Techno-economic analysis of wastewater sludge gasification: a decentralized urban perspective.

The successful management of wastewater sludge for small-scale, urban wastewater treatment plants, (WWTPs), faces several financial and environmental challenges. Common management strategies stabilize sludge for land disposal by microbial processes or heat. Such approaches require large footprint processing facilities or high energy costs. A new approach considers converting sludge to fuel which can be used to produce electricity on-site. This work evaluated several thermochemical conversion (TCC) technologies from the perspective of small urban WWTPs. Among TCC technologies, air-blown gasification was found to be the most suitable approach. A gasification-based generating system was designed and simulated in ASPEN Plus® to determine net electrical and thermal outputs. A technical analysis determined that such a system can be built using currently available technologies. Air-blown gasification was found to convert sludge to electricity with an efficiency greater than 17%, about triple the efficiency of electricity generation using anaerobic digester gas. This level of electricity production can offset up to 1/3 of the electrical demands of a typical WWTP. Finally, an economic analysis concluded that a gasification-based power system can be economically feasible for WWTPs with raw sewage flows above 0.093m(3)/s (2.1 million gallons per day), providing a profit of up to $3.5 million over an alternative, thermal drying and landfill disposal.

[1]  Olivier Jolliet,et al.  Life cycle assessment of processes for the treatment of wastewater urban sludge: energy and global warming analysis , 2005 .

[2]  José Antônio Perrella Balestieri,et al.  Energetic and exergetic analysis in a firewood boiler , 2004 .

[3]  J. Foussard,et al.  Subcritical wet oxidation of municipal sewage sludge: comparison of batch and continuous experiments. , 2001, Water science and technology : a journal of the International Association on Water Pollution Research.

[4]  A. Reynolds,et al.  Simulation of a Circulating Fluidised Bed Biomass Gasifier using ASPEN Plus: a Performance Analysis , 2008 .

[5]  C. Aichernig,et al.  Biomass CHP Plant Güssing – Using Gasification for Power Generation , 2002 .

[6]  A. Reynolds,et al.  The effect of air preheating in a biomass CFB gasifier using ASPEN Plus simulation , 2009 .

[7]  Arnaldo Walter,et al.  Performance evaluation of atmospheric biomass integrated gasifier combined cycle systems under different strategies for the use of low calorific gases , 2007 .

[8]  W. Rulkens.  Sewage Sludge as a Biomass Resource for the Production of Energy: Overview and Assessment of the Various Options† , 2008 .

[9]  James W Griffith,et al.  The first commercial supercritical water oxidation sludge processing plant. , 2002, Waste management.

[10]  J. Werther,et al.  Sewage sludge combustion , 1999 .

[11]  Ger Devlin,et al.  A review of recent laboratory research and commercial developments in fast pyrolysis and upgrading , 2011 .

[12]  Eric D. Larson,et al.  Gasification-Based Fuels and Electricity Production from Biomass, without and with Carbon Capture and Storage , 2005 .

[13]  A. Gupta,et al.  High temperature steam gasification of wastewater sludge , 2010 .

[14]  J. A. Menéndez,et al.  On the pyrolysis of sewage sludge: the influence of pyrolysis conditions on solid, liquid and gas fractions , 2002 .

[15]  G. P. Reed,et al.  Trace Element Distribution in Sewage Sludge Gasification: Source and Temperature Effects , 2005 .

[16]  S. Turns.  An Introduction to Combustion: Concepts and Applications , 2000 .

[17]  H. Kwon,et al.  Urban energy mining from sewage sludge. , 2013, Chemosphere.

[18]  Samsudin Anis,et al.  Tar reduction in biomass producer gas via mechanical, catalytic and thermal methods: A review , 2011 .

[19]  Fan Yang,et al.  Hydrogen-rich gas from catalytic steam gasification of municipal solid waste (MSW): Influence of catalyst and temperature on yield and product composition , 2009 .

[20]  Benjamin Phillips,et al.  Economic and Technical Assessment of Wood Biomass Fuel Gasification for Industrial Gas Production , 2007 .

[21]  D. Vamvuka,et al.  Bio‐oil, solid and gaseous biofuels from biomass pyrolysis processes—An overview , 2011 .

[22]  Roman Weber,et al.  Investigation of ash deposit formation during co-firing of coal with sewage sludge, saw-dust and refuse derived fuel , 2008 .

