Reduction of Mercury Loss in Fluorescent Lamps Coated with Thin Metal-Oxide Films

The absorption of mercury into glass and metal-oxide coated glass tubes is investigated with the aid of Rutherford backscattering spectroscopy (RBS), X-ray photoelectron spectroscopy (XPS), low-energy ion scattering, and thermal desorption mass spectroscopy. The absorption reaction of bare glass with activated mercury species is strongly reduced when the glass is covered with a thin oxide film. The concentration profile of the mercury measured in the films with the aid of RBS varied between a homogeneous distribution and a higher concentration of mercury close to the discharge side of the coating. XPS showed that the oxidation state of the mercury at the surface of the coatings was between that of metallic mercury and mercury(II) oxide. Thermal desorption mass spectroscopy showed that at least two different states of bound mercury were involved. The combination of the thermal desorption mass spectroscopy and XPS led to the conclusion that direct mercury-metal-oxide interactions contribute to the bonding of the mercury.

[1]  T. Duc,et al.  Charge Transfer in Amorphous Colored WO3Films Observed by X-Ray Photoelectron Spectroscopy , 1976 .

[2]  J. Niemantsverdriet,et al.  THERMAL DESORPTION ANALYSIS: COMPARATIVE TEST OF TEN COMMONLY APPLIED PROCEDURES , 1990 .

[3]  Klaus Bange,et al.  Optical absorption of amorphous WO3 and binding state of tungsten , 1990 .

[4]  P. Ackermans,et al.  Simultaneous energy and angle resolved ion scattering spectroscopy , 1988 .

[5]  E. Paparazzo.  XPS studies of damage induced by X-ray irradiation on CeO2 surfaces , 1990 .

[6]  K. Rademann.  Electronic structures and properties of microclusters: cadmium and mercury , 1993 .

[7]  S. Heusden,et al.  Mechanism of the darkening of soda—lime glass by a low-pressure mercury vapour discharge , 1981 .

[8]  H. Bertagnolli,et al.  Experimental studies investigating the structure of soda-lime glasses after silver-sodium ion exchange , 1997 .

[9]  K. Kunimori,et al.  Plasma-Induced Chemisorption of Nitrogen and Its Chemical Reactivity on Alumina , 1994 .

[10]  J. A. Taylor,et al.  Empirical atomic sensitivity factors for quantitative analysis by electron spectroscopy for chemical analysis , 1981 .

[11]  V. D. Hildenbrand,et al.  Interactions of thin oxide films with a low-pressure mercury discharge , 2000 .

[12]  P. Redhead.  Thermal desorption of gases , 1962 .

[13]  Lawrence R. Doolittle,et al.  Algorithms for the rapid simulation of Rutherford backscattering spectra , 1985 .

[14]  T. A. Dang,et al.  Identification of Mercury Reaction Sites in Fluorescent Lamps , 1999 .

[15]  Y. Otani,et al.  Adsorption of mercury vapor on particles. , 1986, Environmental science & technology.

[16]  H. Brongersma,et al.  Application of low energy ion scattering to oxidic surfaces , 1995 .

[17]  S. Heusden,et al.  Interaction of a low-pressure mercury discharge with the discharge tube wall , 1980 .

[18]  M. Kuhn,et al.  Interaction of Silver, Cesium, and Zinc with Alumina Surfaces: Thermal Desorption and Photoemission Studies , 1996 .

[19]  Janusz Nowotny,et al.  Science of ceramic interfaces II , 1994 .

[20]  E. G. Thaler,et al.  Mercury‐Glass Interactions in Fluorescent Lamps , 1995 .

[21]  P. Biswas,et al.  Capture of Mercury in Combustion Systems by In Situ–Generated Titania Particles with UV Irradiation , 1998 .

[22]  D. R. Penn,et al.  Calculations of electron inelastic mean free paths for 31 materials , 1988 .

[23]  S. Heusden,et al.  Mechanism of Glass Darkening by a Low Pressure Mercury Discharge , 1983 .

[24]  P. Mu,et al.  Analysis of the outermost atomic layer of a surface by low-energy ion scattering , 1973 .