Influence of size-induced oxidation state of platinum nanoparticles on selectivity and activity in catalytic methanol oxidation in the gas phase.

Pt nanoparticles with various sizes of 1, 2, 4, and 6 nm were synthesized and studied as catalysts for gas-phase methanol oxidation reaction toward formaldehyde and carbon dioxide under ambient pressure (10 Torr of methanol, 50 Torr of oxygen, and 710 Torr of helium) at a low temperature of 60 °C. While the 2, 4, and 6 nm nanoparticles exhibited similar catalytic activity and selectivity, the 1 nm nanoparticles showed a significantly higher selectivity toward partial oxidation of methanol to formaldehyde, but a lower total turnover frequency. The observed size effect in catalysis was correlated to the size-dependent structure and oxidation state of the Pt nanoparticles. X-ray photoelectron spectroscopy and infrared vibrational spectroscopy using adsorbed CO as molecular probes revealed that the 1 nm nanoparticles were predominantly oxidized while the 2, 4, and 6 nm nanoparticles were largely metallic. Transmission electron microscopy imaging witnessed the transition from crystalline to quasicrystalline structure as the size of the Pt nanoparticles was reduced to 1 nm. The results highlighted the important impact of size-induced oxidation state of Pt nanoparticles on catalytic selectivity as well as activity in gas-phase methanol oxidation reactions.

[1]  H. Einaga,et al.  Photochemical preparation of poly(N-vinyl-2-pyrrolidone)-stabilized platinum colloids and their deposition on titanium dioxide. , 2005, Langmuir : the ACS journal of surfaces and colloids.

[2]  Peidong Yang,et al.  Sub-10 nm platinum nanocrystals with size and shape control: catalytic study for ethylene and pyrrole hydrogenation. , 2009, Journal of the American Chemical Society.

[3]  Minhua Shao,et al.  Electrocatalysis on platinum nanoparticles: particle size effect on oxygen reduction reaction activity. , 2011, Nano letters.

[4]  G. Somorjai,et al.  In situ oxidation study of Pt(110) and its interaction with CO. , 2011, Journal of the American Chemical Society.

[5]  E. Morallón,et al.  Highly dispersed platinum nanoparticles on carbon nanocoils and their electrocatalytic performance for fuel cell reactions , 2009 .

[6]  M. Bäumer,et al.  Nanoporous Gold Catalysts for Selective Gas-Phase Oxidative Coupling of Methanol at Low Temperature , 2010, Science.

[7]  G. Somorjai,et al.  Dependence of Gas-Phase Crotonaldehyde Hydrogenation Selectivity and Activity on the Size of Pt Nanoparticles (1.7–7.1 nm) Supported on SBA-15 , 2009 .

[8]  Karen Wilson,et al.  Recent advances in the heterogeneously catalysed aerobic selective oxidation of alcohols , 2011 .

[9]  G. Somorjai,et al.  From Single Pt Atoms to Pt Nanocrystals: Photoreduction of Pt2+ Inside of a PAMAM Dendrimer , 2012 .

[10]  G. Somorjai,et al.  Size and Shape Dependence on Pt Nanoparticles for the Methylcyclopentane/Hydrogen Ring Opening/Ring Enlargement Reaction , 2011 .

[11]  Size and Shape Control of Metal Nanoparticles for Reaction Selectivity in Catalysis , 2012 .

[12]  Lei Zhang,et al.  A review of anode catalysis in the direct methanol fuel cell , 2006 .

[13]  J. Maas,et al.  Correlation between CO frequency and Pt coordination number. A DRIFT study on supported Pt catalysts , 1991 .

[14]  G. Somorjai,et al.  Influence of Particle Size on Reaction Selectivity in Cyclohexene Hydrogenation and Dehydrogenation over Silica-Supported Monodisperse Pt Particles , 2008 .

[15]  W. Schirmer,et al.  Introduction to Surface Chemistry and Catalysis , 1995 .

[16]  G. Somorjai,et al.  Dendrimer templated synthesis of one nanometer Rh and Pt particles supported on mesoporous silica: catalytic activity for ethylene and pyrrole hydrogenation. , 2008, Nano letters.

[17]  G. Somorjai,et al.  Hydrogenation of benzene and toluene over size controlled Pt/SBA-15 catalysts: Elucidation of the Pt particle size effect on reaction kinetics , 2012 .

[18]  Lin-wang Wang,et al.  Furfuraldehyde hydrogenation on titanium oxide-supported platinum nanoparticles studied by sum frequency generation vibrational spectroscopy: acid-base catalysis explains the molecular origin of strong metal-support interactions. , 2012, Journal of the American Chemical Society.

[19]  V. A. Morozov,et al.  Finite Size Effects in Chemical Bonding: From Small Clusters to Solids , 2011 .

[20]  Xiaofeng Yang,et al.  Single-atom catalysis of CO oxidation using Pt1/FeOx. , 2011, Nature chemistry.

[21]  P. Somasundaran,et al.  Introduction to surface chemistry and catalysis , 1997 .

[22]  M. Daturi,et al.  FT-IR study of CO adsorption on Pt/CeO2: characterisation and structural rearrangement of small Pt particles , 2005 .

[23]  G. Somorjai,et al.  High-surface-area catalyst design: Synthesis, characterization, and reaction studies of platinum nanoparticles in mesoporous SBA-15 silica. , 2005, The journal of physical chemistry. B.

[24]  J. Nørskov,et al.  Atomic-Scale Modeling of Particle Size Effects for the Oxygen Reduction Reaction on Pt , 2011 .

[25]  Jens K Nørskov,et al.  Investigation of Catalytic Finite-Size-Effects of Platinum Metal Clusters. , 2013, The journal of physical chemistry letters.

[26]  G. Somorjai,et al.  Structure sensitivity of carbon-nitrogen ring opening: impact of platinum particle size from below 1 to 5 nm upon pyrrole hydrogenation product selectivity over monodisperse platinum nanoparticles loaded onto mesoporous silica. , 2008, Journal of the American Chemical Society.

[27]  K. Komvopoulos,et al.  Structure Sensitivity in Pt Nanoparticle Catalysts for Hydrogenation of 1,3-Butadiene: In Situ Study of Reaction Intermediates Using SFG Vibrational Spectroscopy , 2013 .

[28]  G. Somorjai,et al.  Reforming of C6 Hydrocarbons Over Model Pt Nanoparticle Catalysts , 2012, Topics in Catalysis.