Transcriptomic and metabolomic profiling of Zymomonas mobilis during aerobic and anaerobic fermentations

BackgroundZymomonas mobilis ZM4 (ZM4) produces near theoretical yields of ethanol with high specific productivity and recombinant strains are able to ferment both C-5 and C-6 sugars. Z. mobilis performs best under anaerobic conditions, but is an aerotolerant organism. However, the genetic and physiological basis of ZM4's response to various stresses is understood poorly.ResultsIn this study, transcriptomic and metabolomic profiles for ZM4 aerobic and anaerobic fermentations were elucidated by microarray analysis and by high-performance liquid chromatography (HPLC), gas chromatography (GC) and gas chromatography-mass spectrometry (GC-MS) analyses. In the absence of oxygen, ZM4 consumed glucose more rapidly, had a higher growth rate, and ethanol was the major end-product. Greater amounts of other end-products such as acetate, lactate, and acetoin were detected under aerobic conditions and at 26 h there was only 1.7% of the amount of ethanol present aerobically as there was anaerobically. In the early exponential growth phase, significant differences in gene expression were not observed between aerobic and anaerobic conditions via microarray analysis. HPLC and GC analyses revealed minor differences in extracellular metabolite profiles at the corresponding early exponential phase time point.Differences in extracellular metabolite profiles between conditions became greater as the fermentations progressed. GC-MS analysis of stationary phase intracellular metabolites indicated that ZM4 contained lower levels of amino acids such as alanine, valine and lysine, and other metabolites like lactate, ribitol, and 4-hydroxybutanoate under anaerobic conditions relative to aerobic conditions. Stationary phase microarray analysis revealed that 166 genes were significantly differentially expressed by more than two-fold. Transcripts for Entner-Doudoroff (ED) pathway genes (glk, zwf, pgl, pgk, and eno) and gene pdc, encoding a key enzyme leading to ethanol production, were at least 30-fold more abundant under anaerobic conditions in the stationary phase based on quantitative-PCR results. We also identified differentially expressed ZM4 genes predicted by The Institute for Genomic Research (TIGR) that were not predicted in the primary annotation.ConclusionHigh oxygen concentrations present during Z. mobilis fermentations negatively influence fermentation performance. The maximum specific growth rates were not dramatically different between aerobic and anaerobic conditions, yet oxygen did affect the physiology of the cells leading to the buildup of metabolic byproducts that ultimately led to greater differences in transcriptomic profiles in stationary phase.

[1]  Min Zhang,et al.  Metabolic Engineering of a Pentose Metabolism Pathway in Ethanologenic Zymomonas mobilis , 1995, Science.

[2]  F. Bolivar,et al.  Metabolic Engineering of Bacillus subtilis for Ethanol Production: Lactate Dehydrogenase Plays a Key Role in Fermentative Metabolism , 2007, Applied and Environmental Microbiology.

[3]  Joachim Kopka,et al.  Current challenges and developments in GC-MS based metabolite profiling technology. , 2006, Journal of biotechnology.

[4]  Charlotte K. Williams,et al.  The Path Forward for Biofuels and Biomaterials , 2006, Science.

[5]  J. Aguilar,et al.  Differential inactivation of alcohol dehydrogenase isoenzymes in Zymomonas mobilis by oxygen , 1997, Journal of bacteriology.

[6]  P. Valentin‐Hansen,et al.  MicroReview: The bacterial Sm‐like protein Hfq: a key player in RNA transactions , 2004, Molecular microbiology.

[7]  M. Winkler,et al.  Characterization of broadly pleiotropic phenotypes caused by an hfq insertion mutation in Escherichia coli K‐12 , 1994, Molecular microbiology.

[8]  Hyun Seok Park,et al.  The genome sequence of the ethanologenic bacterium Zymomonas mobilis ZM4 , 2005, Nature Biotechnology.

[9]  H. Doelle,et al.  Changes in the growth and enzyme level of Zymomonas mobilis under oxygen-limited conditions at low glucose concentration , 1997, Archives of Microbiology.

[10]  J. DiRuggiero,et al.  Microarray analysis of the hyperthermophilic archaeon Pyrococcus furiosus exposed to gamma irradiation , 2006, Extremophiles.

[11]  J. Senez,et al.  Influence of Aeration and of Pantothenate on Growth Yields of Zymomonas mobilis , 1965, Journal of bacteriology.