[23]  A. Bridgwater.  Review of fast pyrolysis of biomass and product upgrading , 2012 .

[24]  G. Boissonnet,et al.  Evaluation of biomass gasification in supercritical water process for hydrogen production , 2005 .

[25]  Willard W. Pulkrabek,et al.  Engineering Fundamentals of the Internal Combustion Engine , 1997 .

[26]  Sebastian Werle,et al.  A review of methods for the thermal utilization of sewage sludge: The Polish perspective , 2010 .

[27]  Firdaus Basrawi,et al.  Effect of ambient temperature on the performance of micro gas turbine with cogeneration system in cold region , 2011 .

[28]  A. Bejan,et al.  Heat transfer handbook , 2003 .

[29]  Enrico Biagini,et al.  Devolatilization rate of biomasses and coal–biomass blends: an experimental investigation , 2002 .

[30]  A. Bridgwater.  The technical and economic feasibility of biomass gasification for power generation , 1995 .

[31]  Michel Feidt,et al.  Estimation of the Energy Efficiency of a Wood Gasification CHP Plant Using Aspen Plus , 2012 .

[32]  M. Azuara,et al.  Sewage sludge pyrolysis for liquid production: A review , 2012 .

[33]  Jesús Arauzo,et al.  Air Gasification of Dried Sewage Sludge in a Fluidized Bed: Effect of the Operating Conditions and In-Bed Use of Alumina , 2005 .

[34]  Hongming Xu,et al.  Characterisation of waste derived intermediate pyrolysis oils for use as diesel engine fuels , 2013 .

[35]  Arpad Horvath,et al.  Hybrid life-cycle environmental and cost inventory of sewage sludge treatment and end-use scenarios: a case study from China. , 2008, Environmental science & technology.

[36]  Luca Fiori,et al.  Supercritical water gasification of biomass for H2 production: process design. , 2012, Bioresource technology.

[37]  Tzahi Y. Cath,et al.  Evaluating air-blown gasification for energy recovery from wastewater solids: Impact of biological treatment and point of generation on energy recovery , 2015 .

[38]  Anthony V. Bridgwater,et al.  Renewable fuels and chemicals by thermal processing of biomass , 2003 .

[39]  Klaus D. Timmerhaus,et al.  Plant design and economics for chemical engineers , 1958 .

[40]  Peter McKendry,et al.  Energy production from biomass (Part 2): Conversion technologies. , 2002, Bioresource technology.

[41]  Chao Gai,et al.  Experimental study on non-woody biomass gasification in a downdraft gasifier , 2012 .

[42]  J. Kim,et al.  Drying characteristics of sewage sludge , 2011 .

[43]  Ryan Michael Swanson,et al.  Techno-Economic Analysis of Biofuels Production Based on Gasification , 2010 .

[44]  Bert Van de Beld,et al.  The use of pyrolysis oil and pyrolysis oil derived fuels in diesel engines for CHP applications , 2013 .

[45]  Daren E. Daugaard,et al.  Techno-Economic Analysis of Biomass Fast Pyrolysis to Transportation Fuels , 2010 .

[46]  Alberto Coronas,et al.  Review and analysis of biomass gasification models , 2010 .

[47]  Stephanie Thalberg,et al.  Wastewater Engineering Treatment Disposal And Reuse , 2016 .

[48]  Á. Bereczky,et al.  Sewage sludge producer gas enriched with methane as a fuel to a spark ignited engine , 2013 .

[49]  Chao He,et al.  Conversion of sewage sludge to clean solid fuel using hydrothermal carbonization: Hydrochar fuel characteristics and combustion behavior , 2013 .

[50]  Peter McKendry,et al.  Energy production from biomass (Part 3): Gasification technologies. , 2002, Bioresource technology.

[51]  George Tchobanoglous,et al.  Wastewater Engineering Treatment Disposal Reuse , 1972 .

[52]  Liselotte Schebek,et al.  Economic analysis of sewage sludge gasification in supercritical water for hydrogen production. , 2008 .

[53]  N. Mahinpey,et al.  Simulation of biomass gasification in fluidized bed reactor using ASPEN PLUS. , 2008 .

[54]  J. Baeyens,et al.  Fluidized bed waste incinerators: Design, operational and environmental issues , 2012 .

