Design for the Interior Permanent Magnet Synchronous Motor Drive System Based on the Z-Source Inverter

The permanent magnet synchronous motor (PMSM) running above the base speed requires flux-weakening control, which is usually realized by the direct-axis demagnetization current generated by the vector control, thus leading to a decrease in the system efficiency in the flux-weakening region. In addition, the motor power output range is limited by the inverter output voltage and current level. In this paper, a Z-Source drive PMSM control system with adjustable DC-link voltage was proposed to improve the efficiency of the motor system. The proposed system was experimentally verified. The response time of DC-link voltage is 10 ms and the overshoot is 3%, indicating good dynamic characteristics. Compared with the flux-weakening scheme, the Z-Source inverter scheme can achieve higher efficiency (about 3%) when the PMSM speed was set to 650 r/min.

[1]  Shuai Dong,et al.  Inductor Current Ripple Comparison Between ZSVM4 and ZSVM2 for Z-Source Inverters , 2016, IEEE Transactions on Power Electronics.

[2]  R. Mahanty,et al.  Single-phase high-voltage gain switched LC Z-source inverters , 2017 .

[3]  Yuan Li,et al.  Modeling and Control of Quasi-Z-Source Inverter for Distributed Generation Applications , 2013, IEEE Transactions on Industrial Electronics.

[4]  G. Narayanan,et al.  Impact of Undercompensation and Overcompensation of Dead-Time Effect on Small-Signal Stability of Induction Motor Drive , 2018, IEEE Transactions on Industry Applications.

[5]  Xiaojie You,et al.  Flux-Weakening in PMSM Drives: Analysis of Voltage Angle Control and the Single Current Controller Design , 2019, IEEE Journal of Emerging and Selected Topics in Power Electronics.

[6]  Frede Blaabjerg,et al.  Comparison of three-phase three-level voltage source inverter with intermediate dc–dc boost converter and quasi-Z-source inverter , 2016 .

[7]  M. Sabahi,et al.  A New Coupled Inductor Nonisolated High Step-Up Quasi Z-Source DC–DC Converter , 2020, IEEE Transactions on Industrial Electronics.

[8]  Ke Li,et al.  Maximum Torque per Ampere (MTPA) Control for IPMSM Drives Using Signal Injection and an MTPA Control Law , 2019, IEEE Transactions on Industrial Informatics.

[9]  Shuai Dong,et al.  Analysis of Critical Inductance and Capacitor Voltage Ripple for a Bidirectional Z -Source Inverter , 2015, IEEE Transactions on Power Electronics.

[10]  Issa Batarseh,et al.  Ultra-Highly Efficient Low-Power Bidirectional Cascaded Buck-Boost Converter for Portable PV-Battery-Devices Applications , 2019, IEEE Transactions on Industry Applications.

[11]  C. L. Philip Chen,et al.  Fuzzy Adaptive Inverse Compensation Method to Tracking Control of Uncertain Nonlinear Systems With Generalized Actuator Dead Zone , 2017, IEEE Transactions on Fuzzy Systems.

[12]  Jie Ma,et al.  Dead-Zone Compensation of an Ultrasonic Motor Using an Adaptive Dither , 2018, IEEE Transactions on Industrial Electronics.

[13]  Ebrahim Babaei,et al.  Steady-state analysis of high-voltage gain multiple series Z-source inverter , 2017 .

[14]  K. Shinohara,et al.  Characteristics of permanent-magnet synchronous motor driven by PWM inverter with voltage booster , 2004, IEEE Transactions on Industry Applications.

[15]  Bo Zhang,et al.  Enhanced boost quasi-Z-source inverters with active switched-inductor boost network , 2018 .

[16]  Siew-Chong Tan,et al.  Buck-Boost Single-Inductor Multiple-Output High-Frequency Inverters for Medium-Power Wireless Power Transfer , 2019, IEEE Transactions on Power Electronics.

[18]  Do-Hyeon Kim,et al.  Self-Tuning LCC Inverter Using PWM-Controlled Switched Capacitor for Inductive Wireless Power Transfer , 2019, IEEE Transactions on Industrial Electronics.

[19]  Bo Lu,et al.  Adaptive Dynamic Surface Control of Pneumatic Servo Systems With Valve Dead-Zone Compensation , 2018, IEEE Access.

[20]  Faa-Jeng Lin,et al.  Intelligent Maximum Torque per Ampere Tracking Control of Synchronous Reluctance Motor Using Recurrent Legendre Fuzzy Neural Network , 2019, IEEE Transactions on Power Electronics.

[21]  Hang Zhao,et al.  A Consequent-Pole PM Magnetic-Geared Double-Rotor Machine With Flux-Weakening Ability for Hybrid Electric Vehicle Application , 2019, IEEE Transactions on Magnetics.

[22]  R. Lorenz,et al.  Extending High-Speed Operating Range of Induction Machine Drives Using Deadbeat-Direct Torque and Flux Control With Precise Flux Weakening , 2019, IEEE Transactions on Industry Applications.

[23]  Fang Zheng Peng.  Z-source inverter , 2002 .

[24]  Haitham Abu-Rub,et al.  Modelling and controller design of quasi-Z-source inverter with battery-based photovoltaic power system , 2014 .

[25]  Paolo Mercorelli,et al.  An Adaptive and Optimized Switching Observer for Sensorless Control of an Electromagnetic Valve Actuator in Camless Internal Combustion Engines , 2014 .