Analysis of the Flow in Vaneless Diffusers With Large Width-to-Radius Ratios

The flow in vaneless diffusers with large width-to-radius ratios is analyzed by using three-dimensional boundary-layer theory. The variations of the wall shear angle in the layer and the separation radius of the turbulent boundary layer versus various parameters are calculated and compared with experimental data. The effect of the separation point on the performance of vaneless diffusers and the mechanism of rotating stall are discussed. It is concluded that when the flow rate becomes very low, the reverse flow zone on the diffuser walls extends toward the entry region of diffusers. When the rotating jet-wake flow with varying total pressure passes through the reverse flow region near the impeller outlet, rotating stall is generated. The influences of the radius ratio on the reverse flow occurrence as well as on the overall performance are also discussed

[1]  W. Jansen.  Rotating Stall in a Radial Vaneless Diffuser , 1964 .

[2]  Huashu Dou.  A Method of Predicting the Energy Losses in Vaneless Diffusers of Centrifugal Compressors , 1989 .

[3]  W. Jansen.  Steady Fluid Flow in a Radial Vaneless Diffuser , 1964 .

[4]  David Japikse,et al.  Introduction to Turbomachinery , 1994 .

[5]  A. N. Abdelhamid,et al.  Experimental Investigation of Unsteady Phenomena in Vaneless Radial Diffusers , 1979 .

[6]  R. Dean,et al.  Rotating Wakes in Vaneless Diffusers , 1960 .

[7]  J. P. Johnston,et al.  On the Three-Dimensional Turbulent Boundary Layer Generated by Secondary Flow , 1960 .

[8]  I. Ariga,et al.  Transient Process of Rotating Stall in Radial Vaneless Diffusers , 1994 .

[9]  D. L. Whitfield,et al.  Time-Dependent Solution of Three-Dimensional Compressible Turbulent Integral Boundary-Layer Equations , 1985 .

[10]  F. White.  Viscous Fluid Flow , 1974 .

[11]  Yasutoshi Senoo,et al.  Asymmetric Flow in Vaneless Diffusers of Centrifugal Blowers , 1977 .

[12]  C. Rodgers,et al.  Impeller Stalling as Influenced by Diffusion Limitations , 1977 .

[13]  R. Braembussche.  Design and Optimization of Centrifugal Compressors , 1985 .

[14]  N. A. Cumpsty,et al.  The Calculation of Three-Dimensional Turbulent Boundary Layers: Part I: Flow over the Rear of an Infinite Swept Wing , 1967 .

[15]  Y. Senoo,et al.  Limits of Rotating Stall and Stall in Vaneless Diffuser of Centrifugal Compressors , 1978 .

[16]  R. Vandenbraembussche.  Surge and stall in centrifugal compressors , 1984 .

[17]  F. K. Moore.  Theory of Finite Disturbances in a Centrifugal Compression System With a Vaneless Radial Diffuser , 1991 .

[18]  Robert C. Dean,et al.  Losses in Vaneless Diffusers of Centrifugal Compressors and Pumps: Analysis, Experiment, and Design , 1966 .

[19]  Roger L. Simpson,et al.  Perspective: On the Near Wall Similarity of Three-Dimensional Turbulent Boundary Layers (Data Bank Contribution) , 1992 .

[20]  Y. Senoo,et al.  Rotating Stall Induced in Vaneless Diffusers of Very Low Specific Speed Centrifugal Blowers , 1985 .

[21]  E. C. Maskell.  Flow separation in three dimensions , 1955 .

[22]  Huashu Dou.  Investigation of the Prediction of Losses in Radial Vaneless Diffusers , 1991 .

[23]  A. N. Abdelhamid.  Effects of Vaneiess Diffuser Geometry on Flow Instability in Centrifugal Compression Systems , 1981 .

[24]  C. W. Park,et al.  Unstable Flows in the Vaneless Diffuser of a Centrifugal Compressor at Low Flow Rates , 1985 .

[25]  Lawrence F Schumann.  A Three-Dimensional Axisymmetric Calculation Procedure for Turbulent Flows in a Radial Vaneless Diffuser , 1986 .

[26]  R. A. Van den Braembussche,et al.  A Theoretical Model for Rotating Stall in the Vaneless Diffuser of a Centrifugal Compressor , 1985 .

[27]  Hiromu Tsurusaki,et al.  A Study on the Rotating Stall in Vaneless Diffusers of Centrifugal Fans : 2nd Report, An Analysis of Pressure Fluctuations : Series B : Fluid Engineering, Heat Transfer, Combustion, Power, Thermophysical Properties , 1987 .

[28]  Amr N. Abdelhamid.  Analysis of Rotating Stall in Vaneless Diffusers of Centrifugal Compressors , 1980 .

[29]  Y. Senoo,et al.  Behavior of Severely Asymmetric Flow in a Vaneless Diffuser , 1975 .

[30]  Hiromu Tsurusaki,et al.  A Study on the Rotating Stall in Vaneless Diffusers of Centrifugal Fans (1st Report, Rotational Speeds of Stall Cells, Critical Inlet Flow Angle) : Fluids Engineering , 1987 .

[31]  A. N. Abdelhamid,et al.  Distinctions Between Two Types of Self Excited Gas Oscillations in Vaneless Radial Diffusers , 1979 .

[32]  Smith. P.D.,et al.  An integral prediction method for three-dimensional compressible turbulent boundary layers , 1972 .

[33]  E. Greitzer.  The Stability of Pumping Systems—The 1980 Freeman Scholar Lecture , 1981 .