[55]  Isabel Cabrita,et al.  The study of reactions influencing the biomass steam gasification process , 2003 .

[56]  A. Gupta,et al.  Hydrogen and syngas production from sewage sludge via steam gasification , 2010 .

[57]  Anastasia Zabaniotou,et al.  Towards sewage sludge based biofuels via thermochemical conversion – A review , 2012 .

[58]  G. K. Anderson,et al.  Wet oxidation of activated sludge , 1999 .

[59]  S. McPhail,et al.  Fuel Gas Clean-up and Conditioning , 2012 .

[60]  Jered H. Dean,et al.  System Analysis of Thermochemical-Based Biorefineries for Coproduction of Hydrogen and Electricity , 2011 .

[61]  Stéphane Godbout,et al.  Biofuels Production from Biomass by Thermochemical Conversion Technologies , 2012 .

[62]  Simon Judd,et al.  Thermochemical Treatment of Sewage Sludge , 2000 .

[63]  Marco Baratieri,et al.  The use of biomass syngas in IC engines and CCGT plants: A comparative analysis , 2009 .

[64]  Thana Phuphuakrat,et al.  Characterization of tar content in the syngas produced in a downdraft type fixed bed gasification system from dried sewage sludge , 2010 .

[65]  Anastasia Zabaniotou,et al.  Energetic assessment of a combined heat and power integrated biomass gasification–internal combustion engine system by using Aspen Plus® , 2012 .

[66]  Kristina Göransson,et al.  Simulation of biomass gasification in a dual fluidized bed gasifier , 2012 .

[67]  Woo-Chan Lee,et al.  Gasification and its emission characteristics for dried sewage sludge utilizing a fluidized bed gasifier , 2011 .

[68]  Peter Howsam,et al.  Biosolids--a fuel or a waste? An integrated appraisal of five co-combustion scenarios with policy analysis. , 2006, Environmental science & technology.

[69]  R. Steeper,et al.  The hydrogen-fueled internal combustion engine : a technical review. , 2006 .

[70]  A. Aden,et al.  Thermochemical Ethanol via Indirect Gasification and Mixed Alcohol Synthesis of Lignocellulosic Biomass , 2007 .

[71]  Umberto Arena,et al.  A techno-economic comparison between two design configurations for a small scale, biomass-to-energy gasification based system , 2010 .

[72]  Robert C. Brown,et al.  Ancillary equipment for biomass gasification , 2002 .

[73]  Anastasia Zabaniotou,et al.  Utilization of sewage sludge in EU application of old and new methods--A review , 2008 .

[74]  M. E. Sánchez,et al.  Effect of pyrolysis temperature on the composition of the oils obtained from sewage sludge , 2009 .

[75]  Patricia Arlabosse,et al.  Drying of municipal sewage sludge: from a laboratory scale batch indirect dryer to the paddle dryer , 2005 .

[76]  Jesper Ahrenfeldt,et al.  The design, construction and operation of a 75kW two-stage gasifier , 2006 .

[77]  Kunio Yoshikawa,et al.  Recent progresses in catalytic tar elimination during biomass gasification or pyrolysis—A review , 2013 .

[78]  Juan A. Conesa,et al.  Evolution of gases in the primary pyrolysis of different sewage sludges , 1998 .

[79]  G. Raghavan,et al.  Evaluation of an Energy Production System from Sewage Sludge Using a Pilot-Scale Downdraft Gasifier , 2013 .

[80]  David Chiaramonti,et al.  Power generation using fast pyrolysis liquids from biomass , 2007 .

[81]  Ian C. Kemp,et al.  Reducing Dryer Energy Use by Process Integration and Pinch Analysis , 2005 .

[82]  S. D. Probert,et al.  Harnessing energy from domestic, municipal and industrial refuse , 1987 .

[83]  Y Kim,et al.  A technical and economic evaluation of the pyrolysis of sewage sludge for the production of bio-oil. , 2008, Bioresource technology.

[84]  Chi Wai Hui,et al.  Process design and feasibility study for small scale MSW gasification , 2004 .

[85]  K. Kimmerle,et al.  Energy recovery from sewage sludge by means of fluidised bed gasification. , 2008, Waste management.

[86]  A. Ashraf,et al.  Simulation of hybrid biomass gasification using Aspen plus: A comparative performance analysis for food, municipal solid and poultry waste , 2011 .