A novel folding blade of wind turbine rotor for effective power control

A concept of novel folding blade of horizontal axis wind turbine is proposed in current study. The folding blade comprises a stall regulated root blade section and a folding tip blade section with the fold axis inclined relative to blade span. By folding blade, lift force generated on the tip blade section changes and the moment arm also shortens, which leads to variations of power output. The blade folding actuation mechanism with servo motor and worm-gear reducer was designed. Wind turbine rotor control scheme and servo system with double feedback loops for blade fold angle control were proposed. In this study, a small folding blade model was tested in a wind tunnel to analyze its performance. The blade model performance was estimated in terms of rotation torque coefficient and thrust coefficient. Wind tunnel experiments were also conducted for pitch control using the same blade model in order to make a direct comparison. The power control, start up and aerodynamic brake performance of the folding blade were analyzed. According to the wind tunnel experiment results, fold angle magnitude significantly affected blade aerodynamic performance and the thrust characteristic together with the rotation torque characteristic of folding blade were revealed. The experiment results demonstrated that the folding blade was valid to control power output and had advantages in reducing thrust with maximum reduction of 51.1% compared to pitch control. Optimum fold angles of 55° and 90° were also found for start up and aerodynamic brake, respectively.

[1]  Yukimaru Shimizu,et al.  Power Augmentation Effects of a Horizontal Axis Wind Turbine With a Tip Vane—Part 2: Flow Visualization , 1994 .

[2]  Alan Wright,et al.  Adding feedforward blade pitch control to standard feedback controllers for load mitigation in wind turbines , 2011 .

[3]  David A. Johnson,et al.  An evaluation testbed for wind turbine blade tip designs–baseline case , 2011 .

[4]  Fernando D. Bianchi,et al.  Power regulation in pitch-controlled variable-speed WECS above rated wind speed , 2004 .

[5]  Yukimaru Shimizu,et al.  Power Augmentation Effects of a Horizontal Axis Wind Turbine With a Tip Vane—Part 1: Turbine Performance and Tip Vane Configuration , 1994 .

[6]  Poul Ejnar Sørensen,et al.  Design of a wind turbine pitch angle controller for power system stabilisation , 2007 .

[7]  Erich Hau,et al.  Wind Turbines: Fundamentals, Technologies, Application, Economics , 1999 .

[8]  Wen Tong Chong,et al.  Early development of an energy recovery wind turbine generator for exhaust air system , 2013 .

[9]  Tareq Saber Abuaisha.  General study of the control principles and dynamic fault behaviour of variable-speed wind turbine and wind farm generic models , 2014 .

[10]  Martin Otto Laver Hansen,et al.  Aerodynamics of Wind Turbines , 2001 .

[11]  Vaughn Nelson.  Wind Energy: Renewable Energy and the Environment , 2009 .

[12]  Abul K. M. Azad,et al.  Flexible Robot Manipulators: Modelling, simulation and control , 2017 .

[13]  Koji Kikuyama,et al.  Numerical Analysis of the Horizontal Axis Wind Turbine with Winglets. , 1998 .

[14]  P. N. Vosburgh,et al.  Commercial applications of wind power , 1983 .

[15]  G.J.W. Van Bussel,et al.  Power Augmentation of a Horizontal Axis Wind Turbine Using a Mie Type Tip Vane: Velocity Distribution Around the Tip of a HAWT Blade With and Without a Mie Type Tip Vane , 1995 .

[16]  M. A. Chowdhury,et al.  Smoothing wind power fluctuations by fuzzy logic pitch angle controller , 2012 .

[17]  Fabricio Garelli,et al.  Variable structure strategy to avoid amplitude and rate saturation in pitch control of a wind turbine , 2010 .

[18]  Pramod Jain,et al.  Wind Energy Engineering , 2010 .

[19]  Michele Messina,et al.  Design and performance of a double-pitch wind turbine with non-twisted blades , 2009 .

[20]  Shafiqur Rehman.  Tower distortion and scatter factors of co-located wind speed sensors and turbulence intensity behavior , 2014 .

[21]  Luai M. Al-Hadhrami.  Performance evaluation of small wind turbines for off grid applications in Saudi Arabia , 2014 .

[22]  Jeppe Johansen,et al.  Determination of the Maximum Aerodynamic Efficiency of Wind Turbine Rotors with Winglets , 2007 .

[23]  Takao Maeda,et al.  Power Augmentation of a HAWT by Mie-type Tip Vanes, considering Wind Tunnel Flow Visualisation, Blade-Aspect Ratios and Reynolds Number , 2003 .

[24]  Rachid Nasri,et al.  Dynamic response of a horizontal axis wind turbine blade under aerodynamic, gravity and gyroscopic effects , 2014 .

[25]  F. Poitiers,et al.  Advanced control of a doubly-fed induction generator for wind energy conversion , 2009 .

[26]  Ahmet Serdar Yilmaz,et al.  Pitch angle control in wind turbines above the rated wind speed by multi-layer perceptron and radial basis function neural networks , 2009, Expert Syst. Appl..

[27]  Simon Joncas,et al.  Preliminary design of large wind turbine blades using layout optimization techniques , 2004 .

[28]  H. Camblong.  Digital robust control of a variable speed pitch regulated wind turbine for above rated wind speeds , 2008 .

[29]  J. Tlusty,et al.  Feedforward and feedback control of a flexible robotic arm , 1990, IEEE Control Systems Magazine.

[30]  Ervin Bossanyi,et al.  Wind Energy Handbook , 2001 .

[31]  Kazumasa Ameku,et al.  PERFORMANCE OF A 3 KW WIND TURBINE GENERATOR WITH VARIABLE PITCH CONTROL SYSTEM , 2009 .

[32]  W. Leithead,et al.  Control of variable speed wind turbines: Dynamic models , 2000 .

[33]  Ahmed A. El-Sattar,et al.  Dynamic response of doubly fed induction generator variable speed wind turbine under fault , 2008 .

[34]  W. Leithead,et al.  Control of variable speed wind turbines: Design task , 2000 .

[35]  Eunkuk Son,et al.  Blade pitch angle control for aerodynamic performance optimization of a wind farm , 2013 .

[36]  William D'haeseleer,et al.  The actual effect of wind power on overall electricity generation costs and CO2 emissions , 2009 .

[37]  Mao-Hsiung Chiang,et al.  A novel pitch control system for a wind turbine driven by a variable-speed pump-controlled hydraulic servo system , 2011 .

[38]  Z. Luo.  Direct strain feedback control of flexible robot arms: new theoretical and experimental results , 1993, IEEE Trans. Autom. Control..

[39]  Lotfi Krichen,et al.  Rotor power control in doubly fed induction generator wind turbine under grid faults , 2012 .

[40]  N. Horiuchi,et al.  Torque and power limitations of variable speed wind turbines using pitch control and generator power control , 2001, 2001 Power Engineering Society Summer Meeting. Conference Proceedings (Cat. No.01CH37262).

[41]  Maureen Hand,et al.  Multivariable control strategy for variable speed, variable pitch wind turbines , 2007 .

[42]  Andreas Sumper,et al.  Modeling and control of the doubly fed induction generator wind turbine , 2010, Simul. Model. Pract. Theory.