Digital self-calibration method for MEMS sensors

This paper presents a digital self-calibration method for microelectromechanical systems (MEMS) using a relay-feedback loop and a set of discrete-time filters. This method is based on the measurement of limit-cycles at the comparator's output, which result from a synchronization phenomenon between the natural frequency of the MEMS and the clock frequency of the discrete-time components. We show how quantized information concerning the MEMS parameters may be extracted from the shape of the limit-cycle, which depends on the characteristics of the MEMS (pulsation, damping, etc.). This digital technique is amplitude-independent, relatively insensitive to noise, and not costly to implement. Details concerning its implementation are discussed, and some simulation and experimental results are given.

[1]  Gerhard Wachutka,et al.  Sensitivity enhancement of MEMS inertial sensors using negative springs and active control , 2002 .

[2]  F. N. Alavi,et al.  Analysis of parasitic effects in the performance of closed loop micromachined inertial sensors with higher order SD-Modulators , 2001 .

[3]  Ioan Doré Landau,et al.  The autocalibration of PI controllers based on two frequency measurements , 1995 .

[4]  E. Colinet,et al.  Self-calibration method for a sigma-delta micro-accelerometer , 2004, Proceedings of the 21st IEEE Instrumentation and Measurement Technology Conference (IEEE Cat. No.04CH37510).

[5]  Michael Kraft,et al.  Closed Loop Silicon Accelerometers , 1998 .

[6]  S. Guessab,et al.  Resolution Enhancement of a Sigma-Delta Micro-Accelerometer Using Signal Prediction , 2004 .

[7]  Lennart Ljung,et al.  System Identification: Theory for the User , 1987 .

[8]  Robert Hooke,et al.  `` Direct Search'' Solution of Numerical and Statistical Problems , 1961, JACM.

[9]  Bernhard E. Boser,et al.  A three-axis micromachined accelerometer with a CMOS position-sense interface and digital offset-trim electronics , 1999, IEEE J. Solid State Circuits.

[10]  Jan Mehner,et al.  Characterization and self-test of electrostatically tunable resonators for frequency selective vibration measurements , 2004 .

[11]  Farrokh Ayazi,et al.  Micromachined inertial sensors , 1998, Proc. IEEE.

[12]  L. O. Chua,et al.  The effect of integrator leak in Σ-Δ modulation , 1991 .

[13]  Leon O. Chua,et al.  The effect of integrator leak in Sigma - Delta modulation , 1991 .

[14]  I︠a︡. Z. T︠S︡ypkin.  Relay Control Systems , 1985 .