Applied and environmental microbiology.

[19]  J. B. Kenworthy,et al.  Chemical Analysis of Ecological Materials. , 1976 .

[20]  Awwa,et al.  Standard Methods for the examination of water and wastewater , 1999 .

[21]  B. Mattiasson,et al.  Supports made from recycled glass as biofilm carriers in anaerobic packed bed treatment of high-strength wastewaters. , 1997 .

[22]  Ioannis Hadjivassilis,et al.  Treatment of wastewater from the potato chips and snacks manufacturing industry , 1997 .

[23]  K. Pinder,et al.  Utilization of volatile fatty acids in methanogenic biofilms , 1993 .

[24]  G. V. R. Marais,et al.  Effects of a recycle in upflow anaerobic sludge bed (UASB) systems , 1991 .

[25]  D. T. Hill,et al.  VOLATILE FATTY ACID RELATIONSHIPS IN ATTACHED GROWTH ANAEROBIC FERMENTERS , 1991 .

[26]  D. T. Hill.  ALKALINITY MEASUREMENTS IN ANAEROBIC DIGESTION SYSTEMS AS INFLUENCED BY ORGANIC ACID LEVEL AND ENDPOINT PH , 1990 .

[27]  D. T. Hill,et al.  Long chain volatile fatty acid relationships in anaerobic digestion of swine waste , 1988 .

[28]  D. T. Hill,et al.  Using volatile fatty acid relationships to predict anaerobic digester failure. , 1987 .

[29]  M. Dohányos,et al.  Production and Utilization of Volatile Fatty Acids in Various Types of Anaerobic Reactors , 1985 .