[12]  T. Yura,et al.  Sensitization of Escherichia coli cells to oxidative stress by deletion of the rpoH gene, which encodes the heat shock sigma factor , 1992, Journal of bacteriology.

[13]  H W Doelle,et al.  Zymomonas mobilis--science and industrial application. , 1993, Critical reviews in biotechnology.

[14]  L. Pankova,et al.  Regulation of intracellular H+ balance in Zymomonas mobilis 113 during the shift from anaerobic to aerobic conditions , 1988, Applied Microbiology and Biotechnology.

[15]  J. Wylie,et al.  The OprB porin plays a central role in carbohydrate uptake in Pseudomonas aeruginosa , 1995, Journal of bacteriology.

[16]  Sunia A Trauger,et al.  Correlating the Transcriptome, Proteome, and Metabolome in the Environmental Adaptation of a Hyperthermophile , 2022 .

[17]  Marc Reisch,et al.  FUELS OF THE FUTURE: Chemistry and agriculture join to make a new generation of RENEWABLE FUELS , 2006 .

[18]  Masayuki Inui,et al.  Metabolic Engineering of Corynebacterium glutamicum for Fuel Ethanol Production under Oxygen-Deprivation Conditions , 2005, Journal of Molecular Microbiology and Biotechnology.

[19]  Maria I Klapa,et al.  Quantifying the metabolic capabilities of engineered Zymomonas mobilis using linear programming analysis , 2007, Microbial cell factories.

[20]  G. Storz,et al.  Global analysis of small RNA and mRNA targets of Hfq , 2003, Molecular microbiology.

[21]  M. Galbe,et al.  Bio-ethanol--the fuel of tomorrow from the residues of today. , 2006, Trends in biotechnology.

[22]  C. Gross,et al.  Hfq modulates the sigmaE-mediated envelope stress response and the sigma32-mediated cytoplasmic stress response in Escherichia coli. , 2007, Journal of bacteriology.

[23]  C. Gross,et al.  Hfq Modulates the σE-Mediated Envelope Stress Response and the σ32-Mediated Cytoplasmic Stress Response in Escherichia coli , 2006 .

[24]  C. Patten,et al.  Microarray analysis of RpoS-mediated gene expression in Escherichia coli K-12 , 2004, Molecular Genetics and Genomics.

[25]  Hideo Tanaka,et al.  Fermentative ability of Zymomonas mobilis under various oxygen supply conditions in batch culture , 1990 .

[26]  H. Lawford,et al.  Steady-state measurements of lactic acid production in a wild-type and a putative d-lactic acid dehydrogenase-negative mutant of zymomonas mobilis , 2002 .

[27]  P. Rogers,et al.  Zymomonas mobilis CP4: a clarification of strains via plasmid profiles , 1988 .

[28]  Pierre Baldi,et al.  Global Gene Expression Profiling in Escherichia coliK12 , 2002, The Journal of Biological Chemistry.

[29]  Wim Soetaert,et al.  Microbial metabolomics: past, present and future methodologies , 2006, Biotechnology Letters.

[30]  H. Lawford,et al.  Steady-state measurements of lactic acid production in a wild-type and a putative D-lactic acid dehydrogenase-negative mutant of Zymomonas mobilis: influence of glycolytic flux. , 2002, Applied biochemistry and biotechnology.

[31]  Manesh Shah,et al.  Molecular Dynamics of the Shewanella oneidensis Response to Chromate Stress*S , 2006, Molecular & Cellular Proteomics.

[32]  Min Zhang,et al.  Cofermentation of glucose, xylose, and arabinose by genomic DNA-integrated xylose/arabinose fermenting strain of Zymomonas mobilis AX101 , 2002, Applied biochemistry and biotechnology.

[33]  R. Sparling,et al.  Regulation in the rpoS regulon of Escherichia coli. , 1998, Canadian journal of microbiology.

[34]  J Swings,et al.  The biology of Zymomonas , 1977, Bacteriological reviews.

[35]  M. Zhang,et al.  Development of an arabinose-fermenting Zymomonas mobilis strain by metabolic pathway engineering , 1996, Applied and environmental microbiology.

[36]  P. Rogers,et al.  Minimal Medium for Isolation of Auxotrophic Zymomonas Mutants , 1982, Applied and environmental microbiology.

[37]  Uldis Kalnenieks,et al.  NADH dehydrogenase deficiency results in low respiration rate and improved aerobic growth of Zymomonas mobilis. , 2008, Microbiology.

