Effect of Vacuum Annealing on the Properties of Transparent Conductive AZO Thin Films Prepared by DC Magnetron Sputtering

Using highly conductive Al doped ZnO (AZO) ceramic target, (001)-oriented transparent conductive AZO (Al doped ZnO) thin films are prepared by dc planar magnetron sputtering deposition on glass sheet substrates. The structural, electrical, and optical properties of the films (deposited at room temperature and annealed at different temperatures in vacuum) are characterized with various techniques. The experimental results show that electrical resistivity of the as-grown films (not intentionally heated) can be decreased to 10 -4 Ω cm level with post-deposition annealing at 400 °C for 2 h in vacuum pressure of 10 -5 Torr. AZO thin films deposited at room temperature (RT) and subsequently annealed at 450 °C for 2 h in vacuum have nano-crystalline structure with even crystal size distribution. With the increase of annealing temperature, the (002) preferred orientation of AZO thin film grows, the carrier concentration of AZO thin film increases, and the absorption edge in the transmission spectrum shifts toward the shorter wavelength side (blue shift). The oxygen vacancies have played an important role in the improvement of electrical conductivity of these AZO thin films with the vacuum annealing process.

[1]  M. Ohtsu,et al.  Blue shift in room temperature photoluminescence from photo-chemical vapor deposited ZnO films , 2001 .

[2]  E. Fortunato,et al.  Influence of the doping and annealing atmosphere on zinc oxide thin films deposited by spray pyrolysis , 1999 .

[3]  Zhang De-heng,et al.  Optical and electronic properties of transparent conducting ZnO and ZnO:Al films prepared by evaporating method , 1999 .

[4]  K. Ellmer.  Resistivity of polycrystalline zinc oxide films: current status and physical limit , 2001 .

[5]  X. Q. Meng,et al.  Structural, optical and electrical properties of ZnO and ZnO-Al2O3 films prepared by dc magnetron sputtering , 2000 .

[6]  A. Jiménez-González,et al.  Optical and electrical characteristics of aluminum-doped ZnO thin films prepared by solgel technique , 1998 .

[7]  M. Hirohashi,et al.  Influence of oxygen partial pressure on transparency and conductivity of RF sputtered Al-doped ZnO thin films , 2000 .

[8]  G. Fang,et al.  Preparation and Electrochromic Properties of Nanocrystalline WO3 Thin Films Prepared by Pulsed Excimer Laser Ablation Technique , 2001 .

[9]  Jiaping Han,et al.  Effect of Al and Mn doping on the electrical conductivity of ZnO , 2001 .

[10]  G. Exarhos,et al.  Ellipsometric studies of thermally induced transformation phenomena in oxide films , 1997 .

[11]  E. Fortunato,et al.  Influence of the post-treatment on the properties of ZnO thin films , 2001 .

[12]  D. Cameron,et al.  Aluminum-doped zinc oxide transparent conductors deposited by the sol-gel process , 1994 .

[13]  I. Mori,et al.  Transparent ZnO:Al films prepared by co-sputtering of ZnO:Al with either a Zn or an Al target , 1996 .

[14]  T. Miyata,et al.  Transparent conducting impurity-co-doped ZnO:Al thin films prepared by magnetron sputtering , 2001 .

[15]  Takashi Minemoto,et al.  Preparation of Zn1−xMgxO films by radio frequency magnetron sputtering , 2000 .

[16]  Sang Hyuck Bae,et al.  Relationship between photoluminescence and electrical properties of ZnO thin films grown by pulsed laser deposition , 2001 .

[17]  A. Morales-Acevedo,et al.  Influence of post-thermal annealing on the properties of sprayed cadmium–zinc oxide thin films , 2000 .

[18]  T. Minami.  New n-Type Transparent Conducting Oxides , 2000 .

[19]  T. Miyata,et al.  Highly transparent and conductive rare earth-doped ZnO thin films prepared by magnetron sputtering , 2000 .

[20]  T. Sekiguchi,et al.  ZnO thin films prepared by remote plasma-enhanced CVD method , 2000 .

[21]  R. Miles,et al.  Growth and characterization of sprayed ZnO:Ga thin films , 1998 .

[22]  W. Jeong,et al.  Electrical and optical properties of ZnO thin film as a function of deposition parameters , 2001 .

[23]  Chia-Liang Sun,et al.  ZAO: an attractive potential substitute for ITO in flat display panels , 2001 .

[24]  Goro Shimaoka,et al.  Preparation of ZnO thin films for high-resolution field emission display by electron beam evaporation , 1999 .