Enhanced concentration polarization by unstirred fouling layers in reverse osmosis: Detection by sodium chloride tracer response technique

Abstract This paper describes a sodium chloride tracer response technique, to determine the effect of fouling on concentration polarization level in a reverse osmosis (RO) system operated in the constant flux mode. Colloidal silica and alginic acid were used as model fouling agents. It was found that the formation of the ‘unstirred’ fouling layer greatly exacerbated the concentration polarization (CP) level in RO separations, with a more pronounced effect at high flux operation. The results suggested that operation at high flux could significantly reduce the apparent permeability, but that this is through a dramatic increase in CP and consequent loss in driving force via the enhanced osmotic pressure rather than through an additional hydraulic resistance. The study also shows that the sodium chloride tracer response technique is a promising technique that can be applied as a non-invasive tool to detect and monitor fouling development in reverse osmosis.

[1]  Chai-fu Pan.  Activity and osmotic coefficients in dilute aqueous solutions of uni-univalent electrolytes at 25.degree.C , 1977 .

[2]  S. Bhattacharjee,et al.  Coupled model of concentration polarization and pore transport in crossflow nanofiltration , 2001 .

[3]  How Yong Ng.  RO membrane solute rejection behavior at the initial stage ofcolloidal fouling , 2005 .

[4]  D. Nivens,et al.  Role of Alginate and Its O Acetylation in Formation of Pseudomonas aeruginosa Microcolonies and Biofilms , 2001, Journal of bacteriology.

[5]  Jianji Wang,et al.  The interaction of sodium alginate with univalent cations , 1998 .

[6]  J. Pope,et al.  An investigation of concentration polarization phenomena in membrane filtration of colloidal silica suspensions by NMR micro-imaging , 1998 .

[7]  How Yong Ng,et al.  Influence of colloidal fouling on rejection of trace organic contaminants by reverse osmosis , 2004 .

[8]  Menachem Elimelech,et al.  A novel approach for modeling concentration polarization in crossflow membrane filtration based on the equivalence of osmotic pressure model and filtration theory , 1998 .

[9]  M. Elimelech,et al.  Cake-enhanced concentration polarization: a new fouling mechanism for salt-rejecting membranes. , 2003, Environmental science & technology.

[10]  O. Levenspiel.  Chemical Reaction Engineering , 1972 .

[11]  E. Verwey,et al.  Theory of the stability of lyophobic colloids. , 1955, The Journal of physical and colloid chemistry.

[12]  Menachem Elimelech,et al.  Influence of Crossflow Membrane Filter Geometry and Shear Rate on Colloidal Fouling in Reverse Osmosis and Nanofiltration Separations , 2002 .

[13]  Eric M.V. Hoek,et al.  Modeling concentration polarization in reverse osmosis processes , 2005 .

[14]  James M. Pope,et al.  Non-invasive observation of flow profiles and polarisation layers in hollow fibre membrane filtration modules using NMR micro-imaging , 1995 .

[15]  B. Fabre,et al.  Sodium chloride stimulus-response experiments in spiral wound reverse osmosis membranes: a new method to detect fouling , 1999 .

[16]  H. Bauser,et al.  Experimental in situ measurement of concentration polarisation during ultra- and micro-filtration of bovine serum albumin and Dextran Blue solutions , 1995 .

[17]  B. Derjaguin,et al.  Theory of the stability of strongly charged lyophobic sols and of the adhesion of strongly charged particles in solutions of electrolytes , 1993 .

[18]  Menachem Elimelech,et al.  Colloidal Fouling of Reverse Osmosis Membranes: Measurements and Fouling Mechanisms , 1997 .

[19]  Menachem Elimelech,et al.  Theory of concentration polarization in crossflow filtration , 1995 .

[20]  Menachem Elimelech,et al.  In situ monitoring techniques for concentration polarization and fouling phenomena in membrane filtration. , 2003, Advances in colloid and interface science.

[21]  S. Gupta,et al.  Analysis of modified surface force pore flow model with concentration polarization and comparison with Spiegler¿Kedem model in reverse osmosis systems , 2004 .