[38]  R. Moreau,et al.  News & Notes: The Effect of Ethanol and Oxygen on the Growth of Zymomonas mobilis and the Levels of Hopanoids and Other Membrane Lipids , 1997, Current Microbiology.

[39]  T. W. Jeffries,et al.  Bacteria engineered for fuel ethanol production: current status , 2003, Applied Microbiology and Biotechnology.

[40]  Weiwen Zhang,et al.  DNA microarray analysis of anaerobic Methanosarcina barkeri reveals responses to heat shock and air exposure , 2006, Journal of Industrial Microbiology and Biotechnology.

[41]  Mamoru Yamada,et al.  Analysis of the Respiratory Chain in Ethanologenic Zymomonas mobilis with a Cyanide-Resistant bd-Type Ubiquinol Oxidase as the Only Terminal Oxidase and Its Possible Physiological Roles , 2007, Journal of Molecular Microbiology and Biotechnology.

[42]  P. Rogers,et al.  Zymomonas mobilis for fuel ethanol and higher value products. , 2007, Advances in biochemical engineering/biotechnology.

[43]  R. Hengge-aronis,et al.  The RNA-binding protein HF-I, known as a host factor for phage Qbeta RNA replication, is essential for rpoS translation in Escherichia coli. , 1996, Genes & development.

[44]  D. Schomburg,et al.  GC–MS libraries for the rapid identification of metabolites in complex biological samples , 2005, FEBS letters.

[45]  H. Williams,et al.  A role for DNA supercoiling in the regulation of the cytochrome bd oxidase of Escherichia coli. , 2001, Microbiology.

[46]  U. Kalnenieks.  Physiology of Zymomonas mobilis: some unanswered questions. , 2006, Advances in microbial physiology.

[47]  G. Storz,et al.  The Sm-like Hfq protein increases OxyS RNA interaction with target mRNAs. , 2002, Molecular cell.

[48]  Hideo Tanaka,et al.  Mechanism of fermentation performance of Zymomonas mobilis under oxygen supply in batch culture , 1990 .

[49]  Jizhong Zhou,et al.  Use of Microarrays with Different Probe Sizes for Monitoring Gene Expression , 2005, Applied and Environmental Microbiology.

[50]  E. Newman,et al.  Leucine-responsive regulatory protein: a global regulator of gene expression in E. coli. , 1995, Annual review of microbiology.

[51]  J. Liu,et al.  Molecular characterization of the Zymomonas mobilis enolase (eno) gene , 1992, Journal of bacteriology.

[52]  A. Khodursky,et al.  Adaptation to famine: A family of stationary-phase genes revealed by microarray analysis , 2002, Proceedings of the National Academy of Sciences of the United States of America.

[53]  T. Jeffries.  Ethanol fermentation on the move , 2005, Nature Biotechnology.

[54]  Andrew D. Jones,et al.  Supporting Online Material for: Ethanol Can Contribute To Energy and Environmental Goals , 2006 .

[55]  J. Liu,et al.  The polycistronic mRNA of the Zymomonas mobilis glf-zwf-edd-glk operon is subject to complex transcript processing , 1992, Journal of bacteriology.

[56]  R. Poole,et al.  Cyanide inhibits respiration yet stimulates aerobic growth of Zymomonas mobilis. , 2000, Microbiology.

[57]  R. K. Finn,et al.  Effect of oxygen on the metabolism of Zymomonas mobilis , 1984, Archives of Microbiology.

[58]  G. W. Hatfield,et al.  Global gene expression profiling in Escherichia coli K12. The effects of integration host factor. , 2000, The Journal of biological chemistry.

[59]  J. Liu,et al.  The Zymomonas mobilis glf, zwf, edd, and glk genes form an operon: localization of the promoter and identification of a conserved sequence in the regulatory region , 1992, Journal of bacteriology.

[60]  S. Koonin.  Getting Serious About Biofuels , 2006, Science.

[61]  A. Ohta,et al.  Biosynthesis of novel acidic phospholipid analogs in Escherichia coli , 1985, Journal of bacteriology.

[62]  Marco Oldiges,et al.  Metabolomics: current state and evolving methodologies and tools , 2007, Applied Microbiology and Biotechnology.

[63]  Roland Eils,et al.  Using gene expression data and network topology to detect substantial pathways, clusters and switches during oxygen deprivation of Escherichia coli , 2007, BMC Bioinformatics.